Industrial intel atom e3900 series (intel atom processor x series) nano-itx single board computer (sbc) (64 pages)
Summary of Contents for WinSystems PCM-586
Page 1
Artisan Technology Group is your source for quality new and certified-used/pre-owned equipment SERVICE CENTER REPAIRS WE BUY USED EQUIPMENT • FAST SHIPPING AND DELIVERY Experienced engineers and technicians on staff Sell your excess, underutilized, and idle used equipment at our full-service, in-house repair center We also offer credit for buy-backs and trade-ins •...
TA BLE OF CON TENTS Sec tion Para graph Page Num ber Ti tle Num ber Gen eral In for ma tion Fea tures Gen eral De scrip tion Speci fi ca tions PCM- 586 Tech ni cal Ref er ence In tro duc tion ACC Mi cro 2089 Proc es sor/Chipset Real Time Clock/Cal en dar...
Page 5
PCM- 586 Sili con Disk Ref er ence In tro duc tion ROM DISK us age Boota ble RAM DISK us age Non- Bootable RAM DISK us age Non- Bootable FLASH DISK us age Disk On Chip us age Se rial Con sole Reference In tro duc tion Win com.exe Se rial Con sole Cli ent Get ting Started with the Se rial Con sole...
Al ter nately, the M-Systems’ Disk On Chip FLASH mod ules may be popu lated and disk sizes range from 2 Mega bytes to 72 Mega bytes. 021402 OPERATIONS MANUAL PCM-586 Page 1-1 Artisan Technology Group - Quality Instrumentation ... Guaranteed | (888) 88-SOURCE | www.artisantg.com...
WinSystems - "The Embedded Systems Authority" Specifications Electrical 1.3.1 Bus In ter face : PC/104 8- bit or 16- bit ex pan sion Bus Sys tem Clock : Fac tory con fig ured for 133 Mhz In ter rupts :...
Page 8
WinSystems - "The Embedded Systems Authority" Mouse : 5 pin latch ing type Mo lex 22-12-2054 Speaker : 3 pin latch ing type Mo lex 22-12-2034 Environmental 1.3.4 Op er at ing Tem pera ture : -40° to +70° Non- Condensing Hu mid ity :...
PCM-586 Technical Reference Introduction This sec tion of the man ual is in tended to pro vide suf fi cient in for ma tion re gard ing the con figu ra tion and us age of the PCM- 586 board. Win Sys tems main tains a Tech ni cal Sup port Group to help an swer ques tions re gard ing con figu ra tion, us age, or pro gram ming of the board.
WinSystems - "The Embedded Systems Authority" Real Time Clock Calendar 1 2 3 1 2 3 o o o o o o Master Battery Enable Battery Backup Jumper J6 Jumper J7 The PCM- 586 con tains an on board Clock/Cal en dar from Dal las Semi Con duc tor. The DS12885S is fully com pati ble with the MC146818A used in the origi nal PC- AT com put ers.
WinSystems - "The Embedded Systems Authority" Serial Interface The PCM- 586 pro vides two RS- 232 se rial chan nels on board, con fig ur able as RS- 422 or RS- 485 with the ad di tion of op tional driver ICs. The con figu ra tion op tions for each of the sup ported modes are shown on the fol low ing pages.
Page 12
WinSystems - "The Embedded Systems Authority" COM 2 - RS-232 2.5.2 COM2 is I/O mapped at 2F8H and util izes a 16550-type UART con tained in the Super- I/O chip. When used in RS- 232 mode COM2 is ter mi nated via the multi-I/O con nec tor at J4.The con figu ra tion de tails and the pin defi ni tions when used with the CBL- 162-1 ca ble...
WinSystems - "The Embedded Systems Authority" Speaker/Sound Interface Audio power for the PCM-586 can be accessed thru the connector at J1. Pin 1 drives a +5 volt digital line suitable for Piezo-type transducers. Pin definitions for J1 are given below.
WinSystems - "The Embedded Systems Authority" Floppy Disk Interface The PCM- 586 sup ports up to 2 stan dard 3 ½” or 5 ¼” PC com pati ble floppy disk drives. The drives are con nected via the I/O con nec tor at J3. Note that the in ter con nect ca ble to the drives is a stan dard floppy I/O ca ble used on desk top PCs.
