Marantz AV8003 Service Manual
  1. Manuals
  2. Brands
  3. Marantz Manuals
  4. Tuner
  5. AV8003
  6. Service manual

Marantz AV8003 Service Manual

Av pre tuner
Hide thumbs Also See for AV8003:
Table of Contents

Advertisement

Quick Links

Service
Manual
SECTION
1. TECHNICAL SPECIFICATIONS ........................................................................................... 1
2. TECHNICAL DESCRIPTION ................................................................................................ 9
3. SERVICE MODE ................................................................................................................. 15
4. SYSTEM ERROR ............................................................................................................... 17
5. DUAL BACKUP MEMORY .................................................................................................. 21
6. UPDATE FIRMWARE .......................................................................................................... 22
Mode 2 : Update/Download DSP's software to Flash-ROM ........................................... 30
Mode 5 : Update/Download HD Radio Module's software ............................................. 48
7. WIRING DIAGRAM ............................................................................................................. 61
8. BLOCK DIAGRAM .............................................................................................................. 63
9. SCHEMATIC DIAGRAM ...................................................................................................... 67
10. PARTS LOCATION ............................................................................................................ 101
11. EXPLODED VIEW AND PARTS LIST ............................................................................... 135
12. MICROPROCESSOR AND IC DATA ................................................................................ 139
13. ELECTRICAL PARTS LIST ............................................................................................... 183
14. ABOUT REPLACE THE MICROPROCESSOR WITH A NEW ONE ............................. 255
Please use this service manual with referring to the user guide ( D.F.U. ) without fail.
PURE DIRECT
M-DAX
INPUT
SELECTOR
SURROUND
ZONE
AUTO
ZONE
MODE
SPEAKER
PURE
7.1CH
THX
STANDBY
DIRECT
INPUT
POWER ON/OFF
PHONES
SETUP MIC

TABLE OF CONTENTS

AV8003
AV8003 /
AV PRE TUNER AV8003
UP
HDMI
DOWN
VOLUME
MENU
EXIT
BAND
T-MODE
MEMORY
CLEAR
TOP
M-DAX
DISPLAY
ENTER
F B/K1B/N1B/U1B
AV Pre Tuner
PAGE
Part no. 90M46CW855000
First Issue 2008 05
MZ

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the AV8003 and is the answer not in the manual?

Questions and answers

Related Manuals for Marantz AV8003

Summary of Contents for Marantz AV8003

  • Page 1: Table Of Contents

    Service AV8003 / F B/K1B/N1B/U1B Manual AV Pre Tuner AV PRE TUNER AV8003 PURE DIRECT HDMI M-DAX DOWN INPUT VOLUME SELECTOR SURROUND ZONE AUTO ZONE MENU EXIT BAND T-MODE MEMORY CLEAR MODE SPEAKER PURE 7.1CH M-DAX DISPLAY STANDBY DIRECT INPUT...
  • Page 2 MARANTZ Parts for your equipment are generally available to our National Marantz Subsidiary or Agent. ORDERING PARTS : Parts can be ordered either by mail or by Fax.. In both cases, the correct part number has to be specified.

  • Page 3: Technical Specifications

    AM Loop Antenna for HD Radio ........1 [ /U ] AC cable ................1 USB cable ................1 AV8003 User Guide ..............1 AV8003 NETWORK User Guide ..........1 Wizz.it3 User Guide ..........1 [ /N/U ] 17-5/16 ins. (440 mm) AV PRE TUNER AV8003...
  • Page 4 Surround Mode This unit is equipped with many surround modes. These are provided to reproduce a variety of surround sound effects, according to the content of the source to be played. The available surround modes may be restricted depending on the input signal and speaker setup. The relationship between the selected surround mode and the input signal The surround mode is selected with the surround mode selector on the unit or the remote controller.
  • Page 5 Output Channel Front information display Surround Mode Input Signal Decoding SubW Signal format indicators Channel status DOLBY Dolby Surr.EX Dolby Digital EX 2 DIGITAL EX L, C, R, SL, SR, S, LFE (PLIIx movie) Dolby D (5.1ch) Dolby Digital 5.1 2 DIGITAL L, C, R, SL, SR, LFE (PLIIx music)
  • Page 6 Output Channel Front information display Surround Mode Input Signal Decoding SubW Signal format indicators Channel status Multi Ch. DTS-ES DTS-ES dts, ES L, C, R, SL, SR, S, LFE Movie DTS 96/24 DTS-96/24 dts 96/24 L, C, R, SL, SR, LFE Music DTS (5.1ch) DTS 5.1...
  • Page 7 AUTO eX/eS When this mode is selected, the unit determines This mode provides 6.1 channel surround for Dolby whether the digital input signal is Dolby Digital, Digital EX, and DTS-ES-encoded source material Dolby Digital Surround EX, Dolby Digital Plus, Dolby such as DVD.
  • Page 8 Dolby mODe dts, Neo:6 Cinema, Neo:6 Music (Dolby Digital, Pro Logic IIx MOVIE, Pro Logic IIx This mode is for DTS-encoded source materials MUSIC, Pro Logic IIx GAME) such as laserdisc, CD and DVD. Neo:6 is for some 2 This mode is used with source materials encoded in channel sources.
  • Page 9 STereO THX Surround EX will operate for any 5.1 channel source whenever THX is active. This mode bypasses all surround processing. THX Surround EX is not available in system without In stereo program sources, the left and right channels surround back speaker(s). play normally when PCM audio or analog stereo is input.
  • Page 10 THX GAmeS cAUTIOn For the replay of stereo and multichannel game note for dTS audio the THX Games mode should be selected. • To connected DVD player, laserdisc player or CD In this mode, THX ASA processing is applied to player needs to support DTS digital output.

  • Page 11: Technical Description

    Comp Adaptive Decorrelation-slightly changes one surround web site at www.dolby.com. A list of available DVD menu” channel’s time and phase relationship with respect to software titles encoded with this technology an be the other surround channel. found at www.thx.com. AV8003̲U̲Eng.indb   101...
  • Page 12 Ultra2 as bellow. This product is manufactured under license from a small Neural Audio Corporation and THX Ltd. Marantz A.S.A. (Advanced Speaker Array) hereby grants the user a non-exclusive, non- “ASA” is a proprietary THX technology which transferable, limited right of use to this product...
  • Page 13 Extended Surround includes two signal formats with music, exactly as the artist intended: clear, pure, and Pro Lo different surround signal recording methods, as DTS- uncompromised. encod ES Discrete 6.1 and DTS-ES Matrix 6.1. Logic surrou with co AV8003̲U̲Eng.indb   102...
  • Page 14 Manufactured under license under U.S. Patent Dolby Digital EX creates six full-bandwidth output #’s: 5,451,942; 5,956,674; 5,974,380;5,978,762; channels from 5.1-channel sources. This is done ling at 6,226,616; 6,487,535 & other U.S. and worldwide using a matrix decoder that derives three surround or 24- patents issued &...
  • Page 15 (TruBass). CS-II can enable the dialog loudspeaker placement and acoustical treatments, to become clearer and more discernable in movies there are significant problems that are caused by and it enables the bass frequencies contained in the room acoustics. These include refl ections from nearby AV8003̲U̲Eng.indb   103...
  • Page 16 ENGLISH ve low surfaces and standing waves that are created between large parallel surfaces in the room. In a home theater ations the situation is further complicated because there are several listening locations. The effects of room acoustics on the sound arriving at each person’s ears are very ol are different and the result is a listening experience that is DLNA CERTIFIED™...

  • Page 17: Service Mode

    3. SERVICE MODE 3. SERVICE MODE MAIN CPU Version, DSP Version, HDMI CPU Version, HD MAIN CPU Version, DSP Version, HDMI CPU Version, HD Radio Version, HD Radio module Firmware Version, DMP Radio Version, HD Radio module Firmware Version, DMP Sub CPU Version, DMP module Firmware Version and Sub CPU Version, DMP module Firmware Version and Segment Check Mode.
  • Page 18 電源が入っていることを確認します。 reset the unit with the following procedure. 本機の ボタンを押しながら、 ボタンを 秒以上 To turn on the AV8003, press and hold the ZONE and ZONE 押します。 TOP buttons simultaneously for 3 seconds or more. 本機は一度スタンバイ状態になった後、再度 − Remember that the procedure will reset the settings of POWER 状態となり、各種設定された内容が初期化され、工場出荷時の...

  • Page 19: System Error

    4. SYSTEM ERROR 4. SYSTEM ERROR Check 1 Check 1 異常検出 • EEP-ROM (DSP PWB / IC15) Interface • Indication of abnormalities with the EEP-ROM (DSP との通信で が帰って PWB / IC15) Interface EEP-ROM (DSP PWB / IC15) こない状態（通信エラー）が約２秒以上生じた場合 This indicates a communication error wherein the ACK に下記の様な表示がされます。...
  • Page 20 Check 3 Check 3 電源 時に製品が通常動作を開始するためには、下図の様な For the product to start operating normally when the power で の各入 is turned on, the circuit connected to each input port of _P Timing _P DOWN, _P LINE FAIL, __5V_DOWN 力 で接続されている回路が正常動作している必要がありま DOWN, _P LINE FAIL and 5V_DOWN needs to be operating Port す。...
  • Page 21 電源 時の異常検出動作 Abnormal detection operation when the power is turned 電源立ち上げ：異常時 ：①（ ）で または _STAND BY(OUT) 3.5 sec _P_LINE_FAIL 200 msec が を検出したら、 を以後 にする 5V_DOWN _STAND BY ①（ ） _STANDBY (OUT): If it detects of 3.5 sec And Lo is detected of _P_LINE_FAIL or 5V_DOWN, 3.5 sec it will be made L after that.
  • Page 22 Check 4 Check 4 HD Radio Error Detection ( /U1B のみ ) HD Radio Error Detection (/u1B only) Reason Check points Error Detection 6V power supply CN92, IC61, BN92 "CPU <-> HDR" Main-CPU to 5V power supply IC94 on the FL DISPLAY HD Radio-CPU communication fail HD Radio-CPU IC91, X901 etc.

