Page 1 ORDER NO. ITD0509054CE High Definition Plasma Display TH-65PHD8BK TH-65PHD8EK TH-65PHD8UK GPH8D Chassis Specifications Power Source (UK) 120 V AC, 50/60Hz Power Source (BK/EK) 220 - 240 V AC, 50/60 Hz Power Consumption (UK) Maximum 675 W Stand-by condition Save OFF 0.7 W, Save ON 0.5 W Power off condition 0.2 W...
Page 2: Table Of Contents
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK COMPONENT / RGB (UK) Y / G (BNC) 1.0 Vp-p / composite (75-ohm) 0.7 Vp-p / non-composite (75-ohm) /B (BNC), P /R (BNC) 0.7 Vp-p (75-ohm) AUDIO IN (RCA PIN JACK × 2) 0.5 Vrms (high impedance)
Page 3 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 7.10. Removal of the SC-Board 15.5. P-Board (1 of 3) Schematic Diagram 7.11. Removal of the SS2-Board and the SS3-Board 15.6. P-Board (2 of 3) Schematic Diagram 7.12. Removal of the SS-Board 15.7. P-Board (3 of 3) Schematic Diagram 7.13.
Page 4 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.58. SS-Board (2 of 2) Schematic Diagram 17 Mechanical Replacement Parts List 16 Parts Location 18 Replacement Parts List 16.1. Exploded View 18.1. Relpacement Parts List Notes 16.2. Cable relation 18.2. Electrical Replacement Parts List...
Page 5: Applicable Signals
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 1 Applicable signals...
Page 6: Safety Precautions
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 2 Safety Precautions 2.1. General Guidelines 1. When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or damaged by the short circuit. 2. After servicing, see to it that all the protective devices such as insulation barriers, insulation papers shields are properly installed.
Page 7: Prevention Of Electro Static Discharge (Esd) To Electrostatically Sensitive (Es) Devices
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 3 Prevention of Electro Static Discharge (ESD) to Electrostatically Sensitive (ES) Devices Some semiconductor (solid state) devices can be damaged easily by static electricity. Such components commonly are called Electrostatically Sensitive (ES) Devices. Examples of typical ES devices are integrated circuits and some field-effect transistors and semiconductor "chip"...
Page 8: About Lead Free Solder (Pbf)
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 4 About lead free solder (PbF) Note: Lead is listed as (Pb) in the periodic table of elements. In the information below, Pb will refer to Lead solder, and PbF will refer to Lead Free Solder.
Page 9: Pcb Structure Sheet Of Gph8D Chassis
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 5 PCB Structure sheet of GPH8D chassis Board Name Function Remarks Digital Signal Processor, Format Converter, Plasma AI Processor Slot Interface (Audio/Video/Sync input Switch), SYNC processor, Audio processor, Speaker out amplifier, DC-DC converter Sustain drive...
Page 10: Service Hint
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 6 Service Hint Note: Extension cable kit for Slot Board is supplied as service fixtures and tools. (Part No. TZSC07040)
Page 11: Removal Of The
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK · Removal of the HA-Board 7 Disassembly 1. Remove the 4 screws (D) of the HA Terminal Block and · To remove P.C.B., wait for 1 minute after power was off for then remove the HA Terminal Block.
Page 12: Removal Of The Slot Block
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 5. Remove the 4 Hexagonal-Head screws and the 1 screw of 7.3. Removal of the Slot Block the HX-Board and then remove the HX-Board. 1. Disconnect the couplers(J1, J3, J4, J5, J6, J7, J10, J34).
Page 13: Removal Of The D-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 7.7. Removal of the D-Board 7.8.1. Removal of the P(P-1)-Board 1. Disconnect the couplers(CN01, CN02, CN03). 1. Remove the PB-Board Block.(Reference to Removal of the PB-Board) 2. Remove the 5 screws.(Top view) 2. Disconnect the couplers(D1, D3, D5, D20, D25).
Page 14 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Note: 7.8.2. Removal of the P(P-2)-Board · When assembling the P(P-1)-Board and the P(P-2)- 1. Disconnect the couplers(CN05, CN06, CN08). Board, the position of each hole of the insulation 2. Remove the 5 screws.(Top view)
Page 15: Removal Of The Su-Board And The Sd-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 7.9. Removal of the SU-Board and 7.10. Removal of the SC-Board the SD-Board 1. Disconnect the couplers(PB31, PB32). 2. Remove the each 4 screws and then remove the Fan Block 1. Disconnect the couplers(SC45, SC46).
Page 16: Removal Of The Ss2-Board And The Ss3-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 7.11. Removal of the SS2-Board and the SS3-Board 1. Disconnect the coupler(SS23). 2. Remove the flexible cables from the couplers(SS51, SS52). 3. Disconnect the coupler(SS27). 4. Remove the flexible cables from the couplers(SS57, SS58). 5. Remove the each 3 screws and then remove the SS2- Board and the SS3-Board.
Page 17: Removal Of The C1, C2, C3, C4, C5 And The C6-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 7.14. Removal of the C1, C2, C3, C4, 7.14.2. Removal of the C2-Board C5 and the C6-Board 1. Remove the flexible cables from the couplers(C20, C21, C24, C25). 1. Remove the each 4 screws and then remove the Fan 2.
Page 18: Removal Of The Fan
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 7.14.4. Removal of the C4-Board 7.14.6. Removal of the C6-Board 1. Remove the flexible cable from the coupler(C41). 1. Remove the flexible cable from the coupler(C60). 2. Disconnect the couplers(C42, C43, C44). 2. Disconnect the coupler(C61).
Page 19: Removal Of The Escutcheon