WinSystems - "The Embedded Systems Authority" Watchdog Timer Configuration 2.11 1 2 3 Watchdog timer o o o configuration jumper J2 Battery enable jumper J6 The PCM- 586 board fea tures a power- on volt age de tect and a power- down/power brown out re set cir cuit to pro tect mem ory and I/O from faulty CPU op era tion dur ing pe ri ods of il le gal volt age lev els.
WinSystems - "The Embedded Systems Authority" Battery Selection Control 2.12 The PCM- 586 has an on board lith ium bat tery used to sus tain the Clock/Cal en dar CMOS setup in for ma tion, and Solid State Disk in for ma tion when SRAMs are used. A mas ter bat tery en able jumper is pro vided at J6.
WinSystems - "The Embedded Systems Authority" Silicon Disk Configuration 2.14 1 2 3 10 o o 9 o o o 8 o o 7 6 o o 5 4 o o 3 2 o o 1 Silicon Disk Configuration Jumpers J7 and J12 The PCM- 586 sup ports the use of EPROM, PEROM (Flash), SRAM, and the M- Systems Disk On Chip (DOC) de vices to be used as a Solid State Disk drive.
Page 20
WinSystems - "The Embedded Systems Authority" Disk On Chip de vice. The mode is con trolled via pins 1-2 on jumper block at J15 as shown here : Page 2-12 OPERATIONS MANUAL PCM-586 021402 Artisan Technology Group - Quality Instrumentation ... Guaranteed | (888) 88-SOURCE | www.artisantg.com...
Page 21
WinSystems - "The Embedded Systems Authority" Device Type Selection 2.14.2 Bef ore us ing the Sili con Disk, the proper de vice type must be se lected by prop erly jump er ing J12. The sup ported de vice type jump er ings are shown here :...
The LED can be turned off by writ ing a 0 to 1EDH. Mouse Interface 2.17 Power is applied to the Mouse via the connector at J19. An adapter cable, CBL-225-1 is available from WinSystems to adapt to a conventional PS/2 mouse connector. The pinout for J19 is shown here. MSDATA MSCLK...
WinSystems - "The Embedded Systems Authority" CPU Speed Selection 2.18 CPU Speed Select Jumpers J13 and J14 1 o o 2 6 o o 5 4 o o 3 2 o o 1 The PCM- 586 uses a Crystal controlled frequency synthesizer to control the CPU clock rate.
J14 allows selection as shown here : 1 o o 2 1 o o 2 x4 (Default) NOTE : WinSystems warrants the operation and reliability of the PCM-586- 133 only in the 33x4 mode. Any other jumpering may not result in reliable operation. Jumper/Connector Summary 2.19...
Use the ar row keys to high light the de sired se lec tion and press EN TER to en ter the sub- menu or to exe cute the func tion se lected. Page 3-1 OPERATIONS MANUAL PCM-586 021402 Artisan Technology Group - Quality Instrumentation ... Guaranteed | (888) 88-SOURCE | www.artisantg.com...
WinSystems - "The Embedded Systems Authority" ROM ISA BIOS (97061700) CMOS SETUP UTILITY AWARD SOFTWARE, INC. STANDARD CMOS SETUP PASSWORD SETTING BIOS FEATURES SETUP IDE HDD AUTO DETECTION CHIPSET FEATURES SETUP SAVE & EXIT SETUP LOAD BIOS DEFAULTS EXIT WITHOUT SAVING LOAD SETUP DEFAULTS ↑...
Page 27
WinSystems - "The Embedded Systems Authority" ROM ISA BIOS (97061700) STANDARD CMOS SETUP AWARD SOFTWARE, INC. Date (mm:dd:yy) : Wed, Feb 25 1999 Time (hh:mm:ss): 13 : 28 : 46 CYLS HEADS PRECOMP LANDZONE SECTORS MODE Drive C : Auto (...
Page 29
WinSystems - "The Embedded Systems Authority" Drive A : type/Drive B : type This cate gory iden ti fies the type of floppy drives at tached as Drive A : or Drive B :. The available choices are : NONE 360K, 5.25 in.
WinSystems - "The Embedded Systems Authority" Memory This cate gory is dis play only and is de ter mined by the BIOS POST (Power On Self Test). Base Memory The POST rou tines in the BIOS will de ter mine the amount of base (or con ven tional) mem ory in stalled in the sys tem.
