Convertible facepiece.
for air purifying respirator (apr), continuous flow supplied air respirator
(cf–sar), and powered air purifying respirator (papr) configurations (40 pages)
V. USE INSTRUCTIONS ......6 The SPERIAN Panther HIP-PAC consists of a refillable A. Air Supply ........6 cylinder, valve and pressure gauge assembly, first stage B.
Page 4
Always wear the apparatus. • All persons using this SPERIAN respi- proper head, ear, and eye protection. rator must be made aware of its limita- • This respirator is designed for use in tions.
Page 5
• Users must clean and maintain this respirator only in accordance with SPERIAN’s instructions. Accessories not offered by SPERIAN may degrade performance, and will void NIOSH cer- tification. • The respirator facepiece assembly contains natural rubber latex which may cause allergic reactions in some individuals.
Panther HIP-PAC LOW PRESSURE 2216 PSIG & 3000 PSIG HIP PAC PARTS LIST Item DESCRIPTION Item DESCRIPTION 962266 Nosecup Kit, TwentyTwenty, Twenty Twenty Plus Classic Facepiece, Standard, Black 968416 Facepiece, Large, Clear Classic Facepiece, Small, Black 968417 702064 Nosecup Kit, TwentyTwenty, Twenty Twenty Plus 21 SeriesFacepieces w/ Drink Tube** 2120XX Series Facepiece, Small, Black...
Page 7
Panther HIP-PAC HIGH PRESSURE 4500 PSIG HIP PAC PARTS LIST Item DESCRIPTION Item DESCRIPTION Classic Facepiece, Standard, Black 968416 Communications Classic Facepiece, Small, Black 968417 964331 TwentyTwenty Plus Radio Communication System 21 Series Facepieces w/ Drink Tube** SmallTalk Plus Voice Amplifier Kit 2120XX Series 964332 TwentyTwenty Plus Radio Communication/SmallTalk Plus...
Do not combine different series of g. If the leaks persist, remove the hose from ser- hoses or coupler assemblies. vice and have repairs made by a SPERIAN-certifi ed • The NIOSH approval applies to the use of the splitter (suit bypass) only technician.
If the leaks persist, remove the hose from ser- stage hose so that it routes under your left arm. (If the vice and have repairs made by a SPERIAN-certified hose is too tight, adjust the cylinder nearer the small of your back.)
Page 10
Panther HIP-PAC ii. If your SCBA is equipped with a neck strap, place the neck strap over your head. iii. Grasp the lower headstraps as shown in Figure 6. Figure 5. Waist Belt D-ring 9. Insert the second stage regulator into the regulator receiver on the waist belt.
Place your chin in the chin cup, pull the cleaning and disinfecting, anti-fog solution elastic adjustment strap over your head, and (SPERIAN P/N 951015, 951016, OR 981805) tighten by pulling evenly on both sides. See must be applied to the inside of the lens.
Page 12
Panther HIP-PAC NOTE NOTE Steps 1-3 apply to conventional facepieces The second stage regulator release buttons only. must be pressed simultaneously to remove 1. Place the palm of your hand over the AIR KLIC as the regulator from the holder. shown in Figure 9.
If the free flow continues, open and close the by- cylinder valve must be wrench-tight. pass once, or depress the manual override button once. c. If the problem persists, IMMEDIATELY exit to a safe area. d. Have the HIP-PAC inspected and/or repaired by a SPERIAN-certified repair technician before reuse.
A. Conventional Facepiece Cleaning NOTE Silicone and rubber parts of the facepiece may be cleaned between washings with SPERIAN Mask Wipes, P/N 140096. 1. Make a cleaning solution of warm water and a mild detergent. 2. Fully immerse the facepiece in the solution.
• After each use and/or after cleaning and facepiece lens. Use only SPERIAN Anti- disinfecting, SPERIAN anti-fog solution, Fog Solution, P/N 951015 (1 oz.), or P/N (P/N 951015, 951006, or 981805) must be 951016 (16 oz.).
8. After cleaning and disinfecting the hood, liber- 5. Dry with a clean cloth or with low pressure (15 psig ally apply SPERIAN anti-fog solution, P/N 951015, maximum) clean (breathing grade) air. 951016, or 981805 to the inside of the lens and allow it to dry thoroughly.
WARNING—Continued are required to remain current on new • Do not fill a composite cylinder if it procedures and parts through SPERIAN’s is not marked as being hydrostatically published Technical Bulletins, technical tested within three (3) years. Do not fill an...
Page 18
Panther HIP-PAC to filling. Composite and aluminum cylinders may b. Composite Cylinders be filled only to the service pressure indicated on Ensure that no more than three years have elapsed the cylinder label. Composite and aluminum cylin- since the last hydrostatic test has been performed ders must never be filled to a pressure greater than for the 3000 psig, hoop wrapped cylinder and five the marked service pressure.
If the exhalation valve continues to malfunc- SPERIAN recommends a “change of season” inspection tion, remove the facepiece from service. and increased attention to your preventive maintenance during cold weather conditions. The following recom- vii.
Page 20
Have the facepiece inspected and/or repaired g. If the shutoff button is nonfunctional, turn off the by a SPERIAN-certified repair technician before air supply at the cylinder valve. reuse. h. Remove the facepiece and regulator as a unit.
Panther HIP-PACs converted to sup- the facepiece into storage. Coat the interior of the plied air respirators (SARs) without es- facepiece lens with SPERIAN anti-fog solution, P/N cape cylinders must have the bypass 951015 or 951016. removed by a SPERIAN-certified techni- 8.
12 years from the date of purchase. During this period, SPERIAN will repair or replace defective parts, at SPERIAN’s option. Freight charges to and from the SPERIAN factory shall be paid by the purchaser. EXCLUSIONS: NOTWITHSTANDING ANY CON- TRARY TERM IN THE PURCHASER’S PURCHASE...
Panther HIP-PAC VIII. INSPECTION TABLE IF ANY OF THE DEFECTS LISTED BELOW ARE FOUND, HAVE THE PANTHER HIP-PAC REPAIRED BEFORE USE. COMPONENT LOOK FOR 1. Nicks, scratches, or abrasions which could impair visibility. CONVENTIONAL FACEPIECE LENS 2. Deep gouges or cracks which could reduce impact resistance. 3.
18. Perform a leak check as described in OPERATION INSTRUCTIONS, or conduct a facepiece leak test on the SPERIAN Portable Test Console. NOSE CUP (CLASSIC FACEPIECE)▲ ▲1. Unscrew and remove the exhalation module.
Panther HIP-PAC X. FUNCTIONAL TESTING TABLE IF ANY DEFECTS ARE FOUND, HAVE THE PANTHER HIP-PAC REPAIRED BEFORE USE. COMPONENT INSTRUCTIONS CONVENTIONAL FACEPIECE 1. Don and adjust the facepiece. 2. Block the AIR KLIC opening with the palm of your hand. 3.
(Suit Bypass), P/N 930856, only with the nitrile rubber hose and Snap-tite quick coupler. The splitter is tions before donning. approved to be used in conjunction with the SPERIAN Special or Critical User's Instructions Suit Pass-through Kit, P/N 980200. This approval ap- plies only when the respirator is supplied with respirable 1.
Need help?
Do you have a question about the Panther Hip-Pac P9684 Series and is the answer not in the manual?
Questions and answers