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 7.15.1. Removal of the Fan (Middle/R) 7.15.4. Removal of the Fan (SC/SS) on the SS-Board side 1. Remove the 4 screws and then remove the Fan (Middle/R). 1. Remove the each 4 screws and then remove the Fans (SC/ SS).
Page 20: Removal Of The S1-Board And The V1-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 7.17. Removal of the S1-Board and the V1-Board 1. Remove the Escutcheon. (Refernce to Removal of Escutcheon) 2. Remove the 2 screws (N) and then remove the S1-Board Block. 3. Remove the 1 screw (P) and then remove the S1-Board.
Page 21: Removal Of The Plasma Panel
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 7.18. Removal of the Plasma Panel 1. Disconnect the couplers(PB31, PB32, PB33, PB34, PB35, PB37, PB38). 2. Remove the each 4 screws and then remove the Fan Blocks(A, B, C, D). 9. Disconnect the couplers(P2, P9, P11, P12, P23).
Page 22 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15. Remove the 10 screws and then remove the SC-Board. 22. Disconnect the couplers(C11, C33). 23. Remove the flexible cables from the couplers(C10, C21, C24, C25). 24. Remove the each 6 screws and then remove the C1-Board, the C2-Board and the C3-Board.
Page 23 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 29. Remove the each 6 screws and then remove the C4-Board, arrow2 and then remove the Plasma Panel. the C5-Board and the C6-Board. 30. Remove the each 2 screws and then remove the Shield Plate and the Angle.
Page 24: Location Of Lead Wiring
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 8 Location of Lead Wiring...
Page 25 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK...
Page 26: Adjustment Procedure
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 9 Adjustment Procedure 9.1. Driver Set-up 9.1.1. Item / Preparation 1. Input a white signal of the RGB signal generator. 2. Set the picture adjustment items as follows. · Picture menu : Standard · Color temperature : Normal ·...
Page 27: Initialization Pulse Adjust
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 9.2. Initialization Pulse Adjust 1. Input a white signal to plasma video input. 2. Set the picture adjustment items as follows. · Picture menu : Standard · Color temperature : Normal · Picture : 25 ·...
Page 28: Adjustment Volume Location
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 9.4. Adjustment Volume Location 9.5. Test Point Location...
Page 29: Service Mode
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 10 Service mode 10.1. CAT (computer Aided Test) mode To exit the CAT mode, access the ID mode and switch off the main power. 10.1.1. IIC mode Select the IIC mode by Up/Down button on the remote control at the front page of CAT mode and then press the Action button on the remote control.
Page 30 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 10.1.2. CD mode Select the CD mode by Up/Down button on the remote control at the front page of CAT mode and then press the Mute button on the remote control more than 5 seconds.
Page 31: Iic Mode Structure (Following Items Value Is Sample Data.)
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 10.2. IIC mode structure (following items value is sample data.)
Page 32: Alignment
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 11 Alignment 11.1. PC / RGB panel white balance INPUT Equipment Setting Alignment menu Procedure Note: · Before adjustment, color signal has not been displayed 1 PC (VGA) Color Picture menu: on panel. Gray Scale...
Page 33 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Color temperature High A0-11AD A0-11AE A0-11AF Medium A0-11B0 A0-11B1 A0-11B2 A0-11B3 A0-11B4 A0-11B5 Table 2 Drive data addresses (PC/RGB) Color temperature High A0-1180 A0-1181 A0-1182 Medium A0-1183 A0-1184 A0-1185 A0-1186 A0-1187 A0-1188 Table 3 Drive data addresses (NTSC)
Page 34: Hd / 525Ip / 625Ip Panel White Balance
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 11.2. HD / 525ip / 625ip panel white balance INPUT Equipment Setting Alignment menu Procedure Note: · Before adjustment, color signal has not been displayed Color Picture menu: on panel. (YUV2_HD) Analyzer Standard · The pedestal adjustment has been done.
Page 35 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Color temperature High A0-119D A0-119B A0-119C Medium A0-119E A0-119F A0-11A0 A0-11A1 A0-11A2 A0-11A3 Table 2 Drive data addresses (YUV2_HD) Color temperature High A0-1192 A0-1193 A0-1194 Medium A0-1195 A0-1196 A0-1197 A0-1198 A0-1199 A0-119A Table 3 Drive data addresses (YUV1_525ip)
Page 36: Trouble Shooting Guide
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 12 Trouble shooting guide 12.1. Self Check 12.1.1. Display Indication 1. Self-check is used to automatically check the bus line controlled circuit of the Plasma display. 2. To get into the Self-check mode, press the volume down...
Page 37: No Power
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 12.2. No Power First check point 1. No lit. 2. Green is lit then turns red blinking a few seconds later. 3. Only red is lit. 1. No lit. 12.3. No Picture...
Page 38: Local Screen Failure
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 12.4. Local screen failure Plasma display may have local area failure on the screen. Fig - 1 is the possible defect P.C.B. for each local area. Fig - 1...
Page 39: Option Setting
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 13 Option Setting...
Page 40 Sets the slot power mode while the power is turned on. Allow Optional Terminal Board insert Slots while power is on. V. Installation V. Installation function On/Off This mode is available for TH-65PHD8BK/EK/UK. Note: Turn up the power switch for the upward direction when you set display vertically. Rotate...
Page 41: Circuit Board Layout
