DriSteem GTS04 Manual

DriSteem GTS04 Manual

Humidififier, standard water

Advertisement

Available languages

Available languages

DRISTEEM GTS
®
WARNING
Indicates a hazardous situation that could result in death or
serious injury if instructions are not followed.
mc_051508_1145
WARNING
Read all warnings and instructions
This page provides important safety instructions; it is intended to supplement — not replace — the humidifi er's Installation,
Operation, and Maintenance Manual (IOM). Read the IOM that was provided with the humidifi er before performing
service or maintenance procedures on any part of the system. Failure to follow all warnings and instructions could
produce the hazardous situations described here and in the IOM, resulting in property damage, personal injury, or
death.
If the IOM is missing, go to www.dristeem.com to download a replacement.
Hot surfaces and hot water
Steam humidifi cation systems have extremely hot surfaces, and water in tanks, electrode cylinders, steam pipes, and
dispersion assemblies can be as hot as 212 °F (100 °C). To avoid severe burns, allow the entire humidifi cation system to
cool.
Follow the cool-down procedure in the humidifi er's IOM before performing service or maintenance procedures on any
part of the system.
Carbon monoxide, fi re, explosion, and electrical shock hazards
Improper installation, adjustment, alteration, service, maintenance, or use can cause carbon monoxide poisoning, fi re,
explosion, electrical shock, and other hazardous conditions. These hazardous conditions could cause personal injury,
property damage, or death. To prevent hazardous conditions, read all warnings; lock all power disconnect switches in
the OFF position before removing any access panels; and consult a qualifi ed installer, service agency, local gas supplier,
or your distributor or branch for information or assistance. The qualifi ed installer or agency must use only factory
authorized and listed kits or accessories when modifying this product.
If you smell gas:
Do not try to light any appliance.
Do not touch any electrical switch; do not use any phone in your building.
Immediately call your gas supplier from an off-site phone. Follow the gas supplier's instructions.
If you cannot reach your gas supplier, call the fi re department.
Electrical shock hazard
If the humidifi er starts up at a call for humidity during maintenance, severe bodily injury or death from electrical shock
could occur. To prevent such start-up, follow the procedure below before performing service or maintenance procedures
on this humidifi er (after the tank has cooled down and drained):
1. Use the Vapor-logic
2. Shut off all electrical power to the humidifi er using the fi eld-installed fused disconnect, and lock all power disconnect
switches in the OFF position.
3. Close the fi eld-installed manual water supply and gas shut-off valves.
Parts in this service kit are for the GTS04 humidifi er (October 2004 to present). Parts are listed on page 2.
HUMIDIFIFIER, STANDARD WATER
®
keypad to change the control mode to Standby.
Service Kit Manual
CAUTION
Indicates a hazardous situation that could result in damage to
or destruction of property if instructions are not followed.
Water Treatment Systems

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the GTS04 and is the answer not in the manual?

Questions and answers

Summary of Contents for DriSteem GTS04

  • Page 1 2. Shut off all electrical power to the humidifi er using the fi eld-installed fused disconnect, and lock all power disconnect switches in the OFF position. 3. Close the fi eld-installed manual water supply and gas shut-off valves. Parts in this service kit are for the GTS04 humidifi er (October 2004 to present). Parts are listed on page 2.
  • Page 2 Damage from hot discharge water Discharge water can be as hot as 212 °F (100 °C) and can damage the drain plumbing. If the humidifi er is equipped with a water tempering device such as a DriSteem Drane-kooler ™ , it needs fresh make-up water in order to function properly.
  • Page 3 GTS, standard water, service kit parts This service kit contains the replacement parts called out in the parts drawing to keep your DriSteem humidifi er operating at peak performance. This Probe Tool Service Kit Manual provides important safety and service instructions; it is intended to supplement — not replace —...
  • Page 4: Inspection Recommendations

    (adjusted using the keypad/display Table 4-1; if not, consult DriSteem. Setup screens) is less than room temperature (default setting is 40 °F [4 °C]) so the burners do not energize Table 4-1: while cooling down the tank.
  • Page 5: Inspection And Maintenance

    • The bottom 3/8" (10 mm) of each rod is the 2. After cleaning, the humidifier should remain empty sensing portion; clean these areas with a wire until humidification is required. brush, abrasive pad, or steel wool. GTS DRISTEEM STANDARD SERVICE MANUAL...
  • Page 6: Burner Maintenance Instructions

