Air Source; Safety Symbol Definitions; Specific Safety Instructions - Central Pneumatic 95211 Owner's Manual And Safety Instructions

Tool Use and Care (cont.)
4. Check for misalignment or binding of
moving parts, breakage of parts, and any
other condition that affects the hose reel's
operation. If damaged, have the hose reel
serviced before using. Many accidents are caused
by poorly maintained hose reels. There is a risk
of bursting if the hose reel is damaged.
Service
1. Hose reel service must be performed
only by qualified repair personnel.
2. When servicing a hose reel, use only identical
replacement parts. Use only authorized parts.

Air Source

1. Never connect to an air source that is
capable of exceeding 200 psi.
Over pressurizing the hose reel may
cause bursting, abnormal operation,
breakage of the hose reel or serious
injury to persons. Use only clean, dry, regulated
compressed air at the rated pressure or within the
rated pressure range as marked on the hose reel.
Always verify prior to using the hose reel that the air
source has been adjusted to the rated air pressure or
within the rated air-pressure range.

Safety Symbol Definitions

Symbol Property or statement
PSI
Pounds per square inch of pressure
NPT
National pipe thread, tapered
WARNING marking
concerning Risk of Eye Injury.
Wear ANSI-approved eye protection.

Specific Safety Instructions

1. The warnings and precautions discussed in this
manual cannot cover all possible conditions and
situations that may occur. It must be understood
by the operator that common sense and caution
are factors which cannot be built into this
product, but must be supplied by the operator.
2. Obey the manual for the air hose reel and
air compressor used with this hose reel.
Item 95211
SAVE THESE INSTRUCTIONS.
For technical questions, please call 1-888-866-5797.
5. Use only accessories that are identified by
the manufacturer for the specific hose reel
model. Use of an accessory not intended
for use with the specific hose reel model,
increases the risk of injury to persons.
3. Use only the lubricants supplied with the
hose reel or specified by the manufacturer.
2. Never use oxygen, carbon dioxide, combustible
gases or any bottled gas as an air source
for the hose reel. Such gases are capable
of explosion and serious injury to persons.
Symbol Property or statement
WARNING marking concerning
Risk of Respiratory Injury. Wear
NIOSH-approved dust mask/respirator.
WARNING marking concerning
Risk of Explosion.
3. Install an in-line shutoff valve to allow
immediate control over the air supply in an
emergency, even if a hose is ruptured.
4. WARNING: The brass components of
this product contain lead, a chemical
known to the State of California to cause
birth defects (or other reproductive harm).
(California Health & Safety code § 25249.5, et seq.)
Page 3