Every 400 Hours; Replacing Fuel Filter; Every 1 Year; Replacing Air Cleaner Element - Kubota GR2000 Operator's Manual

EVERY 400 HOURS
.Replacing Fuel Filter
Change fuel filter every 400 hours. This should be done by
your KUBOTA Dealer.
EVERY 1 YEAR
.Replacing Air Cleaner Element
[GR21 00]
Change the element once a year.
• Flush Cooling System and Changing
Coolant
[GR2100]
A
CAUTION
To avoid personal injury:
• Do not remove the radiator cap when the
engine is hot. Then loosen cap slightly to the
stop to relieve any excess pressure before
removing cap completely.
1. Stop the engine and let cool down.
2. To drain the coolant, remove the clamp and the hose,
and remove radiator cap. The radiator cap must be
removed to completely drain the coolant.
3. After all coolant is drained, install the hose with the
clamp.
4. Fill with clean water and cooling system cleaner.
5. Follow directions of the cleaner instruction.
6. After flushing, fill with clean water and anti-freeze until
the coolant level is just below the fill port on the
radiator.
Install the radiator cap securely.
7. Fill with coolant up to the "FULL" mark on the recovery
tank.
8. Start and operate the engine for a few minutes.
9. Stop the engine and let cool.
10. Check coolant level of recovery tank and add coolant
if necessary.
(1) Clamp
(2) Recovery tank
(3) Recovery tank cap
IMPORTANT:
PERIODIC SERVICE 63
(A) "FULL"
(B) "LOW"
• Do not start engine without coolant.
• Use clean, distilled water and anti-freeze to fill the
radiator and recovery tank.
• When the anti-freeze is mixed with water, the anti-
freeze mixing ratio must be less than 50%.
• Securely tighten radiator cap. If the cap is loose or
improperly fitted, water may leak out and the engine
could overheat.