Problems That May Be Encountered During Use; Problems That May Be Encountered During Incubation - Borotto REAL Series Instruction Manual

10 – Problems that may be encountered during use
PROBLEM
The product or its accessory does
not switch on
Does not reach the required
temperature
An accessory does not work
11 – Problems that may be encountered during incubation
PROBLEM
Clear eggs. There are no blood
vessels (through candling).
Blood rings visible in candling
Many dead embryos or chicks
that die before pipping
The eggs explode
Chicks with lower limb
malformations
POSSIBLE CAUSE
Disconnected cable
Damaged cable
Other
Unsuitable room temperature
Thermostat does not work
Resistor does not heat
Damaged product parts that cause
heat dispersal
Disconnected cable
Damaged cable or component
Other
POSSIBLE CAUSE
Non-fecundated eggs due to too many or
too few cockerels, old or infertile.
Egg storage was too long before incubation.
The temperature in the egg storage room
was too high or low.
Inadequate egg care before incubation.
Low egg collection frequency
Breeders are inbred
Old eggs.
Aged breeders.
Nutritional deficiencies
Eggs have travelled long distances.
Incorrect humidity during incubation.
The incubator has been opened several
times during hatching.
The incubator has been operating in
excessively hot or cold premises
Bacterial contamination
Other causes
The eggs are dirty
Incorrect humidity during incubation.
Inbred breeders
The incubator has been operating in
premises with temperature below 20°C
SUGGESTION
Connect the cable
Request technical support for the repair
Request technical support
Move to another room
Request technical support
Request technical support
Request technical support
Connect the cable
Request technical support for the repair
Request technical support
SUGGESTION
Only use young, zestful and unrelated cocks
and not exceeding 3 years of age
Do not store the eggs longer than 7 days.
Ensure the temperature in the egg storage
room is between 14°C and 18°C.
Check proper egg storage.
Collect the eggs more often throughout the
day.
The breeders must not be related
(the cock MUST NOT be the hen's brother)
Store the eggs for 7 days at most.
The breeders must not be older than 3
years.
Feed breeders with adequate feed (use
breeding feed)
Incubate local eggs.
Comply with the information provided on
filling the water trays.
Open once a day at most to remove
properly dry hatchlings.
Ensure the room temperature is between
20°C and 25°C.
Disinfect the incubator before use.
Ensure the eggs are properly clean.
ADHERE TO CHAPTERS 6 and 7.1.2.3.4!
Incubate clean eggs
Comply with the information provided on
filling the water trays.
Do not pour water out of the trays
The breeders must not be related
Ensure room temperature is at least 20°C
Page 15 of 20
Rev 01