Related Manuals for Rollerdor RD55
Summary of Contents for Rollerdor RD55
- Page 1 Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 Installation Guide Rollerdor RD55 Econ Roller Garage Doors Edition 2020/2...
-
Page 2: Table Of Contents
Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 CHECKLIST & COMPONENTS EQUIPMENT REQUIRED ROLLERDOR COMPONENT CHECKLIST CONTENTS • 2 x Step ladders or hop ups • Door Curtain. • Spirit level • Barrel Assembly (Barrel, Tube End, Security Springs, Security CHECKLIST &... -
Page 3: Preparing Site For Installation
Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 1. PREPARING SITE FOR INSTALLATION REQUIREMENTS FOR THE OPENING & TAKING MEASUREMENTS Name Address Requirements For The Opening & Taking Measurements Name: Address: Tel: PLAN OF WHERE TO TAKE MEASUREMENTS Plan Of... -
Page 4: Preparing Guide Runners For Installation
It will leave you with your desired width of the door. You would against the wall for a standard back fixing need a minimum of 65mm each side for the RD55 and 95mm for the RD77. or face out of the garage for a between... -
Page 5: Installing Header Assembly
Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 3. INSTALLING HEADER ASSEMBLY Place your hop ups / step ladders (For IMO system) remove winding stem and one guide runner each side of from your winding handle where it has been taped securely (fig.3.10.IMO). -
Page 6: Programming Remote Control Handsets
Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 4. INSTALLING (TYPE 1) RECEIVER BOX 4. INSTALLING (TYPE 1) RECEIVER BOX 5. PROGRAMMING REMOTE CONTROL HANDSETS (HOLD TO RUN) (HOLD TO RUN) (HOLD TO RUN) Carefully remove the cover by sliding it upwards... - Page 7 Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 6. INSTALLING (TYPE 2) RECEIVER BOX 7. PROGRAMMING REMOTE CONTROL HANDSETS AND (HOLD TO RUN) PUSH BUTTON (HOLD TO RUN) Re-attach the front box cable to the board. Remove the lid of the receiver box by unscrewing small screw at bottom (fig 6.1A)
- Page 8 Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 8. INSTALLING (TYPE 3) RECEIVER BOX 9. PROGRAMMING REMOTE CONTROL HANDSETS (HOLD TO RUN) (HOLD TO RUN) Remove the lid of the receiver box by squeezing Slide the cover down on the remote control handset each side at the bottom where the wires come and you will see there are four buttons (fig.9.1).
- Page 9 Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 10. INSTALLING (TYPE 1) RECEIVER BOX (SAFETY EDGE) Open the lid of the receiver box by unscrewing the Before plugging in, check to make sure that there are no bare cables touching and all wires are securely fixed.
-
Page 10: Somfy Optical Safety Edge (Rollixo Rts)
Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 11. SOMFY OPTICAL SAFETY EDGE SAFTEY BRAKE WIRING (ROLLIXO RTS) SOMFY ROLLIXO RTS CONTROL PANEL Sto p Safety Edg Sto p Safety Edg Sto p Safety Edg Sto p Safety Edg Sto p... -
Page 11: Setting Motor Limits
Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 12. SETTING MOTOR LIMITS (ALL HOLD TO RUN AND TYPE 1 SAFETY EDGE) Press and hold the down button on receiver box so the curtain starts to roll down to 300mm (roughly 6 slats) from top of the guide runners. -
Page 12: Setting Motor Limits (Somfy Rollixo Rts Only)
Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 13. SETTING MOTOR LIMITS (SOMFY ROLLIXO RTS ONLY) For somfy Rollixo RTS control panel you must press and hold the open and close buttons for 3 seconds to enter motor adjustment mode. The number 1 light will flash slowly and the door will judder up and down slightly to confirm motor adjustment mode has been entered. -
Page 13: Setting Up Wireless Safety Edge Kit (Optical Edge)
Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 14. SETTING UP WIRELESS SAFETY EDGE KIT PROGRAMMING RUN TIMERS & LIMITS (SAFETY EDGE) (OPTICAL EDGE) The curtain must be all the way down in the closed position before starting. Please be aware! During set up the Press and hold the “PROG”... -
Page 14: Setting Up Wireless Safety Edge Kit (Velocity Edge)
Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 15. SETTING UP WIRELESS SAFETY EDGE KIT PROGRAMMING RUN TIMERS & LIMITS (VELOCITY EDGE) (SAFETY EDGE) The curtain must be all the way down in the closed position before starting. Please be aware! During set up the Press and hold the “PROG”... -
Page 15: Programming Of Remote Control Handsets
Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 16. PROGRAMMING OF REMOTE CONTROL HANDSETS AND PUSH BUTTON (SAFETY EDGE) CLEARING MEMORY OF REMOTE CONTROL HANDSETS (SAFETY EDGE) Press and hold the “RADIO PROG” button (fig.16.3). You will hear a beep and the red LED alongside “C1”... - Page 16 Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 PAIRING THE SOMFY PAIRING THE SOMFY PAIRING THE SOMFY SAFETY EDGE TRANSMITTER PAIRING THE SOMFY PAIRING THE SOMFY 20 mm POSITIONING OF MAGNETS SAFETY EDGE TRANSMITTER (SAFETY EDGE TRANSMITTER) SAFETY EDGE TRANSMITTER...
-
Page 17: Installation Of Back Case
Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 17. INSTALLATION OF BACK CASE 20 mm 20 mm 20 mm 20 mm 20 mm 20 mm 20 mm 20 mm DELETING ALL SOMFY REMOTE CONTROLS DELETING ALL SOMFY REMOTE CONTROLS DELETING ALL SOMFY REMOTE CONTROLS... -
Page 18: Optional Extras
Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 18. OPTIONAL EXTRAS HARD WIRED ROCKER HARD WIRED ROCKER / KEY SWITCH / KEY SWITCH (HOLD TO RUN) (SAFETY EDGE) WIRING AS FOLLOWS: WIRING AS FOLLOWS: Receiver Box Green 6 Block Terminal (fig.18.3): Receiver Box Green 6 Block Terminal (fig. - Page 19 Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 WIRELESS KEY PAD WIRELESS KEY PAD (ONLY AVAILABLE WITH SAFETY EDGE SYSTEM) (ONLY AVAILABLE WITH SOMFY SAFETY EDGE SYSTEM) INSTALLATION Fit directly to the wall using the 2 fixings making sure it is level and square with the writing at the bottom.
- Page 20 7.6 alarm (optional) Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 If the safety edge is activated while the door is opening, it continues its efore the magnet movement. The alarm is triggered for 2 minutes if the door is fully closed and raised and .
- Page 21 Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 TROUBLESHOOTING TROUBLESHOOTING I was setting the door up The motor for the door is a friction drive and as such will generate heat. If When closing the door it came Check to make sure the security straps are ok and are not broken or...
- Page 22 Rollerdor RD55 Econ Roller Garage Door, Edition 2020/2 NOTES...
- Page 23 10 & 12 Jarrold Way Bowthorpe Employment Area Norwich Norfolk NR5 9JD +44 (0)1603 743215 sales@rollerdor.net www.rollerdor.net Company Registration Number. 10676267 Registered Office Address: Rollerdor Ltd, Bankside 300 Peachman Way, Broadland Business Park, Norwich, Norfolk, United Kingdom, NR7 0LB Edition 2020/2...
Need help?
Do you have a question about the RD55 and is the answer not in the manual?
Questions and answers