    DRI-STEEM Corporation; therefore, product features and specifi cations are subject to change without notice. DriSteem products are warranted according to the terms and conditions of DRI-STEEM, GTS, and Vapor-logic are the standard two-year Limited Warranty effective when the humidifi er was registered trademarks of DRI-STEEM purchased.
  • Page 7 3. Fermer les robinets de sectionnement d'alimentation manuelle en eau et en gaz installés sur site. Les pièces citées dans ce nécessaire d'entretien sont prévues pour l'humidifi cateur GTS04 (octobre 2004 à ce jour). Les pièces sont répertoriées en page 2.
  • Page 8 La température de l'eau de refoulement peut atteindre 100 °C et endommager la plomberie de vidange. Si l'humidifi cateur est équipé d'un dispositif de tempérage de l'eau comme DriSteem Drane-kooler™, il a besoin d'eau d'appoint fraîche pour fonctionner correctement. S'assurer que l'alimentation en eau du Drane-kooler reste ouverte lors de la vidange.
  • Page 9 GTS, eau standard, pièces du nécessaire d'entretien Le nécessaire d'entretien contient les pièces de rechange référencées dans le schéma des pièces qui permettent à votre humidifi cateur DriSteem de continuer à fonctionner au maximum de ses performances. Ce Manuel du nécessaire d'entretien fournit des consignes d'entretien et de sécurité...
  • Page 10 10-1 déplaçant le levier situé à l'arrière du robinet de ; si ce n'est pas le cas, consulter DriSteem. vidange en position d'ouverture manuelle. Le robinet de remplissage s'ouvrira dès qu'une quantité suffi sante Tableau 10-1 : d'eau aura été...
  • Page 11: Inspection Et Maintenance

    2. Après le nettoyage, l'humidificateur doit demeurer vide a. L'eau devrait s'écouler par le tuyau de vidange jusqu'à ce qu'il y ait un besoin d'humidification. de l'écumoire après chaque cycle de remplissage. GTS DRISTEEM, EAU STANDARD, MANUEL DU NÉCESSAIRE D'ENTRETIEN...
  • Page 12 © 2015 DRI-STEEM Corporation Les produits DriSteem sont garantis selon les modalités de la garantie limitée Formulaire n° GTS-standard_Service_Kit_ de deux ans standard prenant effet à la date d'achat de l'humidifi cateur. Voir Manual_0715 la documentation fournie avec l'humidifi...
  • Page 13 2. Die Stromversorgung am bauseitigen gesicherten Hauptschalter abschalten und alle Schalter in Position AUS sperren. 3. Die bauseitigen manuellen Wasser- und Gaszufuhrventile schließen. Teile für diesen Wartungssatz passen zu Befeuchter GTS04 (Oktober 2004 bis heute). Für Teileliste siehe Seite 2.
  • Page 14 ACHTUNG Schäden aufgrund heißem Abwasser Abwasser kann bis zu 100 °C heiß sein und die Ablaufverrohrung beschädigen. Ist der Befeuchter mit einem Abwasserkühlgerät wie z.B. dem DriSteem Drane-kooler ™ ausgerüstet muss ein Kaltwasseranschluss vorhanden sein, damit das Gerät ordnungsgemäß funktioniert. Daher sicherstellen, die Wasserzufuhr zum Drane-kooler-Kühlgerät ist während des Abkühlvorgangs geöffnet.
  • Page 15 Ausrichtung erfordern, wie dargestellt in der Klares Silikon (4) auf Zeichnung. beiden Seiten der Dichtung auftragen. Abzugskammer Falls ausgebaut, säubern und Hochtemperatur-Silikon (5) entlang der Stoßfl ächen erneuern. Anziehmoment 2,8 bis 4,0 Nm OM-1243X DRISTEEM GTS, NORMALWASSER, ANLEITUNG FÜR WARTUNGSSATZ...
  • Page 16 Andernfalls bleibt der Tank noch für mehrere Stunden heiß. 1. Sicherstellen, es wird keine Befeuchtung gefordert und der Wasserthermostat-Einstellwert liegt unter der aktuellen Raumtemperatur (Einstellung mit Hilfe des Steuergeräts in Anzeige Setup, Vorgabeeinstellung ist DRISTEEM GTS, NORMALWASSER, ANLEITUNG FÜR WARTUNGSSATZ...
  • Page 17: Inspektion Und Wartung

    4. Den Skimmer-/Überlaufanschluss reinigen: a. Wasser sollte nach jedem Fülltakt über das Skimmerablaufrohr auslaufen. Diesen Ablaufvorgang einmal wöchentlich einer Sichtprüfung unterziehen. b. Ablagerungen in und um den Skimmer-/ Überlaufanschluss mit einem langen Schraubendreher oder ähnlichem Werkzeug entfernen. DRISTEEM GTS, NORMALWASSER, ANLEITUNG FÜR WARTUNGSSATZ...
  • Page 18 STEEM Corporation und als eingetragene Installations- und Bedienungsanleitung. Warenzeichen in Kanada und der EU beantragt. DriSteem Produkte sind garantiert für einen Zeitraum von zwei Jahren ab Drane-kooler ist ein Warenzeichen von dem Kaufdatum entsprechend den Konditionen der zweijährigen begrenzten DRI-STEEM Corporation.

Table of Contents

Save PDF