  • Page 23: Dual Backup Memory

    5. DUAL BACKUP MEMORY 5. DUAL BACKUP MEMORY 本機は 機能を持っています｡ This product has a Dual Backup Memory function. The Dual Backup Memory 通常の は製品の主電源が切られた時に､その時の状態を conventional Backup functions to memorize, in the EEP- Backup 回路上の に して､電源が された時 ROM in the circuit, a current setting of the moment the EEP-Rom (IC15) Memory にその状態を復帰させますが､...

  • Page 24: Update Firmware

    6. UPDATE FIRMWARE 6. UPDATE FIRMWARE WRITING AND UPDATE SOFTWARE WRITING AND UPDATE SOFTWARE マイコン、 のフラッシュ 、 マイコ Software for MAIN CPU, flash ROM for DSP, HDMI CPU, HD MAIN HDMI ン、 マイコン、 モジュールファームウェ HD Radio HD Radio Radio CPU, HD Radio Module firmware and DMP Sub CPU ア、および...
  • Page 25 書き込みにかかる時間は約１分です。 The updating of software takes about 1 minute. •Mode 6: Update/Download DMP Sub CPU's software to • Mode 6: Update/Download DMP Sub CPU's software to internal Flash-ROM. internal Flash-ROM. このモードは マイコンの更新および書き込み用で DMP Sub This mode is to update/download the software for DMP す。...

  • Page 26: Mode 1: Update/Download Main Cpu's Software To Internal Flash-Rom

    Flash-ROM internal Flash-ROM Update/Download software for MAIN CPU (Mode 1) Update/Download software for MAIN CPU (Mode 1) フォルダを の任意のフォルダにコピー Put the "main (AV8003)" folder into anywhere on your "main (AV8003)" します。 PC's hard disc. 本機のリアパネルにある コネクタと Connect RS-232C on the rear panel of the unit and...
  • Page 27 をクリックします。 Select Click the Select. を選択し、 をクリックしま Choose the av8003_yymmddv.rom. And Click the Open. av8003_yymmddv.rom Open す。 NOTE : The yy is two digits of year. The mm is month. The 注意 は年の下二桁、 は月、 は日、 はリリース番号 dd is date. The v is release number. : yy...
  • Page 28 に を入力します。 AV8003 Input the AV8003 in the Model ID. Model ID 使用する ポート番号を選択します。 Choose the COM Port number. から を選択します。 Choose the 9600 in the Speed. Speed 9600 をクリックします。 And click the Change Mode. Change Mode 本機の ディスプレイに The FLD of the unit alternately displays "UPDATE UPDATE MODE と...
  • Page 29 に が入力されます。 02.00 is inputted into the Boot Version automatically. Boot Version 02.00 マイコンに接続ができた場合、 が有効にな If the connection with the Main CPU is successfully MAIN Update! ります。 made, the Update becomes active. 接続に失敗した場合は、エラーメッセージが表示されま If the connection fails, error message will appear. す。（各接続を確認してください。）...
  • Page 30 マイコンにソフトウェアの書き込みが開始されま Software is written into the MAIN CPU. MAIN す。 The writing of software takes about 3 minutes. 書き込みにかかる時間は約 分です。 At that time, the unit keeps displaying "CONNECTING" このとき、本機の ディスプレイに を "CONNECTING" between a few seconds. 、 秒表示した後、 と "UPDATE1 ?%" "UPDATE MODE"...
  • Page 31 をクリックしアプリケーションを閉じます。 Click the X to close the application. ボタンを押して本機の電源 POWER ON/OFF (STANDBY) button for turn POWER ON/OFF (STANDBY) Press the を切ります。 を除く off the unit. (Except /F B, /U1B) (/F B, /U1B 本機から電源ケーブルを外します。 Disconnect the mains cord. 本機から ケーブルを外します。 Disconnect the RS-232C cable from the unit. RS-232C...

  • Page 32: Mode 2 : Update/Download Dsp's Software To Flash-Rom

    Update/Download Software for DSP (Mode 2) Update/Download Software for DSP (Mode 2) フォルダを の任意のフォルダにコ "TI_DSP (AV8003)" Put the "TI_DSP (AV8003)" folder into anywhere on your ピーします。 PC's hard disc. 本機のリアパネルにある コネクタと Connect the RS-232C on rear panel of the unit and the...
  • Page 33 をダブルクリックし、 Double click the da708_writer.exe. And launch the da708_writer.exe SR8001 TI Writer を起動します。 SR8001 TI Writer. 使用する ポート番号を選択します。 COM Port number. Choose the...
  • Page 34 をクリックします。 Connect Click the Connect. 上に と表示された "Connection OK!!" appears on SR8001 TI Writer. And SR8001 TI Writer "Connection OK!!" ら、 をクリックします。 click the FileOpen. FileOpen...
  • Page 35 を選択し、 をクリックし Open Choose the pa17_c78_yymmdd_v.upd. And click the pa17_c78_yymmdd_v.upd ます。 Open. 注意 は年の下二桁、 は月、 は日、 はリリース番号 NOTE : The yy is two digits of year. The mm is month. The : yy dd is date. The v is release number. をクリックします。...
  • Page 36 ソフトウェアが フラッシュ に書き込まれます。 Software is written into the DSP Flash ROM. 書き込みにかかる時間は約 分 秒です。 The writing of software takes about 6 minutes and 30 seconds. Click the をクリックします。 Discon. Click the をクリックします。 Discon...
  • Page 37 をクリックします。 Exit Click the Exit. ボタンを押し、本機の電源 Press the POWER ON/OFF (STANDBY) button for turn POWER ON/OFF (STANDBY) を切ります。 を除く off the unit. (Except /F B, /U1B) (/F B, /U1B 本機から電源コードを外します。 Disconnect the mains cord. 本機から ケーブルを外します。 Disconnect the RS-232C cable from the unit. RS-232C...

  • Page 38: Mode 3 : Update/Download Hdmi Cpu's Software To Internal Flash-Rom

    Mode 3 : Update/Download HDMI CPU's software to Mode 3 : Update/Download HDMI CPU's software to internal Flash-ROM. internal Flash-ROM. Update/Download Software for HDMI CPU (Mode 3) Update/Download Software for HDMI CPU (Mode 3) フォルダを の任意のフォルダにコピーします。 "HDMI" Put the "HDMI" folder into anywhere on your PC's hard disc.
  • Page 39 をダブルクリックし、 を起動し Double click the wr36049.exe. And Launch the 36049 wr36049.exe 36049 Write ます。 Write. 使用する ポート番号を選択します。 COM Port number. Choose the をクリックします。 Click the (browse). (browse)
  • Page 40 を選択し、 をクリ Open Choose the HDMI_REPV4_yymmdd_hvv.upd. And click HDMI_REPV4_yymmdd_hvv.upd ックします。 the Open. 注意 は年の下二桁、 は月、 は日、 はリリース番号 NOTE : The yy is two digits of year. The mm is month. The : yy dd is date. The vv is release number. をクリックします。...
  • Page 41 をクリックします。 Exit Click the Exit. ボタンを押し、本機の電源 POWER ON/OFF (STANDBY) button for turn POWER ON/OFF (STANDBY) Press the を切ります。 を除く off the unit. (Except /F B, /U1B) (/F B, /U1B 本機から電源コードを外します。 Disconnect the mains cord. 本機から ケーブルを外します。 Disconnect the RS-232C cable from the unit. RS-232C...

  • Page 42: Mode 4 : Update/Download Hd Radio Cpu's Software To Internal Flash-Rom

    Update/Download Software for HD Radio CPU (Mode 4) (/U1B only) (/U1B only) フォルダを の任意のフォルダにコ "HDRadio (AV8003)" Put the "HDRadio (AV8003)" folder into anywhere on ピーします。 your PC's hard disc. 本機のリアパネルにある コネクタと Connect the RS-232C on rear panel of the unit and the...
  • Page 43 フォルダ内の フォルダをダブルクリ HDRadio CPU (R8C) Double click the CPU (R8C) folder in the HDRadio ックします。 (AV8003) folder. をダブルクリックし、 を起 Double click the FlashSta.exe. And launch the M16 FlashSta.exe M16 Flash Start 動します。 Flash Start.
  • Page 44 の にチェックをし Internal flash memory in the Select Select Program Internal flash memory Check the て下さい。 Program. 使用する ポート番号を選択します。 Choose the COM Port number. をクリックします。 And click the OK. をクリックします。 Click the Refer..Refer...
  • Page 45 を選択し、 をクリック Open Choose the SR8002_HdrVyymmdd.mot. And click the SR8002_HdrVyymmdd.mot します。 Open. 注意 は年の下二桁、 は月、 は日 NOTE : The yy is two digits of year. The mm is month. The : yy dd is date. と は自動的に記入され、 は が選 The FilePath and ID are inputted automatically, and the FilePath MCU Type ばれます。...
  • Page 46 をクリックします。 Setting..Setting... Click the から を選択します。 他の設定値は選ばな 57600 in the Baud rate. (DO NOT choose 57600 Choose the Baud rate いで下さい。 the other one.) を にします Choose the 40 in Program_intervals(ms). Program_intervals(ms) をクリックします。 Click the OK.
  • Page 47 をクリックします。 18. E.P.R... Click the E.P.R..をクリックします。 Click the 19. OK...
  • Page 48 ソフトウェアが の内部フラッシュ に書 Software is written into the internal Flash-ROM of HD HD Radio CPU き込まれます。 Radio CPU. 書き込みにかかる時間は約 秒です。 The writing of software takes about 20 seconds. をクリックします。 21. OK Click the...
  • Page 49 をクリックします。 Exit. Exit Click the 本機から電源コードを外します。 Disconnect the mains cord. 本機から ケーブルを抜きます Disconnect the RS-232C cable from the unit. RS-232C...