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14 Circuit Board Layout 14.1. P-Board (P-1), (P-2) P(P-1)-BOARD (FOIL SIDE) ETXMM584MEK (NPX584ME-1) Parts Location P-BOARD (FOIL SIDE) TRANSISTOR MC301 Q332 MC302 Q333 MC303 Q602 MC601 Q603 MC602 Q605 MC604 Q606 MC605 TH-65PHD8 SERIES TH-65PHD8 SERIES...
Page 42 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK P(P-1)-BOARD (COMPONENT SIDE) ETXMM584MEK (NPX584ME-1) Parts Location P-BOARD (COMPONENT SIDE) MC301 MC302 MC303 MC601 MC602 MC604 MC605 TH-65PHD8 SERIES TH-65PHD8 SERIES P-BOARD ETXMM584MEK P-BOARD ETXMM584MEK...
Page 43 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK P(P-2)-BOARD (FOIL SIDE) ETXMM584MEK (NPX584ME-2) Parts Location P-BOARD (FOIL SIDE) TRANSISTOR IC401 Q402 IC701 Q451 IC901 Q452 MC401 Q453 MC701 Q454 MC801 Q703 MC901 Q951 MC902 Q952 MC1601 Q953 MC1602 Q954 MC1604 Q955 Q956 Q1601...
Page 44 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK P(P-2)-BOARD (COMPONENT SIDE) ETXMM584MEK (NPX584ME-2) Parts Location P-BOARD (COMPONENT SIDE) TRANSISTOR IC401 Q1601 IC701 IC901 MC401 MC701 MC801 MC901 MC902 MC1601 MC1602 MC1604 TH-65PHD8 SERIES TH-65PHD8 SERIES P-BOARD ETXMM584MEK P-BOARD ETXMM584MEK...
Page 45: Pb-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.2. PB-Board Parts Location PB-BOARD (FOIL SIDE) TRANSISTOR IC850 Q850 TPFAN Parts Location PB-BOARD (COMPONENT SIDE) TRANSISTOR IC850 Q850 PB-BOARD (FOIL SIDE) PB-BOARD (COMPONENT SIDE) TNPA3655AB TNPA3655AB TNPA3655 R861 Q850 R861 ORDER R852 R852 D857...
Page 46: Ha-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.3. HA-Board HA-BOARD(FOIL SIDE) HA-BOARD(COMPONENT SIDE) TXNHA10RBS TXNHA10RBS (UK) TNPA2845 ORDER TP034 TP036 CR NO.3 JS009 JS007 C022 Parts Location JS008 R038 JS010 R041 R040 R042 HA-BOARD IC3001 TP3032 IC002 IC3002 TP3033 C017 TP3034 JS001...
Page 47: Hb-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.4. HB-Board HB-BOARD (FOIL SIDE) HB-BOARD(COMPONENT SIDE) TXNHB10QXS TXNHB10QXS (BK, EK) (UK) 2 HV TNPA2844 A1 A2 A1 A2 ORDER Parts Location HB-BOARD C324 C324 C330 C330 C329 C329 C321 C321 TRANSISTOR L308 L308 IC251...
Page 48: Hx-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.5. HX-Board HX-BOARD(FOIL SIDE) HX-BOARD(COMPONENT SIDE) TZTNP040VAS TZTNP040VAS TNPA3400 TNPA3400 REVERSE FOR ORDER ORDER CR NO.3 CR NO.3 C409 C405 C404 IC502 R400 L555 R589 C523 R778 D502 C563 C524 R788 D504 R789 D506 R794...
Page 49: J-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.6. J-Board Parts Location J-BOARD (FOIL SIDE) TRANSISTOR IC2301 Q3002 IC2302 Q3003 IC8003 IC8004 J-BOARD (FOIL SIDE) TNPA3630AD (TH-65PHD8BK/EK) TNPA3630AC (TH-65PHD8UK) R2365 TNPA3630 R2408 R2409 R2374 REVERSE FOR ORDER L2330 D3061 C3203 C3202 C3201 IC2301...
Page 50 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Parts Location J-BOARD (COMPONENT SIDE) IC8003 Q3004 Q8024 IC8004 Q3101 Q8025 IC801 IC8005 Q3102 Q8026 IC802 IC8007 Q3103 Q8181 IC803 IC8008 Q3104 Q8182 IC804 Q8183 IC8009 Q3105 IC2301 IC8014 Q3106 Q8184 IC2302 IC8016 Q8001 Q8200...
Page 51: D-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.7. D-Board D-BOARD (FOIL SIDE) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) R891 FL706 R984 FL300 R892 FL703 R476 C994 C716 C993 FL301 C443 FL704 R985 R812 R815 R818 R814 IC605 IC953 R811 R817 R492 R491 Q074 R109...
Page 52 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK D-BOARD (COMPONENT SIDE) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) R981 C377 C375 C992 D705 X701 R593 R567 R396 R473 R418 R424 R569 C636 R427 R429 R568 R435 R437 R439 C991 R595 C081 C780 R766 R835 C708 R777...
Page 53: C1-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.8. C1-Board Parts Location C1-BOARD IC7102 IC7104 IC7105 IC7106 IC7107 C1-BOARD (FOIL SIDE) TNPA3663 TNPA3663 1 2 3 CRNO.7 SEE REVERSE FOR ORDER NO. C1-BOARD (COMPONENT SIDE) TNPA3663 L107 L108 L105 L106 C163 L102 L101...
Page 54: C2-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.9. C2-Board Parts Location C2-BOARD IC7201 IC7202 IC7203 IC7204 IC7205 IC7206 IC7207 IC7208 IC7209 IC7210 IC7211 IC7212 C2-BOARD (FOIL SIDE) TNPA3664 TNPA3664 REVERSE FOR ORDER C2-BOARD (COMPONENT SIDE) TNPA3664 L203 L204 R264 R263 L208 L207...
Page 55: C3-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.10. C3-Board Parts Location C3-BOARD IC7301 IC7302 IC7303 IC7304 IC7305 C3-BOARD (FOIL SIDE) TNPA3665 1 2 3 TNPA3665 CRNO.7 REVERSE FOR ORDER C3-BOARD (COMPONENT SIDE) TNPA3665 CA10 L302 L301 CA11 R365 ZA301 L305 L308 L307...
Page 56: C4-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.11. C4-Board Parts Location C4-BOARD IC7401 IC7402 IC7403 IC7404 IC7405 C4-BOARD (FOIL SIDE) TNPA3666 CRNO.7 TNPA3666 REVERSE FOR ORDER 1 2 3 C4-BOARD (COMPONENT SIDE) TNPA3666 C408 C412 R413 ZA403 ZA404 C409 C404 C413 R447...
Page 57: C5-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.12. C5-Board Parts Location C5-BOARD IC7501 IC7502 IC7503 IC7504 IC7505 IC7506 IC7507 IC7508 IC7509 IC7510 IC7511 IC7512 IC7513 C5-BOARD (FOIL SIDE) TNPA3667 TNPA3667 REVERSE FOR ORDER CRNO.7 C5-BOARD (COMPONENT SIDE) TNPA3667 IC508 R510 C562 R618...
Page 58: C6-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.13. C6-Board Parts Location C6-BOARD IC7602 IC7603 IC7604 IC7605 IC7606 C6-BOARD (FOIL SIDE) TNPA3668 TNPA3668 REVERSE FOR ORDER 1 2 3 CRNO.7 C6-BOARD (COMPONENT SIDE) TNPA3668 R651 R606 CRNO.7 R642 IC604 R638 IC602 R670 R655...
Page 59: Sc-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.14. SC-Board SC-BOARD (FOIL SIDE) TNPA3669 L680 C636 SC41 SC42 SC43 SC44 R845 C623 Q814 R827 C806 Q815 VR602 C614 C658 L813 C615 R812 R811 Q602 Q813 VR802 L811 L812 R860 D528 D525 D529 D527...
