Installing A New Battery; Alternator Maintenance - Barko 6025 Service Manual

INSTALLING A NEW BATTERY

INSTALLING A NEW BATTERY
INSTALLING A NEW BATTERY INSTALLING A NEW BATTERY INSTALLING A NEW BATTERY
1. Remove battery cables. Remember position of positive terminal and negative terminal so you can connect them
again correctly.
2. Remove battery hold-down bar. Remove battery from compartment.
3. Clean terminal posts of new battery and cable connections with wire brush.
4. Install new battery in compartment. Install hold-down bar.
5. Install and tighten battery cables. Connect negative cable last to prevent sparks.
Do not touch battery terminals with any metal. Do not touch battery terminals with any metal. Do not touch battery terminals with any metal. Do not touch battery terminals with any metal. Do not touch battery terminals with any metal.
to battery and personal injury. to battery and personal injury.
to battery and personal injury. to battery and personal injury. to battery and personal injury.

ALTERNATOR MAINTENANCE

ALTERNATOR MAINTENANCE ALTERNATOR MAINTENANCE
ALTERNATOR MAINTENANCE ALTERNATOR MAINTENANCE
CHECKING THE WIRING CHECKING THE WIRING CHECKING THE WIRING CHECKING THE WIRING CHECKING THE WIRING
1. Turn the starter switch on.
2. Connect a volt meter between the ground and:
(See Figure 2.)
a) The No. 1 alternator connector.
b) The No. 2 alternator connector.
c) The "BAT" connector.
3. If any of these tests show zero voltage, repair or
replace wiring.
4. Check voltage again until correct reading appears.
ELECTRICAL SYSTEM MAINTENANCE CONTINUED...
240 Harvester Feller/
Buncher
WARNING WARNING
WARNING WARNING WARNING
Sparks may occur, causing damage Sparks may occur, causing damage Sparks may occur, causing damage Sparks may occur, causing damage Sparks may occur, causing damage
No. 1 terminal No. 1 terminal No. 1 terminal No. 1 terminal No. 1 terminal
"BAT" terminal "BAT" terminal "BAT" terminal "BAT" terminal "BAT" terminal
page 32 page 32 page 32 page 32 page 32
Alternator Alternator Alternator Alternator Alternator
No. 2 terminal No. 2 terminal No. 2 terminal No. 2 terminal No. 2 terminal
Figure 2 Figure 2 Figure 2
Figure 2 Figure 2