  • Page 50: Mode 5 : Update/Download Hd Radio Module's Software

    Update/Download Software for HD Radio Module (Mode 5) Update/Download Software for HD Radio Module (Mode 5) (/U1B only) (/U1B only) の任意のフォルダにコ HDRadio (AV8003) Put the "HDRadio (AV8003)" folder into anywhere on " "フォルダを ピーします。 your PC's hard disc. 本機のリアパネルにある コネクタと...
  • Page 51 をダブルクリック Double click the HDR_SFirmware_00_1.exe. And launch HDR_SFirmware_00_1.exe し、 を起動します。 the SAMSUNG HDR Firmware upgrade. SAMSUNG HDR Firmware Upgrade 使用する ポート番号を選択します。 COM Port number. Choose the...
  • Page 52 をクリックします。 Click the (browse). (browse) を選択し、 をクリック Choose the HDRadioS_00BU_vv_xx.hex. And click the HDRadioS_00BU_vv_xx.hex Open します。 Open. 注意 はメジャー改版番号、 はマイナー改版番号 NOTE : The vv is major revision number. The xx is minor : vv revision number.
  • Page 53 をクリックします。 START Click the START. コマンドラインに が表示 Check the "Ready to enter upgrade mode" appear on "Ready to enter upgrade mode" されたことを確認します。 the command line. の つボタンを同 ENTER, SURROUND MODE and T-MODE ENTER , SURROUND MODE, T-MODE Press the 時に 秒以上押し続け、本機をローディングモードにしま...
  • Page 54 に と表示され、ソフトウェアが "SELECTED HDRM" shows on the FLD. And then " SELECTED HDRM" モジュールに書き込まれます。 software is written into the HD Radio module. HD Radio 書き込みにかかる時間は約 分です。 The writing of software takes about 1 minute. コマンドラインに が表示されたことを確 Check the "Exit bootloader" appear on the command "Exit bootloader"...

  • Page 55: Mode 6 : Update/Download Dmp Sub Cpu's Software To Internal Flash-Rom

    Update/Download Software for DMP Sub CPU (Mode 6) Update/Download Software for DMP Sub CPU (Mode 6) フォルダを の任意のフォルダにコ "DMPSub (AV8003)" Put the "DMPSub (AV8003)" folder into anywhere on ピーします。 your PC's hard disc. 本機のリアパネルにある コネクタと Connect the RS-232C on rear panel of the unit and the...
  • Page 56 をダブルクリックし、 を起 Double click the FlashSta.exe. And launch the M16 FlashSta.exe M16 Flash Start 動します。 Flash Start. の にチェックをし Check the Internal flash memory in the Select Select Program Internal flash memory て下さい。 Program. 使用する ポート番号を選択します。 Choose the COM Port number. をクリックします。...
  • Page 57 をクリックします。 Refer... Click the Refer..を選択し、 をクリック Choose the DMP_Sub_yymmddvv.mot. And click the SR8002_HdrVyymmdd.mot Open します。 Open. 注意 は年の下二桁、 は月、 は日、 はリリース番号 NOTE : The yy is two digits of year. The mm is month. The : yy dd is date. The vv is release number.
  • Page 58 と は自動的に記入され、 は が選 The FilePath and ID are inputted automatically, and the FilePath MCU Type ばれます。 MCU Type is selected to R8C automatically. をクリックします。 Click the OK. をクリックします。 Click the Setting..Setting...
  • Page 59 から を選択します。 他の設定値は選ばな 57600 57600 Choose the in the Baud rate. (DO NOT choose Baud rate いで下さい。 the other one.) を にします Program_intervals(ms) Choose the in Program_intervals(ms). をクリックします。 Click the OK. をクリックします。 E.P.R..E.P.R... Click the...
  • Page 60 をクリックします。 Click the ソフトウェアが の内部フラッシュ に DMP Sub CPU Software is written into the internal Flash-ROM of DMP 書き込まれます。 Sub CPU. 書き込みにかかる時間は約 秒です。 The writing of software takes about 20 seconds. をクリックします。 Click the...
  • Page 61 をクリックします。 Exit Click the Exit. 本機から電源コードを外します。 Disconnect the mains cord. 本機から ケーブルを抜きます。 Disconnect the RS-232C cable from the unit. RS-232C...
  • Page 62 Personal notes:...

  • Page 63: Wiring Diagram

    7. WIRING DIAGRAM Pb/Pr/Y COMPONENT PWB CN34 7P CUP12074 DMP 2.0mm DMP PWB MODULE CN33 11P HDMI FFC 1.0mm CN41 17P CN36 2P VIDEO VIDEO FFC 1.0mm VIDEO 2.0mm CN42 11P VIDEO& COMPONENT MAIN TRANS 2.0mm CN2601 9P CN2904 2P CN2903 3P ST-BY ST-BY 2.0mm...

  • Page 64: Block Diagram

    8. BLOCK DIAGRAM TO FUNCTION SEL PRE OUT-B PART PRE OUT-T PART TUNER L/R INPUT & VOLUME PART TUNER MODULE DMP L/R (SURR.B L/B, CNT, S/W CH) (FRONT L/R, SURR. L/R) (N/K/F VER. ONLY) HEAD PHONE SATELLITE L/R TUNER CONT OP-AMP (U VER.
  • Page 65 FROM BLOCK DIA. -1/2 DMP-CVBS VIDEO PART NJM2595 +6dB X 3 VCR2 VCR1 CVBS-OUT VIDEO CONVERTER & SCALER & HDMI PART VCR2/DSS NETWORK Y-OUT VCR1 C-OUT CONT NJM2595 +6dB X 3 VCR2 CVBS-IN VCR1 NETWORK TV AUTO u-COM CONT V_IIC RST_SC V_IIC RST_ENC...

  • Page 66: Schematic Diagram

    9. SCHEMATIC DIAGRAM VIDEO PWB IC91 IC92 MC7905C KA7908A D708 D709 D710 1N4003 L702 1N4003 1N4003 1.-15V 10uH +5VL 2.GND SE-VIDEO[01:06] 3.+15V 4.+5VV Q701 HVTKTA1267YT 5.+5VV C742 C743 DET-V[01:06] 6.GND 50V/10u JUMMPER 7.GND C744 D702 Q702 8.+5VL KRA102MT CV_MULTI_BYPASS C814 50V/2.2u 1SS133 TV_AUTO...
  • Page 67 COMPONENT PWB C901 Y-INPUT00 IC91 Y-CB-CR-INPUT HVINJM2584MTE1 1/50V R904 R905 C902 Y-INPUT01 Q851 C851 KTC4075 1/50V 10/16V C909 CLAMP 47/25V Y-INPUT00 C903 R961 CB-INPUT00 FROM DMP PWB 1/50V C910 0.01u CN34 JK91 C911 47/25V R962 1.DMP_Pb +5VV BIAS Y-IN00 C912 0.01u 2.GND C852 Q852...
  • Page 68 D133 HDMI PWB -1/5 1SS378 V+5V V+5V C105 IC12 AT24C02N R140 Q110 KRA102S Q113 KRC103S Q111 KRC103S WP_4 Q112 HP_4 UPA672T A2 SCL IC13 TC7MZ4052FK R141 R132 HP DET HDMI_SCL C104 R133 HDMI_SDA R134 DDC DATA R135 DDCDATA1 DDC CLK R136 DDCCLK1 CE REMOTE...
  • Page 69 HDMI PWB -2/5 FROM VIDEO DEC/ENC BLOCK FROM HDMI PWB -4/5 FROM HDMI PWB -4/5 FROM HDMI PWB -4/5 L316 R402 9R005Z V+1.8V3 V+1.8V3 L318 10uH 6.8K L319 10uH L317 V+3.3V2 L320 10uH 9R005Z L321 V+3.3V2 C401 CVCC18 R397 OPEN 10uH CI2CA HD_D18...
  • Page 70 HDMI PWB -3/5 C601 10/50 V+3.3V2 R628 V_CLK_IP C677 R627 V_CLK_ENC OSD-IN C602 V-GND 10/50 T602 Y-IN IC72 C603 V-GND X601 TC74VHC08AFT V+3.3V4 10/50 28.636MHz VD_+1.8VPLL R705 OPEN R630 L601 C624 R706 OPEN T604 9R005Z Y_OSD V-GND VD_+3.3VA 0.082 R648 OPEN R642 OPEN C625...
  • Page 71 HDMI PWB -4/5 FROM HDMI PWB -3/5 FROM VIDEO DEC,ENC,I/P BLOCK L501 9R005Z L502 V+1.8V6 9R005Z L503 V+3.3_SC 9R005Z RESET_SC R507 R506 V_SCL V+3.3_SC R505 V_SDA C520 0.1 FOR ABT1010 (I/O_VDD) CORE_VDD I/O_VSS 72.IN_Y[2] 54.CORE_VDD C510 0.1 C521 0.1 CORE_VSS 73.IN_Y[3] 53.IN_VSN I/O_VDD...
  • Page 72 HDMI PWB -5/5 V+8V IC91 IC90 IC88 FOR VIDEO KIA7808AF NCP1117ADJ NCP1117ADJ +15V V+1.8V1 V+5VA FOR SII9135 (AVCC,DVCC) R920 6.8K R919 6.8K T901 T902 UP+5V V+5V R891 AUX_RXD UP+5V R892 AUX_TXD R922 IC92 IC95 NCP1117ADJ NCP1117ADJ R923 T904 D901 R924 R915 1N4003 V+1.8V2...
  • Page 73 INPUT PWB FROM DMP PWB FROM DSP PWB -1/2 TO DSP PWB -2/2 3P-2.0MM-WIRE 3P-2.0MM-WIRE 3P-2.5MM-WIRE BN73 BN86 BN77 BN87 COM[00:19] ANA[00:33] PRE-FL COM[00:19] C349 GAIN-OUT08 ANA23 22/25V C351 GAIN-OUT00 ANA22 R335 C355100p GAIN-OUT01 IC23 -15V GAIN-OUT00 PRE-FR ANA20 GAIN-OUT02 22/50 R337 C357...
  • Page 74 R-GND SL/SRMUTE XM_MUTE MULTIMUTEB PRO7 PRO10 * 4 , VERSION SET OPTION _XM_DAC_RST MULTIMUTEA SBMUTE RC19 RC18 IC17 XM_ON VCC2 22/50 AV8003 MODE1 SET CC66 PRO11 CNTMUTE PRO3 AFDATA L/RMUTE 0.1uF CC65 PRO8 PRO12 RC61 RC62 PRO4 AFCLK PRO9 SWMUTE...
  • Page 75 DSP PWB 2/2 TO HDMI PWB -2/2 TO HDMI PWB -2/2 BN74 2P-2.0MM-WIRE 15P-1.00MM-WAFER 13P-1.00MM-WAFER AUX-OPT O-IN0 HDMI[00:10] (+3V36) (+3V36) +3V3 +3V3 CN81 CN83 0.1uF C308 R223 JK11 JALCO-5V-RX-NEW C-IN1 * 1-2 _DIR_RST DIR_CLK 50V/0.01u R227 (+3V36) DSPO[00:07] DIG_SEL_A +5VD _CEDIR +3V3 O-IN1...
  • Page 76 XM PWB (/U Only) N. C. BLOCK...
  • Page 77 HD RADIO PWB ( /U Only) CN91 R937 1.RDS CLK R936 2.RDS DATA 3.PLL CE R935 R934 4.PLL DI R933 5.PLL CLK R932 6.PLL DO 7.D-GND 8.NC 9.NC 10.+12V +12V +12V 11.NC 12.L-OUT L_OUT 13.A-GND A_GND R_OUT 14.R-OUT P35/SCL/SSCK P07/AN0 15.MUTE MUTE R901...
  • Page 78 PREOUT TOP PWB +12VR PREOUT-T +15V -15V PREOUT_MUTE_A +12VR -15V +15V VOL-OUT_A00 C501 R502 R503 10K C506 R510 R508 R512 22/25V C502 22/25V HVTKTC2875B HVTKTC2875B FRONT_ON/OFF B-PRE-FL R519 R520 VOL-OUT_A00 Q501 Q503 C557 22/25V R581 R583 R585 100P JK52 R592 22/50V HVTKTC2875B HVTKTC2875B...
  • Page 79 RC232C SIRIUS PWB 7.1 CH INPUT PWB RC232C & SIRIUS JK12 JK15 R121 (U Ver) +15V S-GND BN85 (AUX2) 22/50 1. 7.1 IN-FL R103 C107 ST202EBW +5VLR S-GND R122 IC12 2. GND 3. 7.1 IN-FR R123 S-GND 4. GND D-TUNER-GND D-TUNER-GND C109 S-GND...
  • Page 80 FROM DSP PWB -1/2 TO DSP PWB -1/2 17P-1.0MM-FFC FROM REGULATOR PWB 9P-2.5MM-WIRE FRONT PWB CN64 CJP17GA117ZY 3P-2.5MM-WIRE CWB09 VOLUME BN45 BN18 CWB03 SELECTOR ENCODER PWB AC5.5V 10/50V C830 AC5.5V FRONT ENCODER PWB C806 C829 10/50V 100/35V VOLUME +15V C809 C810 +5VD -15V...
  • Page 81 TO DMP MODULE FROM DSP PWB -1/2 TO PREOUT BOT PWB 2 PIN-2.5MM-WAFER 7 PIN-2.5MM-WAFER 9 PIN-2.0MM-WIRE BN56 CN57 CN54 STANDBY PWB L501 NFM21PC474R1C30 STBYGND +12V DDGND STBYGND DDGND D702 IC74 S-80842CNY-X 1N4003SRT R783 D707 2.2K D708 1N4003SRT +5VD 1.RS232C_SW3 2.DMP_CPU_READREQ 3.DMP_CPU_IICCLK 4.DMP_CPU_IIC_DATA...
  • Page 82 REGULATOR PWB IC96 HVIKIA7812API +12VD COMMON IC97 HVIKIA7812API Q902 KTC3198YT +12VR COMMON Q903 Q904 KTC3198YT KTA1267Y IC93 HVINJM7815FA R903 +15V 0.15(1W) HVDGBJ1006 D901 R908 1.AC 2.CH_GND 3.AC R904 0.15(1W) -15V HVINJM7915FA IC94 5.AC 4.AC 3.NC 2.FL2 BN49 1.FL1 FROM PREOUT BOT PWB 1.+8V2 2.GND 3 PIN-2,5MM-WAFER...