Page 60 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Parts Location Parts Location SC-BOARD (FOIL SIDE) SC-BOARD (COMPONENT SIDE) TRANSISTOR TP6037 Q6576 Q6655 TP6038 Q6577 Q6656 IC6411 Q6411 IC6801 TP6005 TP6039 Q6601 Q6657 IC6412 Q6412 TP6006 TP6040 Q6602 Q6658 TRANSISTOR IC6413 Q6413 TP6007 Q6659...
Page 61 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK SC-BOARD (COMPONENT SIDE) TNPA3669 R756 D639 D640 C638 R755 Q604 R601 R602 R606 C635 R757 IC640 R477 R475 D641 D505 R758 ZA401 ZA402 L680 R615 SC44 SC43 SC42 SC41 R759 R845 Q601 R760 TPSC1 Q630...
Page 62: Su-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.15. SU-Board Parts Location SU-BOARD IC6900 TPSU1 IC6901 TPSU2 IC6902 TPSU3 IC6903 TPSU4 IC6904 TPSU5 IC6905 TPSU6 SU-BOARD (FOIL SIDE) TNPA3673 TNPA3673 1 SU REVERSE FOR ORDER 1 2 3 SUMM1 SU-BOARD (COMPONENT SIDE) TNPA3673...
Page 63: Sd-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.16. SD-Board Parts Location SD-BOARD IC6920 TPSD21 IC6921 TPSD22 IC6922 TPSD23 IC6923 TPSD24 IC6924 TPSD25 IC6925 TPSD26 SD-BOARD (FOIL SIDE) TNPA3674 TNPA3674 1 SD REVERSE FOR ORDER 1 2 3 SDMM1 SD-BOARD (COMPONENT SIDE) TNPA3674...
Page 64: Ss-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.17. SS-Board SS-BOARD (FOIL SIDE) TNPA3670 TP19 SS12 TP23 Q240 TP10 L180 L202 L200 L201 TP913 L207 L206 L205 TP21 TP17 TP918 SS11 L239 TP16 TP18 TP20 TP11 C224 C063 TP12 TP14 C061 TP33 TP32...
Page 65 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Parts Location Parts Location SS-BOARD (FOIL SIDE) SS-BOARD (COMPONENT SIDE) TRANSISTOR TRANSISTOR TP24 Q6142 Q6252 TP25 Q6143 Q6253 IC6000 Q6000 Q6000 TP26 Q6144 Q6254 IC6020 Q6001 Q6001 TP27 Q6145 Q6255 IC6060 Q6002 Q6002 TP28 Q6160...
Page 66 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK SS-BOARD (COMPONENT SIDE) TNPA3670 Q007 D241 R095 R098 R246 R092 L206 L207 L201 L200 L205 L202 C220 R220 L230 R056 R233 R234 R217 R055 JS200 JS201 R091 Q005 R089 SSMM1 Q006 R094 Q240 L180 R093...
Page 67: Ss2 And Ss3-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.18. SS2 and SS3-Board SS2-BOARD (FOIL SIDE) TNPA3671 SS51 SS52 SS23 TNPA3671 REVERSE FOR ORDER SS2-BOARD (COMPONENT SIDE) TNPA3671 SS23 SS52 SS51 TNPA3671 ORDER SS3-BOARD (FOIL SIDE) TNPA3672 TNPA3672 REVERSE FOR ORDER SS58 SS57 1 2 3...
Page 68: H3, S1 And V1-Board
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 14.19. H3, S1 and V1-Board V1-BOARD (FOIL SIDE) TNPA3199AB S1554 S1553 S1550 S1551 S1552 IC1550 RM001 TNPA3199 SEE REVERSE FOR ORDER NO. 94V-0 V1-BOARD (COMPONENT SIDE) TNPA3199AB D1550 D1552 R1554 R1553 S1-BOARD (FOIL SIDE) S1-BOARD (COMPONENT SIDE)
Page 69: Schematic Diagrams
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15 Schematic Diagrams 15.1. Schematic Diagram Notes...
Page 70: Main Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.2. Main Block Diagram S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. 78V_L 78V_R Vda_75V DATA DRIVER DATA DRIVER DATA DRIVER PB31 FANx7 PB32 CONTROL PB33 PB34 PB30 PB35 SCAN OUT PB37...
Page 71: P-Board (1 Of 2)Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.3. P-Board (1 of 2)Block Diagram CN04 CNPFC RF1601 3A L1604 POWER SUPPLY MC1604 MC1601 AC IN (1/2) RECTIFIER D709 CN02 T701 K1601 K1602 (2/2) L1601 L1602 LIVE DC(+) F701 VS_OUT F1601 Q703 VS_OHP NEUTRAL...
Page 72: P-Board (2 Of 2)Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.4. P-Board (2 of 2)Block Diagram POWER SUPPLY (2/2) COLD MC601 PFC(POWER FACTOR CONTROL) RF601 3A L604 MC604 CN05 Vsus RECTIFIER VSUS (1/2) K601 K602 L601 L602 LIVE DC(+) F601 F603 VR351 Z601 Z602 VSUS...
Page 73: P-Board (1 Of 3) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.5. P-Board (1 of 3) Schematic Diagram COLD SS-BOARD (SS12) K5D402BNA007 AC_IN K5D402BNA007 CN03 J-BOARD (J10) SC BOARD (SC23) J-BOARD (J4) PB-BOARD (PB30) COLD D-BOARD (D25) CN01 K5D102BNA007 CN02 P-BOARD ETXMM584MEK (1/3) COLD TH-65PHD8 SERIES...
Page 74: P-Board (2 Of 3) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.6. P-Board (2 of 3) Schematic Diagram P-BOARD ETXMM584MEK (2/3) TH-65PHD8 SERIES TH-65PHD8 SERIES P-Board (2 of 3) Schematic Diagram P-Board (2 of 3) Schematic Diagram...
Page 75: P-Board (3 Of 3) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.7. P-Board (3 of 3) Schematic Diagram SC-BOARD (SC2) SS-BOARD (SS11) K5D103BMA001 CN05 K5D103BMA001 CN06 COLD COLD CN08 P-BOARD ETXMM584MEK (3/3) TH-65PHD8 SERIES TH-65PHD8 SERIES P-Board (3 of 3) Schematic Diagram P-Board (3 of 3) Schematic Diagram...
Page 76: Pb And V1-Board Block And Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.8. PB and V1-Board Block and Schematic Diagram FAN CONTROL IC850 REGULATOR FAN A +9V/+7.2V L6FALCEH0004 VOLTAGE CONTROL TO FAN D850 R854 FAN B Q850 L6FALCEH0004 TO P30 JS851 +15V P-BOARD D851 FAN SOS (P30)
Page 77: Ha-Board Block And Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.9. HA-Board Block and Schematic Diagram HA-BOARD TXNHA10RBS L3001 J0HABB000004 LAN15V LAN15V JS3011 JS3014 COMPONENT HA BNC TP032 L3002 VIDEO IN J0HABB000004 COMPONENT VIDEO JS3012 JS3015 TP033 TP034 L3003 J-BOARD J0HABB000004 JK3001 SLOT -0.8 JS3013...
Page 78: Hb-Board Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.10. HB-Board Block Diagram HB BNC COMPOSITE VIDEO / S_VIDEO IC3104 IC3201 RESET MEMORY FIFO IC3103 IC3251 GC2M LVDS TRANSMITTER IC3003 J-BOARD SLOT MEMORY CONTROLLOR TX0+ TX0+ TX0- Q3006 Q3101,3102 TX0- TX1+ TX1+ BUFFER BUFFER...
Page 79: Hb-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.11. HB-Board (1 of 2) Schematic Diagram IC3101 AVR 2.5V C0DBEZG00004 HB-BOARD TXNHB10QXS (1/2) C3127 3.3V IC3104 R3145 C3159 220u AD2R5V C0EBE0000066 R3112 1.5k RESET R3159 C3103 C3105 C3102 R3113 R3144 R3185 0.1u 1.5k 220u...
