Subscribe to Our Youtube Channel
Related Manuals for Trion Air Boss ATS Series
Summary of Contents for Trion Air Boss ATS Series
- Page 1 Air Boss ATS Series ® READ AND SAVE THESE INSTRUCTIONS Electrostatic Precipitators Commercial & Industrial Applications T R I O N | w w w . t r i o n i a q . c o m ®...
-
Page 2: Table Of Contents
I n s t a l l a t i o n , O p e r a t i o n , & S e r v i c e M a n u a l Electrostatic Precipitators for Commercial & Industrial Applications Air Boss ATS Series ®... -
Page 3: Installation
TRION strongly recommends a fire INSTALLATION WARNING suppression system be installed in the ductwork Precautions must... - Page 4 The drain line is recommended the collectors. These special wires are furnished by to have a clean-out at the end to perform maintenance. TRION. Two power supplies may be required to power a tier of cells. These power supplies will be jumpered Water Supply together in the Control Panel (at the factory).
- Page 5 Service space must be Note: TRION Tridex Detergent is specially provided for periodical manual filling of the detergent tank, formulated for use with TRION electronic air and to gain access to the pump and motor assembly. cleaners. Use of other cleaners and detergents, After positioning, the unit must be secured in place.
-
Page 6: Operation
I n s t a l l a t i o n , O p e r a t i o n , a n d S e r v i c e M a n u a l sections can be built in several widths and heights to O p e ra t i o n accommodate different air flow requirements. - Page 7 I n s t a l l a t i o n , O p e r a t i o n , a n d S e r v i c e M a n u a l The ionizing-collecting cells (contaminate collecting devices.
- Page 8 Operator Devices on the face of the control panel Note: TRION Tridex Detergent is specially allow manual control of the system. formulated for use with TRION electronic air • The illuminated Control Power switch turns ON/ cleaners. Use of other cleaners and detergents, OFF the power for the control panel.
-
Page 9: Initial Startup
I n s t a l l a t i o n , O p e r a t i o n , & S e r v i c e M a n u a l pieces of foreign material are lodged between Kitchen Exhaust Systems the plates. - Page 10 I n s t a l l a t i o n , O p e r a t i o n , & S e r v i c e M a n u a l the volume and counter clockwise decreases the accurate DATE, HOUR, MINUTE.
-
Page 11: Routine Maintenance
If substitutes are used, they must be Condition 2: When timer’s status is OFF, press MANUAL approved by TRION (so as to not void the warranty) and should be safe for use in ventilation systems. key to move indicator from AUTO to ON. Timer status shall turn to ON status, programs overrided. -
Page 12: Troubleshooting
I n s t a l l a t i o n , O p e r a t i o n , a n d S e r v i c e M a n u a l Tr o u b le sh o o t in g WARNING DO NOT USE HIGH PRESSURE CLEANING EQUIPMENT TO... - Page 13 I n s t a l l a t i o n , O p e r a t i o n , a n d S e r v i c e M a n u a l of elimination. A flickering light with an arcing noise is will be indicated in both sections when they an indication of a high resistance short circuit.
-
Page 14: Troubleshooting Chart
I n s t a l l a t i o n , O p e r a t i o n , a n d S e r v i c e M a n u a l Troubleshooting Reference Chart Symptom Probable Cause Correction... -
Page 15: Spare Parts
Recommended spare part quantities are usually based on the unit size and the amount of units per installation. For specific recommendations, consult the TRION factory or nearest Sales Office. Consideration, however, should be given to stocking the following components. Description... - Page 16 TRION ® 101 McNeill Rd. | Sanford, NC 27330 P: 800.884.0002 | F: 800.458.2379 | www.trioniaq.com | customerservice@trioniaq.com Form No. 147207-001 Rev. 09/17 © TRION 2017. All Rights Reserved.
Need help?
Do you have a question about the Air Boss ATS Series and is the answer not in the manual?
Questions and answers