Related Manuals for SystemAir Villavent Combini EC
Summary of Contents for SystemAir Villavent Combini EC
- Page 1 ® Villavent Combini EC Air Handling Unit Installation description 09-01 (02-12-2009)
-
Page 3: Manufacturer
EC Low Voltage Directive Our products are manufactured in compliance with 2006/95/EC applicable international standards and regulations. The following harmonized standards are in use: Systemair AB EN 60 335-1 Industrivägen 3 Electric domestic products and similar – safety- SE-739 30 general requirements. -
Page 4: Table Of Contents
Installation, operation and maintenance manual concerns air handling unit type Combini EC manufactured by Systemair AB. It consists of basic instructions and recommendations concerning the design, installation, start-up and operation, which shall be obeyed to ensure proper and fail-free operation of the unit. -
Page 5: Dimensions And Weight
Dimensions and weight Ø Ø Ø Ø Ø = 125mm Weight: 23kg Pos. Dimension (mm) Pos. Dimension (mm) Fig. 1 _________________________________________________________________________________________________________ Combini EC Installation description 206803 (02-12-2009) Systemair AB... -
Page 6: Component Description
Sensor humidity (hygrostat)* Condensate drain Electrical connection box Fig. 2 * Forces the unit to go to top speed when the relative humidity level in the extract air reaches a certain level. _________________________________________________________________________________________________________ Combini EC Installation description 206803 (02-12-2009) Systemair AB... -
Page 7: Installing The Unit
Recommended installation position for the outdoor air intake is away from openings for discharge of stale ventilation air, kitchen ventilator, central vacuum system, waste water drainage and other pollution sources like exhaust from traffic etc. _________________________________________________________________________________________________________ Combini EC Installation description 206803 (02-12-2009) Systemair AB... -
Page 8: Duct System
Insulation thickness for condensation insulation should be 25 mm, with plastic diffusion barrier. Insulation thickness for heat insulation may be 50 mm, with plastic diffusion barrier. Fig. 6 Note! Remember to cover all joints well with insulation and tape. _________________________________________________________________________________________________________ Combini EC Installation description 206803 (02-12-2009) Systemair AB... -
Page 9: Diffusers/Louvers
Lock by means of centre nut. Air circulation To obtain a satisfactory air circulation in the building, vents or slots must be installed/allowed in or below doors between rooms. Fig. 8 _________________________________________________________________________________________________________ Combini EC Installation description 206803 (02-12-2009) Systemair AB... -
Page 10: Fireplace, Kitchen Ventilator, Tumble Dryer Etc
Installation of condensation drain must be made by authorized plumber. Combini EC is supplied with a 10 mm 90 degree connector for condensate. Drain pipe to be lead via frost proof water lock to drain. (Under kitchen sink to or SVP if unit in loft). _________________________________________________________________________________________________________ Combini EC Installation description 206803 (02-12-2009) Systemair AB... -
Page 11: Electrical Connections
Check the enclosed wiring diagram for more detailed information Position Description Air handling unit Combini EC 3-step speed regulator Control signal connection plug Fig.11 R = Red B = Blue Y = Yellow Fig.12 _________________________________________________________________________________________________________ Combini EC Installation description 206803 (02-12-2009) Systemair AB... -
Page 12: Additional Equipment
( fig.14). The knob, a step-less potentiometer, makes it possible to lower the supply air fan speed down to 75% of the speed of the extract air fan, thereby ensuring the proper balance in the unit and building. Fig.14 _________________________________________________________________________________________________________ Combini EC Installation description 206803 (02-12-2009) Systemair AB... - Page 13 • There is no excessive noise in the unit or in diffusers/louvers in the living areas. In addition to the above items every diffuser/louver should be set to the correct airflow. _________________________________________________________________________________________________________ Combini EC Installation description 206803 (02-12-2009) Systemair AB...
-
Page 14: Equipment List
Villavent extract louvers with frames, Ø125 (Ø100) mm. Villavent inlet diffusers for ceiling or wall installation, with frame, Ø125 (Ø100) mm. Installation material, i.e. tape, screws for Spiro duct, hose clips and installation instructions. _________________________________________________________________________________________________________ Combini EC Installation description 206803 (02-12-2009) Systemair AB... - Page 16 Systemair AB reserves the right to make changes and improvements to the contents of this manual without prior notice. Systemair AB Industrivägen 3 SE-739 30 Skinnskatteberg, Sweden Phone +46 222 440 00 Fax +46 222 440 99 www.systemair.com For UK: www.villavent.co.uk...