Page 80: Hb-Board (2 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.12. HB-Board (2 of 2) Schematic Diagram HB-BOARD TXNHB10QXS (2/2) C3265 C3266 220u 0.1u 3.3V TS3100 TS3101 TS3102 AE_V_Y AL_S2_DET R3251 AM_HS IC3251 LVDS TRANSMITTER C0ZBZ0000684 AM_VS AE_R AE_L SCL2 SDA2 3.3V L3252 L3251 ELJPA2R2MF ELJPA2R2MF 3.3V...
Page 81: Hx-Board Block And Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.13. HX-Board Block and Schematic Diagram HX-BOARD TZTNP040VAS L3555 ELJPA100KF C3405 R3653 C3550 C3551 C3404 C3561 Q3531 0.01u JK3513 2SD0601A0L 0.1u K2HC103B0105 R3776 R3668 R3654 R3663 FL3512 R3547 J0HAAB000012 IC3502 PC AUDIO IN R3529 R3655...
Page 82: J-Board (1 Of 2) And H3-Board Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.14. J-Board (1 of 2) and H3-Board Block Diagram SLOT INTERFACE/SYNC PROCESSOR/SOUND PROCESSOR S_CLOCK3 S_DATA3 RESET TO P5 AUDIO MUTE DIG+12V DIG+12V AUDIO L DR15V AUDIO R AUDIO+12V AUDIO+12V AUDIO+12V Q2370 Q2371 12V DET 12V DET...
Page 83: J-Board (2 Of 2) Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.15. J-Board (2 of 2) Block Diagram TO HX1 STB5V J SLOT INTERFACE/SYNC PROCESSOR/SOUND PROCESSOR STB3.3V S_CLOCK3 IC3008 AA_SCL3 S_DATA3 IC3004 AA_SDA3 STB5V IIC ON/OFF IC3007 EX I/O(VIDEO/AUDIO SELECT) IC3003 STB5V EX.I/O(SLOT DET IIC CONTROL)
Page 84: J-Board (1 Of 4) And H3-Board Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.16. J-Board (1 of 4) and H3-Board Schematic Diagram J-BOARD (1/4) TNPA3630AD (65PHD8BK/EK) TNPA3630AC (65PHD8UK) IC801 C0DBAMH00013 D_3.3V D_1.8V DIG12V AVR 9V 9V/0.5A R801 C807 C802 4.7u 470u L801 G1C470MA0078 R802 R808 C809 C806 2.2u 0.1u...
Page 85: J-Board (2 Of 4) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.17. J-Board (2 of 4) Schematic Diagram 3.3V STB3.3V R3125 IC8001 SLOT1 C0JBAR000241 SLOT2 C8003 C8035 R3163 Q8002 SLOT3 0.1u 0.1u SYNC SELECT(MAIN) 2SD0601A0L C8001 R8072 R8047 R8001 R3134 L8001 C8049 IC8007 G1C100K00020 R8036 100k...
Page 86: J-Board (3 Of 4) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.18. J-Board (3 of 4) Schematic Diagram SYNC SIGNAL IC8003 PROCESSOR TPJH1 TPJV1 C1AA00000706 (MAIN) L8003 R8065 G1C100K00020 AG_HD_M AG_VD_M H.State Clamp Timing C8036 R8067 R8041 V.State V.Pol. 100p C8045 Green Sep Filter L8005 H.Pol.
Page 87: J-Board (4 Of 4) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.19. J-Board (4 of 4) Schematic Diagram IC8014 C0ZBZ0000911 STB3.3V RS232C DRIVER C8084 SHUTDOWN C8081 C8080 0.1u 0.1u AJ_TXD_4 T1_OUT AJ_RXD1 R8124 AJ_RXD_4 R1_IN C8082 AJ_TXD1 R8125 AJ_RXD4 0.1u R1_OUT R8126 ONLINE C8083 AJ_TXD4 T2_OUT 0.1u...
Page 88: D-Board (1 Of 2) Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.20. D-Board (1 of 2) Block Diagram DIGITAL SIGNAL PROCESSOR FORMAT CONVERTER, PlASMA AI SUB-FIELD PROCESSOR TO J1 IC9002 IC9001 R(M) R/PR(M) P+5V G(M) 8bit A/D CONVERTER 3.3V G/Y(M) +3.3V B(M) R,G,B B/PB(M) MAIN VIDEO...
Page 89: D-Board (2 Of 2) Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.21. D-Board (2 of 2) Block Diagram DIGITAL SIGNAL PROCESSOR FORMAT CONVERTER, PlASMA AI TO C24 SUB-FIELD PROCESSOR DOUTU19A U19A-U21C IC9302 IC9501 DOUTU21C 1.5V 2.5V 3.3V 1.5V 2.5V 3.3V PLASMA AI DRVRST SIGNAL PROCESSOR 3.3V...
Page 90: D-Board (1 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.22. D-Board (1 of 12) Schematic Diagram D-BOARD (1/12) TZTNP01YUSE (TH-65PHD8BK/EK) FL9051 J0MAB0000175 ANF_R_S TZTNP020YUS (TH-65PHD8UK) ANF_G_S J-BOARD EXPECT ANF_B_S (J1) PHD8UK R/PR_S PHD8UK ONLY R9028 PR_M G/Y_S ANF_R_M R9029 ANF_G_M G/Y_M ANF_B_M B/PB_S 12V->3.3V/1.4A...
Page 91: D-Board (2 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.23. D-Board (2 of 12) Schematic Diagram IC9002 C0CBCBC00190 PHD8UK ONLY C9069 C9070 R9070 R9073 6.3V 0.1u VOUT VOUT R9020 R9024 C9016 C9017 3.3V 6.3V 0.1u 3.3V C9066 C9067 6.3V 0.1u R9054 R9004 C9021 C9071 6.3V...
Page 92: D-Board (3 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.24. D-Board (3 of 12) Schematic Diagram FPGA FPGA_MODE DATA_DRIVER 1.2V VCCI VCCINT 3.3V DD_PCU1 IC9201 IO_L39P_2 IC9201 IC9201 DD_PCD1 FPGA3.3V IC9201 IC9201 IO_L20N_6 L9204 IC9201 IC9201 DD_PCU2 IC9201 C9226 C9214 IC9201 IO_L24N_2 PCU2 IC9201 IC9201 6.3V...
Page 93: D-Board (4 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.25. D-Board (4 of 12) Schematic Diagram D-BOARD (4/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) IC9103 C0JBAE000354 2.5V->3.3V 3.3V LEVEL CONVERTER C9108 3.3V 0.1u IC9304 IC9305 L9502 C9654 G1C150KA0038 6.3V IC9306 C0JBAZ000856 C0JBAZ000856 R9611 4.7k C0JBAZ000856 TDO_2V 3.3V->5V...
Page 94: D-Board (5 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.26. D-Board (5 of 12) Schematic Diagram D-BOARD (5/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) FL9305 FL9304 POWER 2.5V_L8 1.5V 1.5V_L8 2.5V_2 F1J1E1040022 F1J1E1040022 C9441 220u FL9502 3.3V 3.3V_L78 F1J1E1040022 3.3V_L78 C9387 IC9302 IC9302 IC9302 VDD33 16V 0.1u...
Page 95: D-Board (6 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.27. D-Board (6 of 12) Schematic Diagram L-UP R-UP TERM TERM C2-BOARD C2-BOARD (C24) (C25) FL9301 FL9300 F1J1E1040022 F1J1E1040022 TP9343 TP9344 TP9342 TP9345 3.3V 3.3V R9476 D9302 3.3V MA3X152K0L D9303 R9480 MA3X152K0L R9477 C9443 Q9301 4.7k...
Page 96: D-Board (7 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.28. D-Board (7 of 12) Schematic Diagram D-BOARD (7/12) DG-BOARD (1/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) P12V J-BOARD (J3) R9995 FL9707 STB5V_M F1J1E1040022 R9993 Q9078 R9986 STB3.3V B1ABCF000138 R9881 STB5V AR_IIC_CONT 5V_SCL3 3V_SCL3 P12V IIC_CONT R9882...