  • Page 83: Parts Location

    10. PARTS LOCATION COMPONENT A PWB COMPONENT B PWB IC99 IC94 IC92 IC97 IC91 IC96 IC89 IC95 IC93 IC90 IC98 Q851 Q852 Q853 Q854 Q855 Q856 Q857 Q858 Q859 Q860 Q861 Q862 XM A PWB (/U Only) XM B PWB (/U Only) XM PWB B (/U Only) XM PWB A (/U Only) ICU4...
  • Page 84 VIDEO A PWB IC73 IC72 IC77 IC82 IC71 IC81 Q701 IC76 IC75 IC74 Q703 Q704 Q702 Q713 IC79 IC83 Q707 Q706 Q705 IC78 Q708 IC80 IC91 IC92 Q710 - Q712 鉛フリー半田 半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。 Lead-free Solder When soldering, use the Lead-free Solder (Sn-Ag-Cu).
  • Page 85 VIDEO B PWB 鉛フリー半田 半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。 Lead-free Solder When soldering, use the Lead-free Solder (Sn-Ag-Cu).
  • Page 86 HDMI A PWB HDMI PWB A Q101 Q102 Q104 Q105 Q107 Q108 Q110 Q111 Q302 Q303 IC96 Q103 Q106 Q114 Q109 Q112 IC12 IC39 IC11 Q113 IC13 IC36 IC38 IC98 IC95 IC14 IC15 IC31 IC90 IC37 IC93 IC89 Q304 IC41 IC40 IC32 IC33 IC34 Q301 IC81 Q905...
  • Page 87 HDMI B PWB 鉛フリー半田 半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。 Lead-free Solder When soldering, use the Lead-free Solder (Sn-Ag-Cu).
  • Page 88 DSP A PWB DSP PWB A IC39 IC40 QC26 QC28 IC26 IC44 QC31 QC30 Q29 QC23 QC24 QC25 IC45 IC22 IC24 IC23 IC28 QC27 IC25 IC41 IC46 IC29 IC62 IC65 QC11 QC12 IC59 IC13 IC31 IC32 IC36 IC33 IC47 IC12 QC13 QC14 IC35 IC21 IC37...
  • Page 89 DSP B PWB IC27 IC34 鉛フリー半田 半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。 Lead-free Solder When soldering, use the Lead-free Solder (Sn-Ag-Cu).
  • Page 90 INPUT A PWB INPUT PWB A IC23 IC34 IC38 IC40 IC24 IC35 IC41 IC21 IC22 IC42 Q215 IC28 IC36 IC43 IC25 Q201 IC39 IC44 Q203 Q204 IC26 IC29 Q205 Q206 IC27 Q202 IC37 IC45 Q207 Q208 IC47 IC30 Q211 - Q214 Q209 Q210 Q221 - Q223 IC31...
  • Page 91 INPUT B PWB CD-R X A PWB CD-R X B PWB IC13 7.1 CH INPUT A PWB 7.1 CH INPUT B PWB 鉛フリー半田 半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。 Lead-free Solder When soldering, use the Lead-free Solder (Sn-Ag-Cu).
  • Page 92 PREOUT TOP A PWB PREOUT TOP B PWB Q525 Q530 Q506 Q515 Q516 - Q519 Q511 - Q514 Q505 Q507 - Q509 Q501 - Q504 IC54 IC53 Q520 - Q523 Q526 - Q529 IC52 IC51 IC55 IC56 鉛フリー半田 半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。 Lead-free Solder When soldering, use the Lead-free Solder (Sn-Ag-Cu).
  • Page 93 PREOUT BOTTOM A PWB PREOUT BOTTOM B PWB Q723 Q728 Q705 Q714 Q719 - Q722 Q724- Q727 Q706 - Q709 Q701 - Q704 Q715 - Q718 Q710 - Q713 IC75 IC76 IC72 IC71 IC74 IC73 Q729 - Q738 Q739 Q740 鉛フリー半田...
  • Page 94 RC232C SIRIUS A PWB RC232C SIRIUS B PWB IC11 Q101 IC12 REGULATOR A PWB IC95 IC91 IC92 IC96 IC97 IC93 IC94 Q901 Q903 Q904 Q902 鉛フリー半田 半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。 Lead-free Solder When soldering, use the Lead-free Solder (Sn-Ag-Cu).
  • Page 95 HD RADIO A PWB (U Only) HD RADIO B PWB (U Only) Q905 - Q909 Q901 Q902 IC92 IC95 IC94 Q904 IC93 IC91 Q903 REGULATOR B PWB 鉛フリー半田 半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。 Lead-free Solder When soldering, use the Lead-free Solder (Sn-Ag-Cu).
  • Page 96 TACT A PWB TACT B PWB FRONT A PWB Q811 Q808 Q809 Q803 Q801 Q806 Q807 PUSH S/W A WB PUSH S/W B WB SELECTOR ENCODER A PWB SELECTOR ENCODER B PWB 鉛フリー半田 半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。 Lead-free Solder When soldering, use the Lead-free Solder (Sn-Ag-Cu).
  • Page 97 FRONT B PWB MIC A PWB MIC B PWB IC81 IC85 H/P A PWB H/P B PWB VOLUME ENCODER A PWB VOLUME ENCODER B PWB 鉛フリー半田 半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。 Lead-free Solder When soldering, use the Lead-free Solder (Sn-Ag-Cu).
  • Page 98 STANDBY A PWB IC74 - IC76 Q905 Q904 Q901 - Q903 鉛フリー半田 半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。 Lead-free Solder When soldering, use the Lead-free Solder (Sn-Ag-Cu).
  • Page 99 STANDBY B PWB IC51 鉛フリー半田 半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。 Lead-free Solder When soldering, use the Lead-free Solder (Sn-Ag-Cu).