WinSystems - "The Embedded Systems Authority" ROM ISA BIOS (97061700) BIOS FEATURES SETUP AWARD SOFTWARE, INC. Virus Warning : Disabled Video BIOS Shadow : Enabled CPU Internal Cache : Enabled C8000-CFFFF Shadow : Disabled Quick Power On Self Test : Disabled...
WinSystems - "The Embedded Systems Authority" Gate A20 Option This option allows for the selection of the source for the gate A20 signal. The choices are: NOR MAL FAST Type matic Rate Setting This en ables or dis ables type matic rate pro gram ming at boot time. Type matic is the auto- repeat func tion for the key board.
Page 33
WinSystems - "The Embedded Systems Authority" Page 3-9 OPERATIONS MANUAL PCM-586 021402 Artisan Technology Group - Quality Instrumentation ... Guaranteed | (888) 88-SOURCE | www.artisantg.com...
Page 34
WinSystems - "The Embedded Systems Authority" NOTE : To dis able se cu rity, se lect “Pass word Set ting” at the Setup Main Menu and then you will be asked to en ter a pass word. Do not type any thing, just hit EN TER. Once the se cu rity is dis abled, the sys tem will boot and you can en ter Setup freely.
WinSystems - "The Embedded Systems Authority" Pri mary Se rial Port This option, when disabled, turns off the com port at 3F8H and allows access to IRQ4 on the PC/104 Bus. The avaialable choices are : En able Dis able...
Page 36
WinSystems - "The Embedded Systems Authority" ROM PCI/ISA BIOS (97061700) CHIPSET FEATURES SETUP AWARD SOFTWARE, INC. AT Bus Clock Selecton :8.00MHz RAS Timeout : Enabled Shadow RAM Cacheable : Disabled RAS Precharge Timing : 2T RAS to CAS Write Delay...
Page 37
WinSystems - "The Embedded Systems Authority" Shadow RAM Cacheable This op tion, when en abled, allows shadow area to be cacheable. NOTE : Certain diagnostics may fail or lockup with Shadow RAM cached. RAS Precharge Timing Number of clocks RAS is high before a write. The available choices are : RAS To CAS Write Delay This op tion allows the number of clocks between RAS and CAS during a write.
Page 38
WinSystems - "The Embedded Systems Authority" CAS Write Cycle Width Number of clocks CAS is high before a write. The available choices are : CAS to RAS Read Delay This op tion allows the number of clocks between CAS and RAS during a read. The...
WinSystems - "The Embedded Systems Authority" 0.250 uS 0.625 uS 1.125 uS 1.625 uS 2.125 uS 2.635 uS 3.125 uS 16 Bit I/O Recovery Time 0.000 uS 0.250 uS 0.625 uS 1.125 uS 1.625 uS 2.125 uS 2.635 uS 3.125 uS ISA Extra Wait State This option, when enabled, adds one additional clock to the ISA Bus cycle.
WinSystems - "The Embedded Systems Authority" Password Setting This op tion al lows the set ting of the se cu rity pass word. Press ing En ter at the pass word prompt dis ables the se cu rity func tion com pletely.
PCM-586 Silicon Disk Reference Introduction Win Sys tems pro vides Sili con disk sup port for the PCM- 586 us ing four dif fer ent me dia types de pend ing on the needs of the ap pli ca tion.
Page 42
WinSystems - "The Embedded Systems Authority" MKDISK - Solid State RomDisk Creation Utility V6.00 (C) 1988-1994, WinSystems Inc. SELECT SSD TYPE Paged Memory Mode (SSD-XT) Extended Memory Mode (SSD-AT) V53 Expanded Memory Mode I/O Mapped Silicon Disk (USSD) sx386 On Board ROMDISK...
Page 43
WinSystems - "The Embedded Systems Authority" MKDISK - Solid State RomDisk Creation Utility V6.00 (C) 1988-1994, WinSystems Inc. SELECT SOURCE DRIVE Drive A Drive B Use arrow keys and ENTER to make your selection. MKDISK - Drive Menu Se lect the source drive as ap pro pri ate.
WinSystems - "The Embedded Systems Authority" MKDISK - Solid State RomDisk Creation Utility V6.00 (C) 1988-1994, WinSystems Inc. SELECT OUTPUT FILE TYPE Binary Image Files Hex ROM Image Files S-Record ROM image files Use arrow keys and ENTER to make your selection.
