Your Power Chair - Quantum KOZMO Owner's Manual

The Kozmo and the Kozmo Portable
The Kozmo and the Kozmo Portable power chairs have two
main assemblies: the seat assembly and the power base
assembly. Typically, the seat assembly includes the armrests,
seatback, and seat base. The power base assembly includes
the two motors, two drive wheels, two caster wheels, two
anti-tip wheels, two batteries, and a foot platform. See
Kozmo and Kozmo Portable (page 4) and figure 1.
Electrical Components
The electrical components are located on the power base.
The main circuit breaker is located on the front of the battery
box. The controller connector is located on the back of the
power base. See figure 1.
Controller Connector: This is where the controller connects
to the power base. Each controller uses a different type of
cable. Regardless of which type of controller is used, the
cable must be secured to the assembly and not allowed to
drag on the floor.
Battery Box Charger Port: This enables you to charge the
batteries when the battery box is removed from the power
base. See "Batteries and Charging."
Main Circuit Breaker: The main circuit breaker is a safety
feature built into your power chair. When the batteries and the
motors are heavily strained (e.g., from excessive loads), the
main circuit breaker trips to prevent damage to the motors
and the electronics. If the circuit trips, allow your power chair
to "rest" for approximately one minute. Next, push in the
circuit breaker button, turn on the controller, and continue
normal operation. If the main circuit breaker continues to trip
repeatedly, contact a Quantum Rehab Provider.
Manual Freewheel Levers
For your convenience, your power chair has a manual
freewheel lever on each motor. Manual freewheel levers
enable you to disable the drive system in order to maneuver
the chair manually.
WARNING!
Do not use the power chair while the drive motors are
disengaged! Do not disengage the drive motors when
the power chair is on an incline or decline, as the unit
could roll on its own! Only engage the freewheel mode
when on a level surface.
WARNING!
It is important to remember that when your power chair
is in freewheel mode, the braking system is disengaged.
Manual
Seat
Freewheel
Post
Levers
Controller
Connector
Location
Rear
Section
Figure 1. The Kozmo Portable Power Base

YOUR POWER CHAIR

7
Battery
Box
Battery
Charger
Port
Location
Circuit
Breaker
Front
Section