Table of Contents
Advertisement
10.3 BATTERY
Inspect the battery at least once every six
months and before using the seed tender at the
beginning of the season. Always follow the safety
instructions when servicing a battery.
10.3.1 Battery Safety
1.
K eepallsparksandflamesawayfrom
batteries, as gas given off by electrolyte
is explosive.
2.
Avoid contact with battery electrolyte:
wash off any spilled electrolyte
immediately because battery acid can
cause severe chemical burns.
3.
Wear safety glasses when working
near batteries.
4. Do not tip batteries more than 45 degrees, to
avoid electrolyte loss.
5.
To avoid injury from spark or short
circuit, disconnect the battery ground
cable before servicing any part of the
electrical system. Never short circuit
the battery. It may explode.
6.
Protect battery terminals, battery-
charger terminals, and cables against
accidental contact which can cause
sparks, explosions, or component
damage.
7. Never attempt to jump start a frozen battery.
38
10.3.2 Battery Replacement and
Maintenance Tips
• Check the batteries at least every six months for
low Voltage, leakage, etc.
• Always use the correct size and type of battery.
Replace old batteries with a new SP-30 Lawn
and Garden battery with 230 CCA and 290 CA
ratings.
• Do not install the battery cable to the wrong
terminal. Make sure the RED cable is connected
to the + (plus) terminal and the BLACK cable is
connected to the – (minus) terminal.
• Remove the batteries from the seed tender if not
expected to be in use for several months.
• Use recommended practices when recharging a
dead battery.
• Remove any corrosion from the battery post
using a wire brush terminal cleaner. Corrosion
can also be removed using a baking soda paste
and water to neutralize and remove the acid
from the battery terminals
• Dispose of old batteries properly.
10.3.3 Battery Maintenance
1. Make sure the tie-down strap is connected
to the frame of the battery box and in good
condition (not cracked, cut, or damaged).
Advertisement
Table of Contents