Page 97: D-Board (8 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.29. D-Board (8 of 12) Schematic Diagram D-BOARD (8/12) DG-BOARD (2/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) D9707 R9808 C9726 MA2J72800L 1000p STB3.3V C9709 0.1u STB3.3V R9810 C9594 R9826 R9805 0.1u Q9707 R9701 AAE_MCCLK R9803 R9785 B1ABCF000138...
Page 98: D-Board (9 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.30. D-Board (9 of 12) Schematic Diagram DG-BOARD (3/12) SYNC R9240 L8_VOUT IC9201 IO_L17P_3/VREF_3 XNVD L7_HOUT IC9201 IO_L17N_3 XNHD R9241 AM_VD IC9201 IO_L40N_6 VDIAA R9242 AM_HD IC9201 IO_L40P_6/VREF_6 R9243 HDIAA AM_CLK IC9201 IO_L32N_5/GCLK3 FPGA R9244...
Page 99: D-Board (10 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.31. D-Board (10 of 12) Schematic Diagram D-BOARD (10/12) DG-BOARD (4/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) 1.5V_L7 C9662 IC9501 VDD15 16V 0.1u C9663 IC9501 VDD15 16V 0.1u C9664 IC9501 VDD15 16V 0.1u C9665 IC9501 IC9501 IC9501 VDD15 16V 0.1u...
Page 100: D-Board (11 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.32. D-Board (11 of 12) Schematic Diagram D-BOARD (11/12) DG-BOARD (5/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) IC9501 MN845111-A IC9302 TIOCTL0 L8_R0 L8_PCK IC9302 IC9302 IC9302 TIOCTL1 SIGNAL PROCESSOR L8_R1 3.3V IC9302 IC9302 TCKSEL0 FORMAT CONVERTER 3.3V_L78...
Page 101: D-Board (12 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.33. D-Board (12 of 12) Schematic Diagram D-BOARD (12/12) DG-BOARD (6/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) DDR-SDRAM C9439 0.1u 2.5V_L8 IC9302 R9497 MN845121-A PLASMA AI R9498 SUB-FIELD PROCESSOR DRVCLKD0 L8DO_DA0 L8DO_DB0 L8DO_DC0 IC9302 DRVCLKD0 IC9302 DOUTDA00...
Page 102: C1, C2, C5 And C6-Board Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.34. C1, C2, C5 and C6-Board Block Diagram 26,36 48-29,20-15 16,25 R7187 DATA DATA 24bit U0A-U7C 24bit R7186 U14A DATA DRIVE U14A U21C U21C UPPER-RIGHT(FRONT VIEW) PCU2 PCU2 P+5V P+5V 18bit 6bit 6bit 6bit 6bit...
Page 103: C2, C3, C4 And C5-Board Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.35. C2, C3, C4 and C5-Board Block Diagram U4A-U7C U4A-U7C IC7209, IC7210 12bit U0A-U7C 12bit DATA DRIVE R7386 DATA BUFFER 24bit UPPER LEFT(FRONT VIEW) R7387 DRVRST P+5V U2A-U3C U2A-U3C IC7211 6bit 6bit 6bit 6bit 6bit...
Page 104: C1-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.36. C1-Board (1 of 2) Schematic Diagram C1-BOARD TNPA3663 (1/2) ZA7101 ZA7102 ZA7103 ZA7104 K4CD01000013 K4CD01000013 K4CD01000013 K4CD01000013 D7101 VDA_75V B0HCMM000014 C7107 100V 0.47u D7102 B0HCMM000014 L7101 L7102 78V_R J0JJC0000011 J0JJC0000011 R7111 R7115 C1_5V C7102...
Page 105: C1-Board (2 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.37. C1-Board (2 of 2) Schematic Diagram C1-BOARD TNPA3663 (2/2) R7173 R7174 EXB38V681JV EXB38V681JV C1_5_3V BUFFER 78V_R C7169 VDA_75V D7107 78V_R 78.0 B0HCMM000014 0.1u VDA_75V AA_DUC15 C7104 100V AA_DUB15 Vda 75V 0.47u AB_DUC15 75.0 D7108...
Page 106: C2-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.38. C2-Board (1 of 2) Schematic Diagram C2-BOARD TNPA3664 (1/2) C2_5_3V D7201 VDA_75V B0HCMM000014 R7253 EXB38V681JV R7252 C7232 C7274 EXB38V681JV 100V 0.1u 0.47u D7202 AA_DUC15 B0HCMM000014 AA_DUB15 AB_DUC15 L7203 L7204 78V_L AA_DUA15 AB_DUB15 J0JJC0000011 J0JJC0000011...
Page 107: C2-Board (2 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.39. C2-Board (2 of 2) Schematic Diagram C2-BOARD TNPA3664 (2/2) R7284 R7285 C2_5_3V EXB38V681JV EXB38V681JV BUFFER C7214 VDA_75V 0.1u D7205 B0HCMM000014 AA_DUC7 C7234 AA_DUB7 100V AB_DUC7 0.47u D7206 AA_DUA7 AB_DUB7 B0HCMM000014 AB_DUA7 78V_L 78V_L L7207...
Page 108: C3-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.40. C3-Board (1 of 2) Schematic Diagram R7392 R7393 EXB38V681JV EXB38V681JV C3_5_3V C3-BOARD TNPA3665 (1/2) BUFFER C7308 0.1u AA_DUC7 AA_DUB7 VDA_75V AB_DUC7 D7303 AA_DUA7 AB_DUB7 B0HCMM000014 AB_DUA7 AA_DUC6 AB_DUC6 C7359 AA_DUB6 100V D7304 R7303 0.47u...
Page 109: C3-Board (2 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.41. C3-Board (2 of 2) Schematic Diagram C3-BOARD TNPA3665 (2/2) VDA_75V D7305 B0HCMM000014 C7361 100V D7306 0.47u B0HCMM000014 78V_L L7305 L7306 J0JJC0000011 J0JJC0000011 R7378 R7382 C3_5V C7340 CA10 TERM R7374 R7384 PANEL DATA DRIVER C7351...
Page 110: C4-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.42. C4-Board (1 of 2) Schematic Diagram C4-BOARD TNPA3666 (1/2) R7447 C4_5_3V_B C7406 0.1u NUEL CLKL NUEL DRV_SOS9 CLK11 DRV_SOS9 R7405 DRV_SOS2 NCLKL CLK12 DRV_SOS2 DMHR R7406 CLK21 DMHR R7407 DMLL CLK22 DMLL R7408 DMHL...
Page 111: C4-Board (2 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.43. C4-Board (2 of 2) Schematic Diagram C4-BOARD TNPA3666 (2/2) ZA7401 ZA7402 ZA7403 ZA7404 K4CD01000013 K4CD01000013 K4CD01000013 K4CD01000013 VDA_75V D7411 B0HCMM000014 C7422 100V 0.47u D7412 B0HCMM000014 L7405 78V_L L7406 J0JJC0000011 J0JJC0000011 R7481 R7485 SS-BOARD (SS44)
Page 112: C5-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.44. C5-Board (1 of 2) Schematic Diagram D-BOARD (D34) C5-BOARD TNPA3667 (1/2) TERM C5_5V C6-BOARD FL7501 (C60) J0HABH000013 R7565 R7564 EXB38V681JV EXB38V681JV R7511 R7512 EXB38V681JV EXB38V681JV AB_DDC20 C5_5_3V C5_5_3V_B DOUTDC[20] C5_5_3V AB_DDB20 BUFFER R7539 BUFFER...
Page 113: C5-Board (2 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.45. C5-Board (2 of 2) Schematic Diagram C5-BOARD TNPA3667 (2/2) D-BOARD (D33) R7616 R7617 C5_5_3V EXB38V681JV EXB38V681JV BUFFER C7567 TERM 0.1u UEH_BUF USL_BUF C5_5V UML_BUF FL7502 R7618 J0HABH000013 EXB38V470JV NUEL UMH_BUF NUEL_BUF R7619 EXB38V470JV C4-BOARD...
Page 114: C6-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.46. C6-Board (1 of 2) Schematic Diagram C6-BOARD TNPA3668 (1/2) ZA7601 ZA7602 K4CD01000013 K4CD01000013 VDA_75V D7601 B0HCMM000014 C7653 100V 0.47u D7602 B0HCMM000014 L7601 L7602 R7611 R7615 78V_R J0JJC0000011 J0JJC0000011 C7602 C6_5V TERM PANEL DATA DRIVER...