  • Page 100: Exploded View And Parts List

    11. EXPLODED VIEW AND PARTS LIST F, K, U Only N Only DMP PWB MODULE STANDBY PWB PRE TOP PWB PRE BOTTOM PWB RS232C SIRIUS PWB XM PWB COMPONENT PWB REGULATOR PWB HDMI PWB ASS'Y HD-RADIO MODULE HD-RADIO PWB F, U Only CDR-X PWB K, N Only PUSH SWITCH PWB...
  • Page 101 PWB ASSY VIDEO PWB ASSY /N COP12073B 62 /U1B PWB ASSY VIDEO PWB ASSY /U COP12073C 63 /N1B PWB ASSY 7.1CH INPUT PWB ASSY /N COP12077B NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 102 AM LOOP HD RARIO S0160BL-32 CSA1A034Z /U1B 90M-ZA000320R ANTENNA FM ADAPTOR BROWN P-03P1-002A CLR001 /N1B 90M-ZA000210R ANTENNA ANT FM WIRE (PIGTAIL) CSA1A007 /U1B 90M-ZA000330R ANTENNA FM.T (LUG TYPE) CSA267 NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.

  • Page 103: Microprocessor And Ic Data

    12. MICROPROCESSOR AND IC DATA IC17 : M3087BFKBGP PortSetup Port Name Nor. Level Name Note Mode7 Volt STBY Device Shift Act. Init P9-6/ANEX1/TxD4/ DMP_CPU_ (3.3-)5.0V I2C Data for DMP CPU SDA4/SRxD4 IICDATA Ele Volume IC Strobe P9-5/ANEX0/CLK4/ P1 VOL_DTA 5.0V (TC9482) P9-4/DA1/TB4in/_ Ele Volume IC Strobe...
  • Page 104 IC17 : M3087BFKBGP PortSetup Port Name Nor. Level Name Note Mode7 Volt STBY Device Shift Act. Init P8-0/TA4out/U/ TU_MUTE 5.0V H Tuner Mute (Tuner Pack) ISRxD0/RxD5 P7-7/TA3in/ INPC1-4/OUTC1-4/ Tuner PLL CE (Tuner _CE_TU 5.0V ISCLK0/CLK5/ Pack) RTP2-2 P7-6/TA3out/ Tuner PLL Data out INPC1-3/OUTC1-3/ TUDOUT 5.0V...
  • Page 105 IC17 : M3087BFKBGP PortSetup Port Name Nor. Level Name Note Mode7 Volt STBY Device Shift Act. Init 59 Vcc2 P2Vcc +3.3V VCC2 +3.3V' 60 P13-1/OUTC2-5 +3.3V MULTIMUTEA 3.3-5.0V H MULTI ROOM A MUTE 61 P13-0/OUTC2-4 +3.3V MULTIMUTEB 3.3-5.0V H MULTI ROOM B MUTE P5-3/CLKout/ DAC CHIP SELECTION +3.3V...
  • Page 106 IC17 : M3087BFKBGP PortSetup Port Name Nor. Level Name Note Mode7 Volt STBY Device Shift Act. Init 88 P12-2/RxD6 +3.3V D_TUNER_TXD 3.3V H UART for XM Module Front FL Driver Reset 89 P12-1/CLK6 +3.3V _RSTFL 5.0V (NJU3430) 90 P12-0/TxD6 +3.3V D_TUNER_RXD 3.3V H UART for XM Module...
  • Page 107 IC17 : M3087BFKBGP PortSetup Port Name Nor. Level Name Note Mode7 Volt STBY Device Shift Act. Init P15-5/AN15-5/ Analog Switch CE_TCA 5.0V RxD6 (TC94A46FG/TC9274N) P15-4/AN15-4/ ILLMINATION_ FRONT ILLMINATION 5.0V TxD6 ON_OFF ON/OFF P15-3/AN15-3/_ HDMI_LED 5.0V HDMI LED ON CTS5/_RTS5 P15-2/AN15-2/ Serial Data from DIR DIR_IN 3.3V...
  • Page 108 IC51 : R5F21248SNFP [DMP CPU] Port Setup Pin No Port Name Use STBY Name Note Act. Init IIC Serial Clock P3_5/SCL/SSCK DMP_CPU_IICCLK Communication Clock line to Main CPU Control to Firmware update P3_3/SSI RS232C_SW3 L : RS232C Update (Normal) H : Network Update IIC data P3_4/SDA/SCS DMP_CPU_IIC_DATA...
  • Page 109 IC81 : HD64F36049HV Port Setting port STBY Name Note Act. init PB6/AN6 to GND or Pull up selectable PB7/AN7 to GND or Pull up selectable Avcc AVcc A/D ref. V = +5V _RESET _RES _RST_HDMI_CPU also use for JTAG TEST TEST to Vss To GND...
  • Page 110 IC81 : HD64F36049HV Port Setting port STBY Name Note Act. init P90/ DEBUG_X0 N.C to Virtual Connector Land SCK3_3 60 P91/RXD_3 DEBUG_X1/RxD1 N.C to Virtual Connector Land 61 P92/TXD_3 DEBUG_X2/TxD1 N.C to Virtual Connector Land DEBUG_X3 N.C to Virtual Connector Land DEBUG_X4 N.C to Virtual Connector Land DEBUG_X5...
  • Page 111 IC91 : R5F21246SNFP [HD RADIO CPU] (/U only) Port Setup PORT NAME USE STBY NAME Note Act. Init P35/SCL/SSCK RDS CLK Interface to Main CPU (80pin / RDS CLK) P33/SSI No Use P34/SDA/SCS No Use MODE MODE Interface to Main CPU (25pin / Write mode) P43/XCIN No Use P44/XCOUT...
  • Page 112 IC13 : TC7MZ4052FK TC7MZ4052FK IC19 : TC74HC4052AFT X-COM TC7MZ4053FK 1Y 1 Y-COM X-COM Z-COM Y-COM Truth Table TC7MZ4053FK Control Inputs “ON” Channel Inhibit MZ4051FK MZ4052FK MZ4053FK Y-COM X-COM 0X, 0Y 0X, 0Y, 0Z 1X, 1Y 1X, 0Y, 0Z 2X, 2Y 0X, 1Y, 0Z 3X, 3Y 1X, 1Y, 0Z...
  • Page 113 IC20 : TC74HC4094AP IC20 PortSetup IC21 : TC74HC4094AP Port Use STBY Name Note Name Device Act. IC37 : TC74HC4094AP MIC_ENABLE 3.3-5.0V L MIC Enable for MRAC (Relay) IC79 : TC74HC4094AP SPKC_CONT 5.0V L Speaker C Relay Control (Relay) IC80 : TC74HC4094AP _PUREDIRECT_LED 5.0V H PURE DIRECT LED On...
  • Page 114 IC21 : TC94A46CFG...
  • Page 115 IC22 : TC9274CNG CS5361 114 dB, 192 kHz, Multi-Bit Audio A/D Converter Features General Description The CS5361 is a complete analog-to-digital converter for Advanced Multi-bit Delta-sigma Architecture digital audio systems. It performs sampling, analog-to- 24-bit Conversion digital conversion, and anti-alias filtering. The CS5361 generates 24-bit values for both left and right inputs in 114 dB Dynamic Range serial form at sample rates up to 192 kHz per channel.
  • Page 116 CS5361 IC27 : CS5361-KS 2.0 PIN DESCRIPTIONS FILT+ REFGND LRCK SCLK AINR+ MCLK AINR- AINL- SDOUT AINL+ MDIV OVFL S/LJ Pin Name Pin Description Reset (Input) - The device enters a low power mode when low. Master/Slave Mode (Input) - Selects operation as either clock master or slave. LRCK Left Right Clock (Input/Output) - Determines which channel, Left or Right, is currently active on the serial audio data line.
  • Page 117 IC29 : LC89057WVF4E EMPHA/UO AUDIO XMODE LC89057W-VF4-E RXOUT Microcontroller C bit , Ubit SDIN RERR SLRCK SBCK Input Demodulation Data Selector & RDATA RDATA Selector Lock detect RX5/VI XMODE RLRCK RX6/UI DGND DVDD SDIN LC89057W-VF4-E DVDD DGND RMCK TMCK/PIO0 RBCK RBCK RLRCK TBCK/PIO1...
  • Page 118 (14) TC74VCX157FT (13) IEC Logic Symbol IC32 : TC74VHC157FT Truth Table (15) Inputs Outputs SELECT SELECT (11) (10) (14) (12) (13) X: Don’t care Aureus TMS320DA708 Floating-Point Digital Signal Processor www.ti.com SPRS297A – JULY 2005 – REVISED AUGUST 2005 IC33 : TMS320DA788 Outputs 1 Second Generation Aureus™...
  • Page 119 2.14 Terminal Functions Table 2-2, the Terminal Functions table, identifies the external signal names, the associated pin/ball numbers along with the mechanical package designator, the pin type (I, O, IO, OZ, or PWR), whether the pin/ball has any internal pullup/pulldown resistors, whether the pin/ball is configurable as an IO in GPIO mode, and a functional pin description.
  • Page 120 Aureus TMS320DA708 Floating-Point Digital Signal Processor www.ti.com IC33 : TMS320DA788 SPRS297A – JULY 2005 – REVISED AUGUST 2005 Table 2-2. Terminal Functions (continued) SIGNAL NAME TYPE PULL GPIO DESCRIPTION McASP0, McASP1, McASP2, and SPI1 Serial Ports AHCLKR0/AHCLKR1 McASP0 and McASP1 Receive Master Clock ACLKR0 McASP0 Receive Bit Clock AFSR0...
  • Page 121 Aureus TMS320DA708 Floating-Point Digital Signal Processor IC33 : TMS320DA788 www.ti.com SPRS297A – JULY 2005 – REVISED AUGUST 2005 Table 2-2. Terminal Functions (continued) SIGNAL NAME TYPE PULL GPIO DESCRIPTION Clocks OSCIN 1.2-V Oscillator Input OSCOUT 1.2-V Oscillator Output OSCV Oscillator 1.2-V V tap point (for filter only) OSCV Oscillator V...
