Related Manuals for Hoshizaki HNC-180BA-L/R-S
Summary of Contents for Hoshizaki HNC-180BA-L/R-S
- Page 1 Instruction Manual Counter Showcase Models HNC-120BA-L/R-S HNC-150BA-L/R-S HNC-180BA-L/R-S HNC-210BA-L/R-S hoshizakiamerica.com Issued: 8-1-2016...
- Page 2 WARNING Only qualifi ed service technicians should install and service the appliance. To obtain the name and phone number of your local Hoshizaki Certifi ed Service Representative, visit www.hoshizaki.com. No installation or service should be undertaken until the technician has thoroughly read this Instruction Manual. Likewise, the owner/manager should not proceed to operate the appliance until the installer has instructed them on its proper operation.
-
Page 3: Table Of Contents
IMPORTANT This manual should be read carefully before the appliance is installed and operated. Read the warnings and guidelines contained in this manual carefully as they provide essential information for the continued safe use and maintenance of the appliance. Retain this manual for any further reference that may be necessary. CONTENTS PAGE Important Safety Information ----------------------------------------------------------------------------- 3... -
Page 4: Important Safety Information
Important Safety Information Throughout this manual, notices appear to bring your attention to situations which could result in death, serious injury, damage to the appliance, or damage to property. WARNING Indicates a hazardous situation which could result in death or serious injury. AVERTISSEMEN T Signale une situation dangereuse qui peut entraîner des blessures graves voire mortelles. -
Page 5: General Information
I. General Information A. Construction Nameplate Joint Hose Plug* Power Switch (Ground Fault Circuit Interrupter) Condenser Air Filter Slider Louver Sliding Glass Door Food Mount *Note: Always attach the plug(s) to the drain holes located in the showcase. Fig. 1... -
Page 6: Installation And Operating Instructions
II. Installation and Operating Instructions A. Checks Before Installation * Visually inspect the exterior of the shipping container, and any severe damage noted should be reported to the carrier. NOTICE Remove shipping carton, evaporator spacer, tape and packing material. If packing material is left in the showcase, it will not work properly. -
Page 7: Setup
If the foundation is not firm enough, it may No good Good warp and cause some space between its center and the showcase bottom. In this case, provide a support to keep the foundation level. Support * Avoid a site where dripping is not allowed. Fig. -
Page 8: Electrical Connections
1) Unpack the showcase, and remove the shipping carton, evaporator spacer, tape and packing material BEFORE operating the unit. Be careful not to damage the exterior panels when handling the showcase. 2) Position the showcase in a selected site. Clean the interior with soap and water and rinse thoroughly. -
Page 9: Final Checklist
F. Final Checklist 1) Is the showcase level? 2) Is the showcase in a site where the ambient temperature is within 50°F (10°C) to 80°F (27°C) all year around? 3) Have the shipping carton, evaporator spacer, tape and packing material been removed from the showcase? 4) Have all electrical and piping connections been made? 5) Has the power supply voltage been tested or checked against the nameplate rating? - Page 10 IMPORTANT • The showcase is intended to display sushi materials and keep them cool during business hours. The showcase contains a large amount of glass and provides less refrigeration and cold storage capacity than ordinary refrigerators. Before displaying sushi materials, allow the showcase to operate for about 1 hour to cool down. Fully refrigerate sushi materials in a refrigerator prior to displaying them in the showcase.
-
Page 11: Maintenance And Cleaning Instructions
1) Either mix 0.26 gal. (1 liter) of water with 0.13 fl . oz. (3.7 ml) of 5.25% sodium hypochlo- rite solution in a suitable container, or the recommended Hoshizaki sanitizer as directed. 2) Disconnect the hose from the joint. -
Page 12: Air Filter
C. Air Filter Louver A plastic mesh air filter removes dirt or dust from the air, and keeps the condenser from getting clogged. If the fi lter gets clogged, the showcase’s performance will be reduced. Check the fi lter at least twice a month. When clogged, use warm water and a neutral cleaner to wash the fi... - Page 13 618 Hwy. 74 South, Peachtree City, GA 30269 USA (P) 770.487.2331 (F) 770.487.3360 hoshizakiamerica.com L1S014102...