Page 115: C6-Board (2 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.47. C6-Board (2 of 2) Schematic Diagram C6-BOARD TNPA3668 (2/2) C5-BOARD (C50) R7681 BUFFER C6_5_3V_B C7630 0.1u CLKR CLK11 NCLKR R7643 CLK12 R7644 CLK21 R7645 CLK22 R7646 R7601 R7602 R7672 R7647 R7648 AA_DDC20 DOUTDC[20] AA_DDB20...
Page 116: Sc, Su And Sd-Board Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.48. SC, SU and SD-Board Block Diagram TPVSET COLD FLOATING GND SC SCAN DRIVE SU SCAN OUT (UPPER) TPSC1 WAVEFORM TPVSUS TO P2 VSET VSET Gen. IC6654 PDP SCAN Vsus IC6653 IC6652 TPVSET (+230V) DRIVERx6...
Page 117: Sc-Board (1 Of 3) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.49. SC-Board (1 of 3) Schematic Diagram S2(CMH) VSUS TPVSUS Q6551 R6375 C6502 C6503 C6504 C6506 C6507 C6508 C6509 C6510 P-BOARD 250V 250V 250V 250V 250V Q6501 250V 250V 250V B1ABNF000006 R6501 10 2.2u (P2) 2.2u...
Page 118: Sc-Board (2 Of 3) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.50. SC-Board (2 of 3) Schematic Diagram TP061 Q6814 D6813 R6827 D1FL40 2SD1263AP0LB D6831 C6812 C6813 C6814 C6815 D6814 MA2J11100L R6886 630V 630V 630V R6831 R6807 3300p D1FL40 COLD FLOATING GND 3300p 3300p 3300p R6829...
Page 119: Sc-Board (3 Of 3) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.51. SC-Board (3 of 3) Schematic Diagram SU-BOARD SU-BOARD SC41 (SU41) SC42 (SU42) ZA6401 K4CD01000013 SU-BOARD ZA6402 (SU45) K4CD01000013 TP032 AA_FSIU AA_FSIU ZA6403 K4CD01000013 TP033 AA_FCLU TP034 AA_FCLU AA_FCLKU VF+5V TP035 AA_PROU AA_FCLKU 5V_F TP036...
Page 120: Su-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.52. SU-Board (1 of 2) Schematic Diagram SU-BOARD TNPA3673 (1/2) To 1st 96pins of To 2nd 96pins of SCAN ELECTRODES SCAN ELECTRODES AF_27 AF_38 AE_91 AE_102 AD_155 AD_166 AF_26 AF_39 AE_90 AE_103 AD_154 AD_167 AF_25...
Page 121: Su-Board (2 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.53. SU-Board (2 of 2) Schematic Diagram SU-BOARD TNPA3673 (2/2) To 3rd 96pins of To 4th 96pins of SCAN ELECTRODES SCAN ELECTRODES AC_219 AC_230 AB_283 AB_294 AA_347 AA_358 AC_218 AC_231 AB_282 AB_295 AA_346 AA_359 AC_217...
Page 122: Sd-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.54. SD-Board (1 of 2) Schematic Diagram SD-BOARD TNPA3674 (1/2) To 1st 96pins of To 2nd 96pins of SCAN ELECTRODES SCAN ELECTRODES AF_411 AF_422 AE_475 AE_486 AD_539 AD_550 AF_410 AF_423 AE_474 AE_487 AD_538 AD_551 AF_409...
Page 123: Sd-Board (2 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.55. SD-Board (2 of 2) Schematic Diagram SD-BOARD TNPA3674 (2/2) To 3rd 96pins of To 4th 96pins of SCAN ELECTRODES SCAN ELECTRODES AC_603 AC_614 AB_667 AB_678 AA_731 AA_742 AC_602 AC_615 AB_666 AB_679 AA_730 AA_743 AC_601...
Page 124: Ss, S1, Ss2 And Ss3-Board Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.56. SS, S1, SS2 and SS3-Board Block Diagram TO C44 SS51 VE Gen. SUSTAIN DRIVE TPVE (+150V) TPVe VR6250 Adj. D6257 SS52 IC6060 Q6256,Q6257 BUFFER TPSOS2 IC6252 SS23 TO P1 TPVSUS Vsus Q6118-Q6121 Q6160-Q6163 Vsus Gen.
Page 125: Ss-Board (1 Of 2), S1, Ss2 And Ss3-Board Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.57. SS-Board (1 of 2), S1, SS2 and SS3-Board Schematic Diagram SS53 Q6100 B1JADN000002 R6100 C6080 C6100 250V 630V 2.2u 5600p R6101 SS-BOARD TNPA3670 (1/2) R6139 R6138 R6137 R6136 Q6118 C6081 B1ABNF000006 250V R6102 Q6101 2.2u...
Page 126 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.58. SS-Board (2 of 2) Schematic Diagram C6202 470u L6223 J0JJC0000021 D6206 D1FL40 C6207 C6206 160V 160V Vda_75V Vda_75V 100u 100u Q6007 Q6200 R6219 2SB792ATX R6210 R6245 Q6210 2SK326900L 100k 5.9k B1ABNF000006 R6192 R6193 D6240...
Page 127 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 16 Parts Location 16.1. Exploded View 16.1.1. The main mechanical parts relation...
Page 128 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 16.1.2. Escutcheon part location enlarged view 16.1.3. Fan part location enlarged view...
Page 129 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 16.2. Cable relation...
Page 130: Packing Summary
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 16.3. Packing summary...
Page 131 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK...
Page 132 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK...
Page 133 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 17 Mechanical Replacement Parts List Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description EUR7636070R REMOTE CONTROLLER TQBC2064 INSTRUCTION BOOK (DUTCH) EUR7636090R REMOTE CONTROL BK/EK TQBC2065 INSTRUCTION BOOK...
Page 134 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 18 Replacement Parts List 18.1. Relpacement Parts List Notes...
Page 135 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 18.2. Electrical Replacement Parts List Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description F401 HU216002BP CARTRIDGE FUSE C472 KZE1E470 ELECTROLYTIC CAPACITOR F601,02 K5D103BMA001 TIME LAG FUSE HIGH...
Page 136 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description C836 ECJ3YB1C225K C 0.022UF, K, 16V C2358,5 EEEHP1V2R2R E 2.2UF, 35V C837 F1J0J1060004 C 0.010UF, K, 16V C2360,6 ECJ2XC1H102J...
Page 137 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description C3014 EEEHB1C470P C 47PF, J, 16V (HB) C3127 ECJ2VF1C105Z C 1UF, Z, 16V C3015 ECJ1VF1H103Z C 0.010UF, Z, 50V...
Page 138 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description C3261 EEEHB0G221P C 220PF, J, 4V C6226 TCUY1C105ZFN C 1UF, 16V C3262 ECJ1XB1H102K C 1000UF, Z, 50V C6233 F1L1E4750004 C 4.7UF, 25V...