  • Page 122 IC38 : TC9482BFG IC39 : TC9482BFG...
  • Page 123 IC38 : TC9482BFG IC39 : TC9482BFG...
  • Page 124 CE# Access (ns) OE# Access (ns) IC34 : ES29LV320E E S I E S I FUNCTION BLOCK DIAGRAM Excel Semiconductor inc. RY/BY# Timer/ Vcc Detector PIN DESCRIPTION DQ0-DQ15(A-1) Counter Description Analog Bias A0-A20 21 Addresses Generator Input/Output DQ0-DQ14 15 Data Inputs/Outputs Buffers Command Write...
  • Page 125 ESMT M12L64164A IC35 : M12L64164A7T FUNCTIONAL BLOCK DIAGRAM Clock Generator Bank D Bank C Bank B Address Address Buffer Mode Bank A & Register Refresh Counter Sense Amplifier L(U)DQM Column Column Decoder Address Buffer & Refresh Counter Data Control Circuit PIN FUNCTION DESCRIPTION NAME INPUT FUNCTION...
  • Page 126 IC32 : TC74VHC157FT...
  • Page 127 CS4382 IC41 : CS4382A-CQ 114 dB, 192 kHz 8-Channel D/A Converter Features Description 24-bit Conversion The CS4382 is a complete 8-channel digital-to-analog system including digital interpolation, fifth-order delta- Up to 192 kHz Sample Rates sigma digital-to-analog conversion, digital de-emphasis, 114 dB Dynamic Range volume control and analog filtering.
  • Page 128 CS4382 IC41 : CS4382A-CQ PIN DESCRIPTION 4 8 4 7 4 6 4 5 4 4 4 3 4 2 4 1 4 0 3 9 3 8 3 7 DSDA2 AOUTA2- DSDB1 AOUTA2+ AOUTB2+ DSDA1 AOUTB2- CS4382 MCLK LRCK1(DSD_EN) AOUTA3- SDIN1 AOUTA3+...
  • Page 129 CS4382 IC41 : CS4382A-CQ Pin Name Pin Description MUTEC1 Mute Control (Output) - The Mute Control pins go high during power-up initialization, reset, muting, MUTEC234 power-down or if the master clock to left/right clock frequency ratio is incorrect. These pins are intended to be used as a control for external mute circuits to prevent the clicks and pops that can occur in any sin- gle supply system.
  • Page 130 P r o d u c t B r i e f IC51 : ABT1010 March 2007 High Performance Video Scaling Chip for DVD Player/Recorder Applications Summary The ABT1010, Anchor Bay’s second generation video scaling chip is targeted at low-cost DVD player/ recorder applications requiring up-conversion from 480p/576p to high-definition formats including 1080p.
  • Page 131 ABT1010 IC51 : ABT1010 Precision Video Scaling II ™ • 10-bit fully programmable horizontal and vertical scaler • Upscales to 1080p and downscales to VGA format • Automatic Chroma Upsampling Error detection and correction • Aspect ratio control for displaying 4:3 inputs on 16:9 displays —...
  • Page 132 CS4392 IC61 : CS4392KZZ 1. PIN DESCRIPTION - PCM DATA MODE AMUTEC AOUTA- SDATA AOUTA+ SCLK LRCK AGND MCLK AOUTB+ AOUTB- (SCL/CCLK) M2 BMUTEC (SDA/CDIN) M1 CMOUT (AD0/CS) M0 FILT+ Reset (Input) - Powers down device and resets all internal registers to their default settings. Logic Power (Input) - Positive power for the digital input/output.
  • Page 133 CS4392 CS4392 24-Bit, 192 kHz Stereo DAC with Volume Control IC61 : CS4392KZZ Features Description PIN DESCRIPTION - DSD mode Complete Stereo DAC System: Interpolation, The CS4392 is a complete stereo digital-to-analog sys- tem including digital interpolation, fifth-order delta-sigma D/A, Output Analog Filtering AMUTEC digital-to-analog conversion, digital de-emphasis, vol- AOUTA-...
  • Page 134 IC62 : ADV7403BSTZ-110 OUTPUT FIFO & FORMATTER...
  • Page 135 ADV7403 Pin Description IC62 : ADV7403BSTZ-110 98 97 96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 AIN12 Pin1 AIN5 Identifier AIN11 AIN4 CS/HS AIN10 DGND TEST0 DVDDIO CAPC2 ADV7403 CAPC1...
  • Page 136 ADV7403 IC62 : ADV7403BSTZ-110 Pin No. Mnemonic Type Function 72, 74, 76, 53, 55, 57, 71, 73, 75 42, 41, 28, P2–P9, P12– Video pixel output port. 27, 26, 25, 23, 22, 10, 9, 8, 7, 94, 93, 92, 91 44, 43, 21, P0–P1, P10–...
  • Page 137 ADV7403 IC62 : ADV7403BSTZ-110 Pin No. Mnemonic Type Function mode the crystal must be a fundamental crystal. ELPF The recommend external loop filter must be connected to this ELPF pin. 70, 59 TEST0 - These pins should be unconnected TEST1 SFL/SYNC_O SFL (Subcarrier Frequency Lock);...
  • Page 138 IC63 : CD0040AF MPU Interface Configuration Registers Timing Generator Video Processing Engine Digital Out SDRAM Inter face SDRAM Fig. 2-1: System Block Diagram cvdd 109 72 ivdd MD7 110 71 cvdd MD8 111 70 ovss MD6 112 69 RFFI MD9 113 68 FILM ovdd 114 67 CO9...
  • Page 139 IC63 : CD0040AF Name Attr ibut e Functional Description Name Attr ibut e Functional Description OVDD Positive supply voltage(+3.3V) for Pad Ring OVSS Digital ground for Pad Ring CLKI CMOS System Clock Input (27MHz) CVDD Digital positive supply voltage (+2.5V) for core TEST7 CMOS Test purpose only(must be connected to Ground)
  • Page 140 HY57V161610E FUNCTIONAL BLOCK DIAGRAM IC64 : HY57V161610ET-7 1Mx16 Synchronous DRAM Self Refresh Counter Refresh Refresh Interval Timer Counter 512Kx16 Bank 0 Address[0:10] HY57V161610E Sense AMP & I/O gates Column Decoder PIN CONFIGURATION Address Precharge Register Row Active BA(A11) DQ15 DQ15 Column Active Column Addr.
  • Page 141 5-input 3-output Operating Voltage ±4.0 to ±6.5V Operating current ±15mAtyp. at Vcc=±5V Crosstalk -65dBtyp. Internal 6dB Amplifier Internal 75Ω Driver IC71 : NJM2595MTE1 Bipolar Technology Package Outline DIP16,DMP16 IC72 : NJM2595MTE1 IC73 : NJM2595MTE1 PIN CONFIGURATION and BLOCK DIAGRAM IC81 : NJM2595MTE1 NJM2595 ABSOLUTE MAXIMUM RATINGS (Ta=25°C)
  • Page 142 IC75 : NJM2264D IC76 : NJM2244D IC77 : NJM2244D IC82 : NJM2244D...
  • Page 143 IC78 : LC747828A13 LC74782, 74782M Pin Functions Pin No. Symbol Function Description Ground Ground connection (digital system ground) Xtal Used to connect the crystal oscillator and capacitor used to generate the internal Crystal oscillator connection synchronization signal, or to input an external clock (2fsc or 4fsc). Xtal Switches between external clock input mode and crystal oscillator mode.
  • Page 144 IC81 : NJU3430F R S T R ESET Instruction M K R AM Icon D ec oder 16x2 bit D r i v e r 8bits Line Shift C L K Address R e g . Counter C G R AM Segment 35x8 bit D r i v e r...
  • Page 145 Maximum input Voltage1 Vim1 BIAS input Vp-p Maximum input Voltage 2 Vim2 CLAMP input Vp-p BLOCK DIAGRAM BIAS input, Maximum Output Voltage 1 Vom1 Vp-p Vin=1kHz,Sin signal,THD=1%, CLAMP input, Maximum Output Voltage 2 Vom2 Vp-p IC91 : NJM2584M Vin=1kHz,Sin signal,THD=1%, IC92 : NJM2584M Voltage Gain WIDE BAND 3-INPUT 1-OUTPUT 3-CIRCUIT V...
  • Page 146 ST3232E APPLICATION CIRCUITS IC92 : ST3232ECWR ST3232E PIN CONFIGURATION PIN DESCRIPTION CAPACITANCE VALUE (µF) PlN N° SYMBOL NAME AND FUNCTION Positive Terminal for the first Charge Pump Capacitor Cbypass Doubled Voltage Terminal 3.0 to 3.6 Negative Terminal for the first Charge Pump Capacitor 4.5 to 5.5 0.047 0.33...

