Table of Contents
Advertisement
7 Maintenance
Personnel:
n
Operator
Qualified personnel
n
Protective equipment:
n
Protective clothing
n
Light respiratory protection
n
Safety goggles
n
Protective gloves
n
Safety shoes
Spare parts
WARNING!
Risk of injury through the use of incorrect spare parts!
The use of incorrect or defective spare parts can cause hazards for the personnel as well as
damage, malfunctions or complete failure.
–
Only use OEM parts from Krautzberger or Krautzberger-approved spare parts.
–
In case of questions, always contact our Customer Care department.
7.1
Maintenance schedule
Maintenance intervals depend on the operating mode and the ambient conditions. It is therefore
not possible to stipulate these intervals; they must be determined during the operation of the unit.
The time intervals listed in the following must not be exceeded.
Interval
when necessary
during operation
after each use
monthly
GB–20
Operating instructions
Maintenance work
Clean housing of compressed-air motor
Disassembling and assembling transmission
and compressed-air motor (
assembling and assembling gear box and com-
pressed-air motor' on page 22
Pay attention to unusual noises or vibrations
Ä Chapter 7.2 'Cleaning'
Clean agitator (
on page 21)
Check screw connections for a tight fit
Check screw connections of agitator unit-shaft,
shaft-agitator, shaft-coupling and coupling-
bearing for a tight fit.
Ä Chapter 7.4 'Dis-
mail@krautzberger.com, www.krautzberger.com
T-Dok-031-GB-Rev.4
Personnel
Operator
Qualified personnel
Operator
Operator
Operator
Operator
Advertisement
Table of Contents
