Using An Extra Battery To Start Machine - Barko 6025 Service Manual

USING AN EXTRA BATTERY TO START MACHINE

USING AN EXTRA BATTERY TO START MACHINE USING AN EXTRA BATTERY TO START MACHINE USING AN EXTRA BATTERY TO START MACHINE USING AN EXTRA BATTERY TO START MACHINE
If necessary to use an extra battery and "jumper" cables to start engine, be careful. This is a two-person operation.
There must be one person in operator's seat and one person to connect and disconnect battery cables.
Lead-acid batteries produce flammable and explosive gases. Lead-acid batteries produce flammable and explosive gases. Lead-acid batteries produce flammable and explosive gases.
Lead-acid batteries produce flammable and explosive gases. Lead-acid batteries produce flammable and explosive gases.
flames and lighted tobacco away from battery. flames and lighted tobacco away from battery. flames and lighted tobacco away from battery. flames and lighted tobacco away from battery. flames and lighted tobacco away from battery.
warnings are not followed. warnings are not followed. warnings are not followed. warnings are not followed. warnings are not followed.
1. Make sure ignition is in "OFF" position.
2. Be sure battery to be used is of same voltage as battery in machine (24 Volt).
3. Battery terminals have identification marks. Positive terminal is marked (+) and negative terminal is marked (-).
When When using an extra battery to "jump" start an engine, make connections in using an extra battery to "jump" start an engine, make connections in
When When When using an extra battery to "jump" start an engine, make connections in using an extra battery to "jump" start an engine, make connections in using an extra battery to "jump" start an engine, make connections in
order given in this manual. order given in this manual. order given in this manual.
order given in this manual. order given in this manual.
Do not touch battery terminals with any metal or allow jumper cable ends to touch Do not touch battery terminals with any metal or allow jumper cable ends to touch
Do not touch battery terminals with any metal or allow jumper cable ends to touch Do not touch battery terminals with any metal or allow jumper cable ends to touch Do not touch battery terminals with any metal or allow jumper cable ends to touch
each other. each other. each other.
each other. each other.
4. Make sure master Battery OFF/ON switch is ON.
5. Connect negative and positive jumper cable leads to auxillary battery terminals (positive to positive, negative to
negative). Then connect to vehicle battery.
6. When engine starts allow it to run at idle. Turn on all electrical (lights, etc.). Disconnect jumper cables.
7. Check all instruments directly after starting, and then regularly during operation.
DO NOT connect last jumper cable end directly to negative terminal (-) of machine battery. This can cause spark to
destroy battery and cause personal injury should battery explode. Connect last jumper cable to a metal part of engine.
Battery electrolyte is highly corrosive. Battery electrolyte is highly corrosive. Battery electrolyte is highly corrosive. Battery electrolyte is highly corrosive. Battery electrolyte is highly corrosive.
protective goggles and gloves. If acid comes into contact with your skin, wash at once with protective goggles and gloves. If acid comes into contact with your skin, wash at once with protective goggles and gloves. If acid comes into contact with your skin, wash at once with protective goggles and gloves. If acid comes into contact with your skin, wash at once with protective goggles and gloves. If acid comes into contact with your skin, wash at once with
soap and a lot of water. If you get acid in your eyes, flush at once with a lot of cold water soap and a lot of water. If you get acid in your eyes, flush at once with a lot of cold water soap and a lot of water. If you get acid in your eyes, flush at once with a lot of cold water soap and a lot of water. If you get acid in your eyes, flush at once with a lot of cold water soap and a lot of water. If you get acid in your eyes, flush at once with a lot of cold water
and get medical attention at once. and get medical attention at once.
and get medical attention at once. and get medical attention at once. and get medical attention at once.
7. Check to be sure cables are away from fans and belts.
8. Start machine engine.
9. After engine starts, remove negative jumper cable connected to engine FIRST.
10. Next remove jumper cable from machine battery positive (+) terminal.
11. Then remove jumper cables from extra battery.
Do not jump start or charge a frozen battery. Do not jump start or charge a frozen battery. Do not jump start or charge a frozen battery.
Do not jump start or charge a frozen battery. Do not jump start or charge a frozen battery.
degrees C) before connecting to a charger. degrees C) before connecting to a charger.
degrees C) before connecting to a charger. degrees C) before connecting to a charger. degrees C) before connecting to a charger.
or disconnecting cables at battery. or disconnecting cables at battery.
or disconnecting cables at battery. or disconnecting cables at battery. or disconnecting cables at battery.
ELECTRICAL SYSTEM MAINTENANCE CONTINUED...
Sparks may occur, causing damage to battery and personal injury. Sparks may occur, causing damage to battery and personal injury. Sparks may occur, causing damage to battery and personal injury.
Sparks may occur, causing damage to battery and personal injury. Sparks may occur, causing damage to battery and personal injury.
240 Harvester Feller/
Buncher
WARNING WARNING WARNING
WARNING WARNING
An explosion may occur if these An explosion may occur if these An explosion may occur if these An explosion may occur if these An explosion may occur if these
WARNING WARNING WARNING
WARNING WARNING
WARNING WARNING WARNING
WARNING WARNING
WARNING WARNING
WARNING WARNING WARNING
Protect your eyes, skin and cloths. Always use Protect your eyes, skin and cloths. Always use Protect your eyes, skin and cloths. Always use Protect your eyes, skin and cloths. Always use Protect your eyes, skin and cloths. Always use
WARNING WARNING WARNING
WARNING WARNING
Warm battery to 60 degrees F (16 Warm battery to 60 degrees F (16 Warm battery to 60 degrees F (16
Warm battery to 60 degrees F (16 Warm battery to 60 degrees F (16
Unplug charger before connecting Unplug charger before connecting
Unplug charger before connecting Unplug charger before connecting Unplug charger before connecting
Battery gas can explode and cause serious injury. Battery gas can explode and cause serious injury.
Battery gas can explode and cause serious injury. Battery gas can explode and cause serious injury. Battery gas can explode and cause serious injury.
page 31 page 31 page 31 page 31 page 31
Keep arcs, sparks, Keep arcs, sparks, Keep arcs, sparks,
Keep arcs, sparks, Keep arcs, sparks,