Related Manuals for Hussmann EcoVision II Plus Door Upgrade
Summary of Contents for Hussmann EcoVision II Plus Door Upgrade
- Page 1 EcoVision II Plus Door Upgrade for Tyler N6D Multi-deck Merchandisers Installation & Service Manual P/N 0530690_B November 2013 IMPORTANT Spanish 0538854 Keep in store French 0538855 for future reference!
- Page 2 BEFORE YOU BEGIN Read these instructions completely and carefully. PERSONAL PROTECTION EQUIPMENT (PPE) Personal Protection Equipment (PPE) is required whenever servicing this equipment. Always wear safety glasses, gloves, protective boots or shoes, long pants, and a long-sleeve shirt when handling glass.
-
Page 3: Table Of Contents
EcoVision II Plus Door Upgrade Installation Manual P/N 0530690_B Table of Contents PREPARATION Revision History ......iv ANSI Definitions . -
Page 4: Revision History
• NOTICE – Not related to personal injury – Indicates[s] situations, which if not avoided, could result in damage to equipment. U.S. & Canada 1-800-922-1919 • Mexico 01-800-890-2900 • www.hussmann.com... -
Page 5: Shipping Damage
EcoVision II Plus Door Upgrade Installation Manual P/N 0530690_B SHIPPING DAMAGE All equipment should be thoroughly examined EcoVision II Plus doors may be installed for shipping damage before and during unload- without the need to remove product from the ing. - Page 6 All steps of settting, joining and case leveling attention to the glass position is critical. Do not attempt to make glass adjustments prior to case leveling. U.S. & Canada 1-800-922-1919 • Mexico 01-800-890-2900 • www.hussmann.com...
- Page 7 EcoVision II Plus Door Upgrade Installation Manual P/N 0530690_B Screw #8-32 #8-32 x ½ (¼ × ¾ in. Thread Cutting Hex Washer Head Screw Shoulder Screw Hex Head Thread Cutting) Self-Tapping Head (black/gray) TORX Head Type F (¼- in.) 2-4ft...
- Page 8 A. Fasten canopy support bracket to canopy support. B. Fasten left and right gussets to canopy support. Figure 4-2 — Left Gusset Figure 4-1 — Canopy Support Bracket Figure 4-3 — Right Gusset U.S. & Canada 1-800-922-1919 • Mexico 01-800-890-2900 • www.hussmann.com...
-
Page 9: Installing Ecovision Ii Plus Canopy Support
EcoVision II Plus Door Upgrade Installation Manual P/N 0530690_B Installing EcoVision II Plus Canopy Support A. Center the canopy support inside the channel at the top of the case. Fasten the first screw at the center of the canopy support. The canopy support may need to be adjusted later (after the mullions are installed). -
Page 10: Pre-Assemble Light Channel
Plus light channel. B. Attach LEDs to the light channel. Installing Mullions A. Attach the end mullions first. NOTE: End mullions may be used on the left, or the right side of merchandiser. U.S. & Canada 1-800-922-1919 • Mexico 01-800-890-2900 • www.hussmann.com... - Page 11 EcoVision II Plus Door Upgrade Installation Manual P/N 0530690_B B. Attach center mullion(s). C. The goal is to make sure the mullions are 90° in relation to the bottom rail and the can- opy. To do this, measure from back of case to front of mullion at bottom of case.
-
Page 12: Installing Bottom Gasket Retainers
Installing Light Channel A. Plug LED harness into canopy. Tuck wiring into channel. B. Fasten the center screw first (6 screws #10). Install light channel cover 10 screws (8ft). U.S. & Canada 1-800-922-1919 • Mexico 01-800-890-2900 • www.hussmann.com... - Page 13 EcoVision II Plus Door Upgrade Installation Manual P/N 0530690_B Installing Bottom Horizontal Gasket Wiper and Vertical Wipers A. Start at the left end of the case. Push wipers into place, working left to right. Wipers snap into place. HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
-
Page 14: Installing Split Rail Hinge Plate Assembly
Slide hinge plate assembly right, and the left door will raise, right door goes down. Once level screw down (5 places) on hinge plate assembly. U.S. & Canada 1-800-922-1919 • Mexico 01-800-890-2900 • www.hussmann.com... - Page 15 EcoVision II Plus Door Upgrade Installation Manual P/N 0530690_B Install EcoVision II Plus Door(s). B. Raise door up and position torsion rod at Adjust closing tension on each door the bottom of the door into bottom hinge plate as it is installed as shown in Step 19 hole as shown in Fig.
- Page 16 To Correct Shift the Bottom Plate to the Left To correct shift the bottom plate to the left! To correct shift the bottom plate to the right! STEP 1 U.S. & Canada 1-800-922-1919 • Mexico 01-800-890-2900 • www.hussmann.com STEP 2...
- Page 17 EcoVision II Plus Door Upgrade Installation Manual P/N 0530690_B Door Hold Open EcoVision doors have a door hold open latch that allows the doors to remain in an open position. This feature is especially useful for stocking the merchandiser with product or cleaning the merchandiser’s interior.
-
Page 18: Tightening Torsion Rods
This feature is especially useful for stocking the merchandiser with product or cleaning the merchandiser’s interior. Fasten hold open cam screw as shown. Never spread cam with screw driver! U.S. & Canada 1-800-922-1919 • Mexico 01-800-890-2900 • www.hussmann.com... - Page 19 EcoVision II Plus Door Upgrade Installation Manual P/N 0530690_B Increase / Decrease door tension The door’s closing speed may be adjusted by rotating the adjustable tension rods near the hinge of each door. Open door to 90° and lift up weight of door to prevent damage to plate bottom when adding door tension.
-
Page 20: Replace Canopy Fascia
Figure 20-1 Fasten Canopy Fascia Figure 20-2 Canopy Fascia Check Door Open and Closing A. Doors should now open and close smoothly and at the same rate. Figure 21-1 Doors Installed U.S. & Canada 1-800-922-1919 • Mexico 01-800-890-2900 • www.hussmann.com... -
Page 21: Start Up / Stocking
EcoVision II Plus Door Upgrade Installation Manual P/N 0530690_B Start up / Stocking Locate the merchandiser’s refrigerant settings and defrost requirements. Bring merchandisers down to the operating temperatures listed on the data sheet. Product should NOT be placed in merchandisers until merchandiser is at proper operating temperature. -
Page 22: Technical Guideline For Case And Refrigeration System Adjustments
The superheat setting on the valve up, be utilized to optimize case performance may require changing to achieve optimal and increase energy savings. Rear-load cases performance of the case. must have an EPR added. U.S. & Canada 1-800-922-1919 • Mexico 01-800-890-2900 • www.hussmann.com... - Page 23 EcoVision II Plus Door Upgrade Installation Manual P/N 0530690_B If a mechanical EPR is used, sizing to the new load must be considered. NOTE: Pay particular attention to affected circuits that are fed by a satellite compressor If an electronic EPR is used, the existing or conventional unit.
- Page 24 35 percent or more, the HVAC system needs to be evaluated to see if it can handle the entire air-conditioning load. U.S. & Canada 1-800-922-1919 • Mexico 01-800-890-2900 • www.hussmann.com...
Need help?
Do you have a question about the EcoVision II Plus Door Upgrade and is the answer not in the manual?
Questions and answers