Advertisement
Quick Links
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
Instruction No
Instruction No
Version
Version
31346062
31346062
1.2
1.2
© Volvo Car Corporation
Part. No.
Part. No.
31346058, 31414907
31346058, 31414907
Towbar, wiring, 13-pin
Towbar, wiring, 13-pin
Towbar, wiring, 13-pin- 31346062 - V1.2
Page 1 / 22
Advertisement
Related Manuals for Volvo 31346058
Summary of Contents for Volvo 31346058
- Page 1 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Instruction No Instruction No Version Version Part. No. Part. No. 31346062 31346062 31346058, 31414907 31346058, 31414907 Towbar, wiring, 13-pin Towbar, wiring, 13-pin © Volvo Car Corporation Towbar, wiring, 13-pin- 31346062 - V1.2...
- Page 2 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Equipment IMG-345497 IMG-300203 IMG-239664 IMG-273338 © Volvo Car Corporation Towbar, wiring, 13-pin- 31346062 - V1.2 Page 2 / 22...
- Page 3 Explanatory text is also given for more complicated steps. In the event of any problems with the instructions or the accessory, contact your local Volvo dealer. Applies to the S40 (04–) and V50 Applies to the S40 (04–) and V50 Turn the ignition key to position 0.
- Page 4 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the four screws for the bumper. The screws are underneath the bumper and on the sides at the bottom of the boot lid opening. IMG-346192 Remove the five screws (1) holding the bumper cover at the rear edge of the wing liner in the rear wheel arch.
- Page 5 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the end of the bumper cover. Grasp the bumper cover inside the wing liner. Pull carefully until the six catches at the top edge release. Repeat on the other side. J8504526 Remove the bumper cover by pulling it straight backwards.
- Page 6 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Applies to the V50 Remove the cargo compartment carpet. IMG-273472 Prize off the four external clips at the front edge/bottom edge of the sill trim panel on the tailgate. Pry up one of the corners of the sill trim panel so that the two clips at that end release.
- Page 7 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Fold the seat cushion and backrest on the right-hand side of the rear seat forward. J8504578 Grasp the upper edge of the right-hand side cushion. Pull the side cushion forward so that the clip on the reverse releases.
- Page 8 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the screw. Pull the panel upwards so that the four clips on the inside release. Remove the panel. IMG-240927 Pull off the rubber strip at the rear of the opening for the right- hand rear door.
- Page 9 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Fold out the anchorage eyelets. Insert a scriber with an angled tip into the holes in the top of the covers (1). Turn the scriber so that the tip engages the reverse of the covers.
- Page 10 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the insulation panel on the right-hand side. It is secured with two clips. J8504615 Applies to S40 (04-) Applies to S40 (04-) Remove the cargo compartment carpet. J8504553 © Volvo Car Corporation Towbar, wiring, 13-pin- 31346062 - V1.2...
- Page 11 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the upper floor supports on the left and right-hand sides if applicable. J8504552 Unscrew the two external clips at the front edge/bottom edge of the sill trim panel on the tailgate.
- Page 12 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the three clips (1) that hold the right-hand side panel in the bodywork. Unhook the side panel from the mounting (2) on the underneath of the parcel shelf. Fold out the rear edge of the side panel from the bodywork. At the same time unhook the side panel from the rear load securing eyelet.
- Page 13 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Installing the trailer hitch connector, applies to the S40 (04-) and V50 Install the trailer hitch connector with cable harness to the bracket on the left-hand side of the tow bar. Use screws and nuts from the kit.
- Page 14 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Applies to the V50 Pull up the cable to the plastic bracket, route it to the right and secure it using two cable ties from the kit as illustrated. IMG-273185 Applies to all models...
- Page 15 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Take the pliers and widen the hole in the rubber grommet. Pull the wiring through. Adjust the length of the cable harness up to the rubber grommet. J8903624 Insert the cable harness into the cargo compartment through the hole in the car body.
- Page 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Applies to V50 models without RTI Remove the screw and the nut holding the AM/FM tuner module (AFM) in the bodywork. Disconnect the wiring if necessary. Place the AM/FM tuner module (AFM) to one side.
- Page 17 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Applies to all models Pull the cable harness from the towbar. J8903623 Take the connector from the kit. Release the connector's secondary lock. Use: Electrician's screwdriver IMG-347737 © Volvo Car Corporation Towbar, wiring, 13-pin- 31346062 - V1.2...
- Page 18 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Take the connector and install the cable ends as follows: Position Cable Function Pink Reversing lamp Not used White Ground Not used Grey Power supply Not used Brown Right parking lamps Black...
- Page 19 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Applies to S40 (04-) Connect the connector from the wiring to the control module. IMG-359686 Connect the ground lead from the routed cable harness to the ground terminal under the tail lamp. Tighten the screw.
- Page 20 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Applies to the V50 Connect the connector from the wiring to the control module. IMG-359695 Connect the ground lead from the routed cable harness to the ground terminal under the tail lamp. Tighten the screw fully.
- Page 21 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Connect the white 2 pin male connector (1) in the pre-routed cable harness, to the existing white clamped 2 pin female connector (2) at the rear edge of the wheel housing. Take a cable tie from the kit and clamp the remaining white connector (3) on the pre-routed cable harness at existing cables at the rear edge of the wheel housing.
-
Page 22: Position Function
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Applies to all models Note! For correct function, the trailer module (TRM) must be programmed with software before checks can be carried out. Checking the 13 pin connector. Note! To activate the trailer module (TRM) at least two light sources (lamps) must be connected.