Table of Contents
Advertisement
SAFETY PRECAUTIONS
Improper installation and operation could cause
personal injury and/or equipment and property damage.
Read and understand labels and the Owner's Manual
before installing, operating or making adjustments.
WARNING
Lower blade when vehicle is parked.
Temperature changes could change
hydraulic pressure, causing the blade to
drop unexpectedly or damaging hydraulic
components. Failure to do this could result in
serious personal injury.
WARNING
The driver shall keep bystanders clear of the
blade when it is being raised, lowered or angled.
Do not stand between the vehicle and the blade
or within 8 feet of a moving blade. A moving or
falling blade could cause personal injury.
WARNING
Keep hands and feet clear of the blade and
A-frame when mounting or removing the
snowplow. Moving or falling assemblies could
cause personal injury.
WARNING
Do not exceed GVWR or GAWR including
blade and ballast. The rating label is found on
driver-side vehicle door cornerpost.
WARNING
To prevent accidental movement of the blade,
always turn the control OFF whenever the
snowplow is not in use. The power indicator
light will turn OFF.
WARNING
Remove blade assembly before placing
vehicle on hoist.
CAUTION
Refer to the current Selection List for
minimum vehicle recommendations and
ballast requirements.
Lit. No. 64369, Rev. 04
SAFETY
HYDRAULIC SAFETY
Hydraulic fl uid under pressure can cause skin
injection injury. If you are injured by hydraulic
fl uid, get medical attention immediately.
•
Always inspect hydraulic components and hoses
before using. Replace any damaged or worn parts
immediately.
•
If you suspect a hose leak, DO NOT use your
hand to locate it. Use a piece of cardboard or
wood.
FUSES
The WESTERN
contain several blade-style automotive fuses. If
a problem should occur and fuse replacement is
necessary, the replacement fuse must be of the same
type and amperage rating as the original. Installing a
fuse with a higher rating can damage the system and
could start a fi re. Fuse Replacement, including fuse
ratings and locations, is located in the Maintenance
Section of the Owner's Manual.
PERSONAL SAFETY
•
Remove ignition key and put the vehicle in park or
in gear to prevent others from starting the vehicle
during installation or service.
•
Wear only snug-fi tting clothing while working on
your vehicle or snowplow.
•
Do not wear jewelry or a necktie, and secure long
hair.
•
Wear safety goggles to protect your eyes from
battery acid, gasoline, dirt and dust.
•
Avoid touching hot surfaces such as the engine,
radiator, hoses and exhaust pipes.
•
Always have a fi re extinguisher rated BC handy,
for fl ammable liquids and electrical fi res.
4
WARNING
electrical and hydraulic systems
®
June 15, 2010
Advertisement
Table of Contents