WinSystems - "The Embedded Systems Authority" The disk is now pre pared for for mat ting. The sys tem must be re booted prior to for mat ting with the sim ple DOS com mand : for mat b: /s/u Af ter the next re set the for mat ted sili con disk will boot as the A: drive.
WinSystems - "The Embedded Systems Authority" Non-Bootable Flash Disk Usage The AT MEL 5 volt Flash Part (29C040/29C040A) may also be used as a non- bootable drive in a man ner nearly iden ti cal to the RAM DISK us age de scribed in the pre vious sec tion.
This section documents the usage of the WinSystems Serial Console feature present on the PCM-586 board. The serial console consists of special BIOS code and a special terminal program used to communicate with the board. The principal design criteria for the serial console was the ability to access the AWARD CMOS setup options without the need for a standard keyboard or video adapter and monitor.
1. Copy WINCOM.EXE onto a DOS boot disk for the client (terminal) machine. 2. Attach a Null-Modem cable between COM1 of the PCM-586 and a free COM port on the client machine.
WinSystems - "The Embedded Systems Authority" 7. Make whatever changes are required in “Setup”. If permanent serial console access is desired go to the BIOS features screen and select the desired mode, COM port and baud rate. Refer to the next section for details on selecting these items.
To start the upload we would type : scopy com2 -sq app.dat Once Scopy has been started on the PCM-586 we now need to tell Wincom to send or receive a file. If we specified '-r' to Scopy we wanted the PCM-586 to receive and Wincom...
Page 51
Wincom or Scopy will report that an error has occurred. Downloading a file from the PCM-586 to the client PC is done in an identical matter except that '-sq' is used with SCOPY and <ALT><PgDn> is used with WINCOM.
Page 52
COM4 **2F0- 2F7 FREE 2F8- 2FF COM2 -300- 31F Pro to type Card -320- 32F XT Hard Disk **330- 377 FREE 021402 OPERATIONS MANUAL PCM-586 Page 6-1 Artisan Technology Group - Quality Instrumentation ... Guaranteed | (888) 88-SOURCE | www.artisantg.com...
Page 53
WinSystems - "The Embedded Systems Authority" -378- 37F Par al lel Printer -380 -3AF SDLC -3B0 -3BB -3C0 -3CF EGA Video -3D0 -3DF **3E0- 3E7 FREE -3E8 -3EF COM3 3F0- 3F6 Floppy Disk 3F8- 3FF COM1 Page 6-2 OPERATIONS MANUAL PCM-586 021402 Artisan Technology Group - Quality Instrumentation ...
Page 54
BIOS BIOS Time of Day func tions BIOS Key board break vec tor BIOS User chained timer tick BIOS Video Initialization 021402 OPERATIONS MANUAL PCM-586 Page 7-1 Artisan Technology Group - Quality Instrumentation ... Guaranteed | (888) 88-SOURCE | www.artisantg.com...
Page 55
WinSystems - "The Embedded Systems Authority" BIOS Floppy Disk pa rame ter ta ble BIOS CGA graphic char ac ter font MS- DOS Pro gram ter mi nate MS- DOS DOS func tion call MS- DOS Ter mi nate Ad dress...
Page 56
APPENDIX C PCM- 586 Parts Place ment Guide Artisan Technology Group - Quality Instrumentation ... Guaranteed | (888) 88-SOURCE | www.artisantg.com...
Page 57
APPENDIX D PCM- 586 Parts List Artisan Technology Group - Quality Instrumentation ... Guaranteed | (888) 88-SOURCE | www.artisantg.com...
Page 61
WARRANTY WinSystems warrants that for a period of two (2) years from the date of shipment any Products and Software purchased or licensed hereunder which have been developed or manufactured by WinSystems shall be free of any material defects and shall perform substantially in accordance with WinSystems' specifications therefore. With...
Page 62
Artisan Technology Group is your source for quality new and certified-used/pre-owned equipment SERVICE CENTER REPAIRS WE BUY USED EQUIPMENT • FAST SHIPPING AND DELIVERY Experienced engineers and technicians on staff Sell your excess, underutilized, and idle used equipment at our full-service, in-house repair center We also offer credit for buy-backs and trade-ins •...