Page 139 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description C6651 TCUY1C105ZFN C 1UF, 16V C7139 TCUY1C105ZFN C 1UF, 16V C6653 TCUY1C105ZFN C 1UF, 16V C7150 ECJ1XC1H101J C 100PF, J, 50V...
Page 140 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description C7560 ECJ1XB1C104K C 0.1UF, Z, 16V C8114 ECJ2VF1H103Z C 0.010UF, Z, 50V C7563,6 ECJ1XB1C104K C 0.1UF, Z, 16V C8115...
Page 141 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description C9379 EEEHB1C470P C 47PF, J, 16V C9726 ECJ1XF1H102Z C 1000PF, Z, 50V C9383 ECJ1XF1C104Z C 0.1UF, Z, 16V C9733 ECJ2FF1C475Z C 0.047UF, Z, 16V...
Page 142 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description D705 M1FS6 DIODE D6215 B0HDSM000005 DIODE D709 FCF06A40 DIODE D6221 B0JCME000037 DIODE D801 B0JCPD000026 DIODE D6225 B0JCME000037 DIODE D802,03 B0JCME000037...
Page 143 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description D6640- MA111 DIODE D9500,0 B0JCDD000002 DIODE D6643 B0HCMM000014 DIODE D9502,0 B0JCPE000004 DIODE D6644- MA8056H ZENER DIODE D9702- MA3033 ZENER DIODE...
Page 144 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description IC3302 C0DBEZG00018 IC9031 C0JBAZ002198 IC3303 AN80L25RMS IC9051 C0FBAD000102 IC3304 C0JBAZ002344 IC9052 C0CBCBC00190 IC3305 JLC1562BF MOS IC (MICON LSI) IC9101...
Page 145 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description L401,02 EXCELSA35 BEAD CHOKE L6052 G0ZZ00002183 PEAKING COIL L452 EXCELDR35 FERRITE BEAD L6054 G0ZZ00002183 PEAKING COIL INDUCTOR L6068 J0JJC0000021...
Page 146 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description L9205,0 J0JHC0000096 CHIP INDUCTOR Q3001 2SB709A TRANSISTOR Q3001 2SD601A TRANSISTOR (HA) L9401- J0JHC0000096 CHIP INDUCTOR Q3002 2SD601A TRANSISTOR (HB)
Page 147 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description Q6537- B1JADN000002 TRANSISTOR Q9300- 2SD601A TRANSISTOR Q6543- 2SK349400L Q9500,0 B1MBCDA00002 TRANSISTOR Q6551 B1ABNF000006 TRANSISTOR Q9502 B1ABMD000004 TRANSISTOR Q6552 B1ADNF000006...
Page 148 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description R623 ERJ6GEYJ103 M 10KOHM,J,1/10W R907,08 ERJ14YJ104 M 100KOHM, J,1/4W R624 ERJ6GEYJ183 M 18KOHM,J,1/10W R955 ERJ6GEYJ472 M 4.7KOHM,J,1/10W R625 ERJ6GEYJ332 M 3.3KOHM,J,1/10W...
Page 149 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description R2374 ERX1FJSR56D M0.56 OHM, J, 1W R3017 J0JCC0000100 CHIP INDUCTOR R2376 ERJ6GEYJ332 M 3.3KOHM,J,1/10W R3017 ERJ3GEYJ103 M 10KOHM,J,1/16W (HA)
Page 150 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description R3049 ERJ3GEYJ334 M 330KOHM,J,1/16W R3117 J0JCC0000100 CHIP INDUCTOR R3049 ERJ3GEYJ102 M 1KOHM,J,1/16W (HB) R3117 ERJ3GEYJ102 M 1KOHM,J,1/16W (HB) R3050...
Page 151 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description R3183 ERJ3EKF1401 M 1.4KOHM, 1/16W R6000- ERJ14YJ100 M 10 OHM, J,1/4W R3184 ERJ3EKF1101 M 1.1KOHM, 1/16W R6012 ERJ6GEYJ101 M 100 OHM,J,1/10W...
Page 152 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description R6216,1 ERJ6GEYJ101 M 100 OHM,J,1/10W R6385 ERJ6GEYJ681 M 680 OHM,J,1/10W R6386 ERJ6GEYJ272 M 2.7KOHM,J,1/10W R6219 ERJ6GEYJ104 M 100KOHM,J,1/10W R6387 ERJ6GEYJ332 M 3.3KOHM,J,1/10W...
Page 153 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description R6575 ERJ6GEYJ100 M 10 OHM,J,1/10W R6762 ERG1FJS101D M 100 OHM, J, 1W R6576 ERJ6GEYJ103 M 10KOHM,J,1/10W R6763,6 ERJ6GEYJ224 M 220KOHM,J,1/10W...
Page 154 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description R6900 ERJ6GEYJ103 M 10KOHM,J,1/10W R7217,1 EXB38V681J RESISTOR ARRAY R6901 ERJ6GEYJ221 M 220 OHM,J,1/10W R7221,2 EXB38V470J RESISTOR ARRAY R6902 ERJ6GEYJ224...
Page 155 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description R7373,7 TAJAAH0470JV M 47 OHM,J,1/16W R7535- TAJAAH0470JV M 47 OHM,J,1/16W R7377,7 ERJ12YJ2R2 M 2.2 OHM, J,1/2W R7538 ERJ6GEY0R00 M 0 OHM, 1/10W...
Page 156 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description R7667,6 EXB38V470J RESISTOR ARRAY R8124- ERJ6GEYJ101 M 100 OHM,J,1/10W R7669,7 EXB38V681J RESISTOR ARRAY R8129 ERJ6GEY0R00 M 0 OHM, 1/10W...
Page 157 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description R9104- ERJ3GEY0R00 M 0 OHM, 1/16W R9284 ERJ3GEY0R00 M 0 OHM, 1/16W R9286 ERJ3GEYJ223 M 22KOHM,J,1/16W R9108 EXB38V103J RESISTOR ARRAY...
Page 158 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description R9482 ERJ3GEYJ472 M 4.7KOHM,J,1/16W R9653,5 ERJ3GEY0R00 M 0 OHM, 1/16W R9484 ERJ3GEYJ104 M 100KOHM,J,1/16W R9656- ERJ3GEY0R00 M 0 OHM, 1/16W...
Page 159 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description R9762 ERJ3GEYJ153 M 15KOHM,J,1/16W R9861 ERJ3GEYJ332 M 3.3KOHM,J,1/16W R9765 TAJAAH0101JV M 100 OHM,J,1/16W R9863 ERJ3GEYJ103 M 10KOHM,J,1/16W R9766 ERJ3GEYJ393...
Page 160 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK Ref. Part No. Part Name & Remarks Ref. Part No. Part Name & Remarks Description Description TNPA3665 CIRCUIT BOARD C3 ZA007 K4CD01000013 TERMINAL TNPA3666 CIRCUIT BOARD C4 ZA3001- K4CD01000013 TERMINAL TNPA3667 CIRCUIT BOARD C5 ZA6101-...

This manual is also suitable for:

Th-65phd8ek Th-65phd8uk

Panasonic TH-65PHD8BK Service Manual

1 Applicable Signals

2 Safety Precautions

3 Prevention of Electro Static Discharge (ESD) to Electrostatically Sensitive (ES) Devices

4 About Lead Free Solder (Pbf)

5 PCB Structure Sheet of GPH8D Chassis

6 Service Hint

8 Location of Lead Wiring

9 Adjustment Procedure

10 Service Mode

11 Alignment

12 Trouble Shooting Guide

13 Option Setting

14 Circuit Board Layout

15 Schematic Diagrams

Quick Links

Related Manuals for Panasonic TH-65PHD8BK

Summary of Contents for Panasonic TH-65PHD8BK

This manual is also suitable for:

Table of Contents