  • Page 147: Electrical Parts List

    13. ELECTRICAL PARTS LIST PARTS INFORMATION NOTE ON SAFETY FOR FUSIBLE RESISTOR : The suppliers and their type numbers of fusible resistors RESISTORS are as follows; 1) 00MGD05 × × × 140, Carbon film fixed resistor, ±5% 1/4W 1. KOA Corporation 2) 00MGD05 ×...
  • Page 148 COMP. C812 00MOA10701620 ELECT CAP. 100UF 16V CCEA1CH101T COMP. C813 00MOA10701620 ELECT CAP. 100UF 16V CCEA1CH101T COMP. C814 00MDK96103300 CER. CAP. 0.01UF 50V KC CCUS1H103KC NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 149 COMP. C917 00MOA10505020 ELECT CAP. 1UF 50V CCEA1HH1R0T COMP. C918 00MDK96103300 CER. CAP. 0.01UF 50V KC CCUS1H103KC COMP. C919 00MOA47602520 ELECT CAP. 47UF 25V CCEA1EH470T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 150 COMP. C987 00MOA10505020 ELECT CAP. 1UF 50V CCEA1HH1R0T COMP. C988 00MDK96103300 CER. CAP. 0.01UF 50V KC CCUS1H103KC COMP. C989 00MOA47602520 ELECT CAP. 47UF 25V CCEA1EH470T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 151 22K OHM 1/10W J CRJ10DJ223T COMP. R874 00MNN05102610 CHIP RES. 1K OHM 1/10W J CRJ10DJ102T COMP. R875 00MNN05223610 CHIP RES. 22K OHM 1/10W J CRJ10DJ223T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 152 47 OHM 1/10W J CRJ10DJ470T COMP. R967 00MNN05470610 CHIP RES. 47 OHM 1/10W J CRJ10DJ470T COMP. R968 00MNN05470610 CHIP RES. 47 OHM 1/10W J CRJ10DJ470T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 153 0.1UF 50V K CCUS1H104KC C127 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC C128 00MOA22605020 ELECT CAP. 22UF 50V CCEA1HH220T C129 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 154 0.1UF 50V K CCUS1H104KC C199 00MOA10605020 ELECT CAP. 10UF 50V CCEA1HH100T C200 00MDD95471300 CER. CAP. 470PF 50V JA CCUS1H471JA C201 00MDD9515030R CER. CAP. 15PF 50V JA CCUS1H150JA NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 155 CCEA1HRA220T C333 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC C334 00MOA22605020 ELECT CAP. 22UF 50V RA2-50V220ME3#8 CCEA1HRA220T C335 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 156 CCUS1H104KC CC49 00MDK96102300 CER. CAP. 1000PF 50V KC CCUS1H102KC CC50 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC CC51 00MDK96102300 CER. CAP. 1000PF 50V KC CCUS1H102KC NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 157 1SS355 CVD1SS355T DC14 00MHZ21303210 00MHZ21303210 DIODE 1SS355 CVD1SS355T DC15 00MHZ21303210 00MHZ21303210 DIODE 1SS355 CVD1SS355T DC16 90M-HD201750R DIODE 1N4003 CVD1N4003SRT DC17 00MHZ21303210 00MHZ21303210 DIODE 1SS355 CVD1SS355T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 158 90M-YT003650R TERMINAL CINCH 2P GREEN RCA-207AE-11 CJJ4N071Z JK17 90M-YJ002760R 90M-YJ002760R CONN. STEREO 2P 3.5MM HSJ1002-016020 HJJ1D002Z JK18 90M-YJ002760R 90M-YJ002760R CONN. STEREO 2P 3.5MM HSJ1002-016020 HJJ1D002Z NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 159 00MNN05103610 CHIP RES. 10K OHM 1/10W J CRJ10DJ103T R126 00MNN05103610 CHIP RES. 10K OHM 1/10W J CRJ10DJ103T R127 00MNN05103610 CHIP RES. 10K OHM 1/10W J CRJ10DJ103T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 160 00MNN05332610 CHIP RES. 3.3K OHM 1/10W J CRJ10DJ332T R202 00MNN05472610 CHIP RES. 4.7K OHM 1/10W J CRJ10DJ472T R203 00MNN05182610 CHIP RES. 1.8K OHM 1/10W J CRJ10DJ182T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 161 00MNN05010610 CHIP RES. 1 OHM 1/10W J CRJ10DJ1R0T R343 00MNN05105610 CHIP RES. 1M OHM 1/10W J CRJ10DJ105T R344 00MNN05102610 CHIP RES. 1K OHM 1/10W J CRJ10DJ102T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 162 00MNN05101610 CHIP RES. 100 OHM 1/10W J CRJ10DJ101T R453 00MNN05101610 CHIP RES. 100 OHM 1/10W J CRJ10DJ101T R454 00MNN05101610 CHIP RES. 100 OHM 1/10W J CRJ10DJ101T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 163 00MNN05000610 CHIP RES. 0 OHM 1/10W J CRJ10DJ0R0T RC64 00MNN05473610 CHIP RES. 47K OHM 1/10W J CRJ10DJ473T RC65 00MNN05473610 CHIP RES. 47K OHM 1/10W J CRJ10DJ473T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 164 00MNN05000610 CHIP RES. 0 OHM 1/10W J CRJ10DJ0R0T RR32 00MNN05103610 CHIP RES. 10K OHM 1/10W J CRJ10DJ103T RR34 00MNN05000610 CHIP RES. 0 OHM 1/10W J CRJ10DJ0R0T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 165 CCBS1H101KBT FRONT CN64 CONN. 17P WAFER FFC FCZ100E-17SSK CJP17GA117ZY FRONT D802 90M-HI101040R 90M-HI101040R L.E.D. SLR342VCTB7T089 HVD342VCTB7T089 FRONT D803 90M-HI101190R 90M-HI101190R L.E.D. BLUE LED TOL-52CSBBCEAB2 CVD52CSBBCEAB2 NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 166 RES. 2.7K OHM 1/6W J CARBON CRD20TJ272T FRONT R828 RES. 2.2K OHM 1/6W J CARBON CRD20TJ222T FRONT R829 RES. 1.5K OHM 1/6W J CARBON CRD20TJ152T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 167 RES. 10K OHM 1/6W J CARBON CRD20TJ103T FRONT R971 RES. 270 OHM 1/6W J CARBON CRD20TJ271T FRONT R972 RES. 220 OHM 1/6W J CARBON CRD20TJ221T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 168 0.01UF 50V KC CCUS1H103KC HD RADIO C922 /U1B 00MDK96472300 CER. CAP. 4700PF 50V KC CCUS1H472KC HD RADIO C923 /U1B 00MDK96472300 CER. CAP. 4700PF 50V KC CCUS1H472KC NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 169 CRJ10DJ103T HD RADIO R906 /U1B 00MNN05000610 CHIP RES. 0 OHM 1/10W J CRJ10DJ0R0T HD RADIO R907 /U1B 00MNN05103610 CHIP RES. 10K OHM 1/10W J CRJ10DJ103T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 170 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC HDMI C107 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC HDMI C108 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 171 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC HDMI C348 00MOA10705020 ELECT CAP. 100UF 50V RA2-50V101MG3#8 CCEA1HRA101T HDMI C349 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 172 00MDD90010300 CER. CAP. 1 PF 50V CCUS1H1R0CA HDMI C420 00MDD90010300 CER. CAP. 1 PF 50V CCUS1H1R0CA HDMI C421 00MDD90010300 CER. CAP. 1 PF 50V CCUS1H1R0CA NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 173 HDMI C606 00MOA10701620 ELECT CAP. 100UF 16V CCEA1CH101T HDMI C607 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC HDMI C608 00MOA10605020 ELECT CAP. 10UF 50V CCEA1HH100T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 174 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC HDMI C674 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC HDMI C675 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 175 00MDD95180300 CER. CAP. 18PF 50V JA CCUS1H180JA HDMI C908 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC HDMI C909 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 176 TC7MZ4052FK 4CH MUX CVITC7MZ4052FK HDMI IC14 90M-HC700680R 90M-HC700680R IC TC74VHCT14AF CVITC74VHCT14AFT HDMI IC15 90M-HC700630R 90M-HC700630R IC TC74VHCT04AFN CVITC74VHCT04AFN HDMI IC31 SII9135CTU HDMI RX 144PIN TQFP CVISII9135CTU NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 177 90M-LU000290R 90M-LU000290R CHIP INDUCT MIP3226D100M 10UH CLQ10E100MRY HDMI L313 90M-LU000290R 90M-LU000290R CHIP INDUCT MIP3226D100M 10UH CLQ10E100MRY HDMI L314 90M-LU000290R 90M-LU000290R CHIP INDUCT MIP3226D100M 10UH CLQ10E100MRY NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 178 90M-HT800110R TRS. KTC4075GR HVTKTC4075GR HDMI Q812 90M-HT600050R 90M-HT600050R TRS. KTA2014GR HVTKTA2014GR HDMI Q813 90M-HT800110R 90M-HT800110R TRS. KTC4075GR HVTKTC4075GR HDMI Q814 90M-HT600050R 90M-HT600050R TRS. KTA2014GR HVTKTA2014GR NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 179 47K OHM 1/10W J CRJ10DJ473T HDMI R313 00MNN05220610 CHIP RES. 22 OHM 1/10W J CRJ10DJ220T HDMI R314 00MNN05220610 CHIP RES. 22 OHM 1/10W J CRJ10DJ220T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 180 6.8K OHM 1/10W J CRJ10DJ682T HDMI R403 00MNN05332610 CHIP RES. 3.3K OHM 1/10W J CRJ10DJ332T HDMI R404 00MNN05473610 CHIP RES. 47K OHM 1/10W J CRJ10DJ473T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 181 0 OHM 1/10W J CRJ10DJ0R0T HDMI R622 00MNN05220610 CHIP RES. 22 OHM 1/10W J CRJ10DJ220T HDMI R623 00MNN05220610 CHIP RES. 22 OHM 1/10W J CRJ10DJ220T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 182 0 OHM 1/10W J CRJ10DJ0R0T HDMI R714 00MNN05000610 CHIP RES. 0 OHM 1/10W J CRJ10DJ0R0T HDMI R715 00MNN05000610 CHIP RES. 0 OHM 1/10W J CRJ10DJ0R0T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 183 470 OHM 1/10W J CRJ10DJ471T HDMI R852 00MNN05471610 CHIP RES. 470 OHM 1/10W J CRJ10DJ471T HDMI R853 00MNN05561610 CHIP RES. 560 OHM 1/10W J CRJ10DJ561T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 184 47K OHM 1/10W J CRJ10DJ473T HDMI R949 00MNN05473610 CHIP RES. 47K OHM 1/10W J CRJ10DJ473T HDMI R950 00MNN05473610 CHIP RES. 47K OHM 1/10W J CRJ10DJ473T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 185 CRJ104DJ0R0T HDMI RN65 90M-BW000470R 90M-BW000470R RES. COMPO. RES ARRAY 0 OHM 1608X4 CRJ104DJ0R0T HDMI RN66 90M-BW000400R 90M-BW000400R RES. COMPO. 