Final Check Lists - Blodgett BCX-14G Installation Operation & Maintenance

WARNING!!
Final check list must be performed by a quali-
fied installer only.
ELECTRICAL CONTROL COMPARTMENT
• Voltage to appliance matches rating plate
PLUMBING FINAL CHECK
• Incoming water pressure within appliance specifica-
tion.
• Atmospheric vented drain in place.
• Water feed lines intact without leaks.
• Ensure proper clearance as detailed.
• Delime system has been primed. BCX-14 only.
OVEN OPERATIONAL TESTS
NOTE: Checks to be made by customer or authorized
service agent.
Cool Down Mode
• Check that the fan runs with the door open.
Steam Mode - BCX-14 and BX-14 only
Turn on STEAM mode and set thermostat to 200°F. Verify
the following:
• The oven is preheating and shows the actual cavity
temperature rising.
• Boiler heat demand shuts off at approximately 200ºF
(100ºC) and regulates the cavity temperature to
200ºF.
• Set timer for 1 minute and start. Be sure the beeper
sounds when the time expires.
• Power light turns on.
• Unit produces steam, window fogs, door seal does
not leak.
Combi Mode - BCX-14 and BX-14 only
Change to COMBI mode, set thermostat to 350ºF (177ºC)
and verify:
• The oven is preheating and shows the actual cavity
temperature rising.
• Heat demand shuts off at 350ºF (177ºC) and oven
maintains 350ºF (177ºC).
• Fan shuts off with door open.
Hot Air Mode - All models
Change to HOT AIR mode and set thermostat to 400ºF
(204ºC) and verify:
• The oven is preheating and shows the actual cavity
temperature rising.
• Heat demand shuts off at 400ºF (204ºC) and oven
maintains 400ºF (204ºC).
• Fan shuts off with door open.
Steam On Demand Mode - BCX-14 and BX-14 only
Turn the oven to Hot Air mode. Press the steam on de-
mand key. Set Steam On Demand for 1 minute.
• The Steam On demand timer is counting down.
• The steam on demand counter goes away after the
timer expires.
Lights
• Press switch to ensure lights come on.
Cavity Vent
• Press the vent key to ensure that the vent opens and
closes.
Fan Speed
• Ensure all fan speeds work on the preheated oven
using the fan key and knob.
17
Installation

Final Check Lists