Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Lang CL36GF
Summary of Contents for Lang CL36GF
- Page 1 Installation, Operation, and Maintenance, & Troubleshooting Electric Marine & Cruise Line Griddle Model: CL36GF CL48GF Star Manufacturing International 10 Sunnen Drive St. Louis, MO 63143 Part Number: 2M-W362 Phone: 314-781-2777 Fax: 314-781-2714 Rev. A WWW.STAR-MFG.COM May 16, 2007...
- Page 2 THIS MANUAL MUST BE RETAINED FOR FUTURE REFERENCE. READ, UNDERSTAND AND FOLLOW THE INSTRUCTIONS AND WARNINGS CONTAINED IN THIS MANUAL. FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE.
-
Page 3: Table Of Contents
TABLE OF CONTENTS CHAPTER PAGE 1. TABLE OF CONTENTS ................3 2. READ FIRST ....................4 3. UNPACKING....................6 4. INSTALLATION ................... 7 5. INITIAL START-UP..................9 6. OPERATION....................10 7. MAINTENANCE & CLEANING PROCEDURES........11 8. TROUBLESHOOTING ................. 12 9. -
Page 4: Read First
IMPORTANT READ FIRST IMPORTANT CAUTION: GRIDDLE IS EXTREMELY HEAVY. FOR SAFE HANDLING, INSTALLER SHOULD OBTAIN HELP AS NEEDED, OR EMPLOY APPROPRIATE MATERIALS HANDLING EQUIPMENT (SUCH AS A FORKLIFT, DOLLY, OR PALLET JACK) TO REMOVE THE UNIT FROM THE SKID AND MOVE IT TO THE PLACE OF INSTALLATION. - Page 5 WARNING AND FOLLOW THE DIRECTIONS ON THE LABEL OF THE CLEANER TO BE USED. NOTICE: Service on this, or any other, LANG appliance must be performed by qualified personnel only. Consult your LANG authorized service agent directory or call the factory at 1-800-807-9054, or WWW.STAR-MFG.COM...
-
Page 6: Unpacking
UNPACKING 3.1 Receiving the Griddle Upon receipt, check for freight damage, both visible and concealed. Visible damage should be noted on the freight bill at the time of delivery and signed by the carrier's agent. Concealed loss or damage means loss or damage which does not become apparent until the merchandise has been unpacked. -
Page 7: Installation
INSTALLATION DANGER: THIS APPLIANCE MUST BE GROUNDED AT THE TERMINAL PROVIDED. FAILURE TO GROUND THE APPLIANCE COULD RESULT IN ELECTROCUTION AND DEATH. WARNING: INSTALLATION OF THE UNIT MUST BE DONE BY PERSONNEL QUALIFIED TO WORK WITH ELECTRICITY. IMPROPER INSTALLATION CAN CAUSE INJURY TO PERSONNEL AND/OR DAMAGE TO EQUIPMENT. -
Page 9: Initial Start-Up
INITIAL START UP 5.1 Initial Start Up Before starting the griddle for the first time, clean the griddle body and cooking surface with a mild soap and water solution then rinse with clear water and dry. Set the main power switch, located at the far left of the control panel, to the "ON" (up) position (there are 2 "ON"... -
Page 10: Operation
OPERATION CAUTION: ALWAYS KEEP THE AREA NEAR THE APPLIANCE FREE FROM COMBUSTIBLE MATERIALS. CAUTION: KEEP FLOOR IN FRONT OF EQUIPMENT CLEAN AND DRY. IF SPILLS OCCUR, CLEAN IMMEDIATELY, TO AVOID THE DANGER OF SLIPS OR FALLS. 6.1 Setting the Temperature If different temperature settings across the same griddle are to be used, select one side of the griddle and run that at the lowest temperature. -
Page 11: Maintenance & Cleaning Procedures
MAINTENANCE & CLEANING 7.1 Daily Cleaning WARNING: KEEP WATER AND SOLUTIONS OUT OF CONTROLS. NEVER SPRAY OR HOSE CONTROL CONSOLE, ELECTRICAL CONNECTIONS, ETC. CAUTION: MOST CLEANERS ARE HARMFUL TO THE SKIN, EYES, MUCOUS MEMBRANES AND CLOTHING. PRECAUTIONS SHOULD BE TAKEN TO WEAR RUBBER GLOVES, GOGGLES OR FACE SHIELD AND PROTECTIVE CLOTHING. -
Page 12: Troubleshooting
TROUBLESHOOTING 9.1 Symptoms What follows is a chart of Symptoms and Possible Causes to aid in diagnosing faults with the oven. Refer to the Symptoms column to locate the type of failure then to the Possible Cause for the items to be checked. To test for a possible cause, refer to the TEST section and locate the Possible Cause then refer to test to identify test procedures. - Page 13 TROUBLESHOOTING CONT’D 9.2 TESTS NOTICE: Service on this, or any other, LANG appliance must be performed by qualified personnel only. Consult your LANG authorized service agent directory or call the factory at 1-800-807-9054 or WWW.STAR-MFG.COM For the service agent nearest you.
-
Page 14: Parts Lists
PARTS LIST May 16, 2007, Rev. A CL36GF Electric Marine & Cruise Line Griddle Part No. Description Application 2A-72500-05 LEG 4 W/BOLT DOWN ADJ CL36GF-440V 2D-73800-01 WATER PAN 1/3 HOTEL CL36GF-440V 2E-30500-11 TRM BLOCK 2 PLE LG 175AMP CL36GF-440V 2F-50404-07-1...
Need help?
Do you have a question about the CL36GF and is the answer not in the manual?
Questions and answers