22 OHM X4 2012 ARRAY CRJ104DJ220T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 186 INPUT C224 00MDD95471300 CER. CAP. 470PF 50V JA CCUS1H471JA INPUT C225 00MOA10605020 ELECT CAP. 10UF 50V CCEA1HH100T INPUT C226 00MOA10605020 ELECT CAP. 10UF 50V CCEA1HH100T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 187 10 UF M 50V RA2-50V100ME3E# HCEA1HRA100T INPUT C292 00MOA10605020 ELECT CAP. 10 UF M 50V RA2-50V100ME3E# HCEA1HRA100T INPUT C293 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 188 00MOA22605020 ELECT CAP. 22UF 50V RA2-50V220ME3#8 CCEA1HRA220T INPUT C359 00MDD95471300 CER. CAP. 470PF 50V JA CCUS1H471JA INPUT C360 00MDD95471300 CER. CAP. 470PF 50V JA CCUS1H471JA NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 189 C425 00MDD95101300 CER. CAP. 100PF 50V JA CCUS1H101JA INPUT C426 00MDD95101300 CER. CAP. 100PF 50V JA CCUS1H101JA INPUT C427 00MOA10705020 ELECT CAP. 100UF 50V CCEA1HH101T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 190 00MHC10102090 00MHC10102090 IC NJM2068MD-TE1 HVINJM2068MDTE1 INPUT IC44 00MHC10102090 00MHC10102090 IC NJM2068MD-TE1 HVINJM2068MDTE1 INPUT IC45 00MHC10102090 00MHC10102090 IC NJM2068MD-TE1 HVINJM2068MDTE1 INPUT IC46 00MHC10200090 00MHC10200090 IC NJM4556AL HVINJM4556AL NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 191 82K OHM 1/10W J CRJ10DJ823T INPUT R234 00MNN05832610 CHIP RES. 82K OHM 1/10W J CRJ10DJ823T INPUT R235 00MNN05473610 CHIP RES. 47K OHM 1/10W J CRJ10DJ473T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 192 4.7K OHM 1/10W J CRJ10DJ472T INPUT R301 00MNN05104610 CHIP RES. 100K OHM 1/10W J CRJ10DJ104T INPUT R302 00MNN05104610 CHIP RES. 100K OHM 1/10W J CRJ10DJ104T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 193 3.6K OHM 1/10W J CRJ10DJ362T INPUT R368 00MNN05822610 CHIP RES. 8.2K OHM 1/10W J CRJ10DJ822T INPUT R369 00MNN05473610 CHIP RES. 47K OHM 1/10W J CRJ10DJ473T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 194 100 OHM 1/10W J CRJ10DJ101T INPUT R435 00MNN05101610 CHIP RES. 100 OHM 1/10W J CRJ10DJ101T INPUT R436 00MNN05101610 CHIP RES. 100 OHM 1/10W J CRJ10DJ101T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 195 C752 00MOA22701620 ELECT CAP. 220UF 16V CCEA1CH221T PREOUT B C753 90M-OA000120R ELECT CAP. 100UF 50V HCEA1HAHS101T PREOUT B C754 90M-OA000120R ELECT CAP. 100UF 50V HCEA1HAHS101T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 196 CORD SN95/PB5 0.6 C3A206 PREOUT B J720 CORD SN95/PB5 0.6 C3A206 PREOUT B J721 CORD SN95/PB5 0.6 C3A206 PREOUT B J722 CORD SN95/PB5 0.6 C3A206 NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 197 90M-YT003720R TERMINAL GOLD PLATE CJJ4P047Z PREOUT B JK72 943646001450S 943646001450S TERMINAL E703A0800N XLR OUT CJS6S004Z PREOUT B JK73 943646001450S 943646001450S TERMINAL E703A0800N XLR OUT CJS6S004Z NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 198 10K OHM 1/10W J CRJ10DJ103T PREOUT B R724 00MNN05103610 CHIP RES. 10K OHM 1/10W J CRJ10DJ103T PREOUT B R725 00MNN05473610 CHIP RES. 47K OHM 1/10W J CRJ10DJ473T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 199 10 OHM 1/10W J CRJ10DJ100T PREOUT B R791 00MNN05473610 CHIP RES. 47K OHM 1/10W J CRJ10DJ473T PREOUT B R792 00MNN05473610 CHIP RES. 47K OHM 1/10W J CRJ10DJ473T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 200 00MDD95471300 CER. CAP. 470PF 50V JA CCUS1H471JA PREOUT T C542 00MOA10605020 ELECT CAP. 10UF 50V CCEA1HH100T PREOUT T C543 00MDK96104300 CER. CAP. 0.1UF 50V K CCUS1H104KC NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 201 CORD SN95/PB5 0.6 C3A206 PREOUT T J518 CORD SN95/PB5 0.6 C3A206 PREOUT T J519 CORD SN95/PB5 0.6 C3A206 PREOUT T J520 CORD SN95/PB5 0.6 C3A206 NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 202 PREOUT T Q504 90M-HT300970R 90M-HT300970R TRS. KTC2875B HVTKTC2875B PREOUT T Q505 90M-HX800010R 90M-HX800010R CHIP TRS. KRC102S HVTKRC102S PREOUT T Q506 90M-HX800010R 90M-HX800010R CHIP TRS. KRC102S HVTKRC102S NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 203 47K OHM 1/10W J CRJ10DJ473T PREOUT T R542 00MNN05103610 CHIP RES. 10K OHM 1/10W J CRJ10DJ103T PREOUT T R543 00MNN05103610 CHIP RES. 10K OHM 1/10W J CRJ10DJ103T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 204 47K OHM 1/10W J CRJ10DJ473T PREOUT T R612 00MNN05473610 CHIP RES. 47K OHM 1/10W J CRJ10DJ473T PREOUT T R614 00MNN05473610 CHIP RES. 47K OHM 1/10W J CRJ10DJ473T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 205 D904 90M-HD302400R 90M-HD302400R ZENER DIODE ZJ30BT CVDZJ30BT REG. D905 90M-HD201750R DIODE 1N4003 CVD1N4003SRT REG. D906 90M-HD201750R DIODE 1N4003 CVD1N4003SRT REG. D907 90M-HD201750R DIODE 1N4003 CVD1N4003SRT NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 206 RES. 22K OHM 1/6W J CARBON CRD20TJ223T REG. R907 RES. 22K OHM 1/6W J CARBON CRD20TJ223T REG. R908 RES. 10K OHM 1/6W J CARBON CRD20TJ103T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 207 CCBS1H104ZFT STBY C511 CER. CAP. 0.01UF 50V Z CCBS1H103ZFT STBY C512 00MOA10701620 ELECT CAP. 100UF 16V CCEA1CH101T STBY C513 00MOA10701620 ELECT CAP. 100UF 16V CCEA1CH101T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 208 C3A206 STBY JP36 CORD SN95/PB5 0.6 C3A206 STBY JP37 CORD SN95/PB5 0.6 C3A206 STBY JP38 CORD SN95/PB5 0.6 C3A206 STBY JP39 CORD SN95/PB5 0.6 C3A206 NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 209 CRD20TJ472T STBY R546 RES. 4.7K OHM 1/6W J CARBON CRD20TJ472T STBY R547 RES. 10K OHM 1/6W J CARBON CRD20TJ103T STBY R550 CORD SN95/PB5 0.6 C3A206 NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 210 CCFT1H103ZF VIDEO C755 CER. CAP. 47PF 50V JC CCCT1H470JC VIDEO C756 CER. CAP. 0.01UF 50V Z CCFT1H103ZF VIDEO C757 00MOA10701620 ELECT CAP. 100UF 16V CCEA1CH101T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 211 CCKT1H102KB VIDEO C828 CER. CAP. 0.01UF 50V Z CCFT1H103ZF VIDEO C829 CER. CAP. 47PF 50V JC CCCT1H470JC VIDEO C830 CER. CAP. 47PF 50V JC CCCT1H470JC NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 212 C3A206 VIDEO J728 CORD SN95/PB5 0.6 C3A206 VIDEO J729 CORD SN95/PB5 0.6 C3A206 VIDEO J730 CORD SN95/PB5 0.6 C3A206 VIDEO J731 CORD SN95/PB5 0.6 C3A206 NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 213 C3A206 VIDEO J799 CORD SN95/PB5 0.6 C3A206 VIDEO J801 CORD SN95/PB5 0.6 C3A206 VIDEO J802 CORD SN95/PB5 0.6 C3A206 VIDEO J803 CORD SN95/PB5 0.6 C3A206 NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 214 C3A206 VIDEO R715 RES. 75 OHM 1/6W J CARBON CRD20TJ750T VIDEO R716 RES. 75 OHM 1/6W J CARBON CRD20TJ750T VIDEO R717 CORD SN95/PB5 0.6 C3A206 NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 215 RES. 75 OHM 1/6W J CARBON CRD20TJ750T VIDEO R794 RES. 75 OHM 1/6W J CARBON CRD20TJ750T VIDEO R795 RES. 3.3K OHM 1/6W J CARBON CRD20TJ332T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 216 00MDK96122300 CER. CAP. 1200PF 50V KC CCUS1H122KC C618 /U1B 00MDK96122300 CER. CAP. 1200PF 50V KC CCUS1H122KC C619 /U1B 00MDD95331300 CER. CAP. 330PF 50V JA CCUS1H331JA NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 217 100 OHM 1/10W J CRJ10DJ101T R527 /U1B 00MNN05101610 CHIP RES. 100 OHM 1/10W J CRJ10DJ101T R528 /U1B 00MNN05223610 CHIP RES. 22K OHM 1/10W J CRJ10DJ223T NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.
  • Page 218 00MNM11800020 CHIP RES. 180 OHM 1% 180 OHM 1% CRJ10DF1800T CRJ10DF1800T R813 /U1B 00MNM11800020 CHIP RES. 180 OHM 1% CRJ10DF1800T X501 /U1B 00D2623516908 X'TAL 45.1584 MHZ COX45158ISCR NOTE : "nsp" PART IS LISTED FOR REFERENCE ONLY, MARANTZ WILL NOT SUPPLY THESE PARTS.

  • Page 219: About Replace The Microprocessor With A New One

    When replaced of the U-PRO (Microprocessor) or the Flash ROM, confirm contents of the following. Pos. After Description Remark Name replaced IC17 M3087BFKBGP MAIN AV8003 IC34 ES29LV320ET70TG DSP AV8003 HD RADIO IC91 R5F21246SNFP HD RADIO SR8002 HDMI IC81 HD64F36049HV HDMI AV8003 STBY IC51 R5F21246SNFP DMP AV8003 After replaced A : Mask ROM (With software).

Table of Contents