Product Information and Technical Guide Side by Side and Top Mount Refrigerators January 2005 - June 2005 ® ® White-Westinghouse ® October 2005 5995449906...
Page 2
Service Data Sheet, Refrigerant Charge & Energy Efficiency Rating Indexes ------------------- 3 - 17 Troubleshooting Guide --------------------------------------------------------------------------------------------- 18- 22 Appendix A - Service Data Sheets 240379005 --------------------------------------------------------------------------------------------------------- A1 - A2 240379011 --------------------------------------------------------------------------------------------------------- A3 - A4 240379014 --------------------------------------------------------------------------------------------------------- A5 - A6...
Page 3
Electrolux Home Products, Inc. cannot be responsible, nor assume any liability, for injury or damage of any kind arising from the use of this manual.
Page 9
Cha rge Ene rgy Efficie ncy Ra ting Mode l Se rvice Da ta She e t Bra nd (oz.) (KW H / Ye a r) FRT18IS6CW C 240379015 4.25 Frigidaire FRT18IS6CW D 240379015 4.25 Frigidaire FRT18KB2DW 0 240379015 Frigidaire FRT18KB2DW 2 240379015 Frigidaire...
Page 10
Cha rge Ene rgy Efficie ncy Ra ting Mode l Se rvice Da ta She e t Bra nd (oz.) (KW H / Ye a r) FRT21G4BW C 240279014 4.25 Frigidaire FRT21HC5DW 5 240279014 4.25 Frigidaire FRT21HC5DW 7 240379014 4.25 Frigidaire FRT21HS6DB3 240379014...
TROUBLESHOOTING GUIDE PROBLEM CAUSE SOLUTION Compressor will not run. No voltage at wall receptacle. Check circuit breaker, fuse or GFCI (Ground Fault Circuit Interruptor - It is not recommended to connect your refrigerator to a GFCI.) Service cord defective or unplugged at Check service cord.
Page 20
PROBLEM CAUSE SOLUTION Compressor short cycles. Erratic control thermostat. Replace control thermostat. Faulty relay. Replace relay or starter. Restricted air flow over condenser. Ensure air flow is unobstructed over condenser. Low voltage … fluctuation exceeds ± 10% Call qualified electrician. of 115 vac (104-127).
Page 21
CAUSE PROBLEM SOLUTION Freezer compartment too warm. Inoperative evaporator fan motor. Check wiring and evaporator fan motor. Check ADC on Side-by-Sides with electrical mechanical control. Check the electronic control on SxS models equipped with the electronic control system. Fig. A Improperly positioned fan blade.
Page 22
CAUSE PROBLEM SOLUTION Refrigerator compartment too warm. Inoperative evaporator fan motor. Check wiring and evaporator fan motor. (Check ADC on Side-by-Sides.) Improperly positioned fan blade. Position fan blade properly. See page 20, Figure A. Evaporated frosted up. Check defrost system timers ADC and electronic control depending on control system product is equipped with.
Page 23
CAUSE PROBLEM SOLUTION Refrigerator compartment too cold. Inoperative cold control or electronic Replace cold control or electronic control. control. (Continued) Refrigerator compartment inlet air Re-install air duct or remove obstruction from duct loose or restricted. Door is loose. air duct. Adjust door. Diffuser (foam block) in top of food Replace diffuser.
Page 24
SERVICE DATA SHEET ICE MAKER INFORMATION STANDARD - AUTOMATIC ° 5 ° 8 ° 0 ° 2 Test Cycling P/N: 240379005 DEFROST TOP FREEZER (12594301) MODELS (R134a) Remove cover by inserting screwdriver in notch at bottom and prying ° 2 ° 8 °...
Page 26
SERVICE DATA SHEET ICE MAKER INFORMATION STANDARD - AUTOMATIC ° 5 ° 8 ° 0 ° 2 Test Cycling P/N: 240379011 DEFROST TOP FREEZER MODELS (R134a) Remove cover by inserting screwdriver in notch at bottom and prying ° 2 ° 8 °...
Page 27
Pictorial Schematic Ladder Schematic NOTE: _ _ _ _ _ _ DENOTES NOT ON ALL MODELS COMPRESSOR WIRING Induction Run Compressor with Relay 15 & 17 CUBIC FOOT 18 CUBIC FOOT 21 CUBIC FOOT SERVICE PARTS STATIC DYNAMIC E-STAR STATIC DYNAMIC E-STAR DYNAMIC...
Page 28
SERVICE DATA SHEET ICE MAKER INFORMATION STANDARD - AUTOMATIC ° 5 ° 8 ° 0 ° 2 Test Cycling P/N: 240379014 DEFROST TOP FREEZER MODELS (R134a) Remove cover by inserting screwdriver in notch at bottom and prying ° 2 ° 8 °...
Page 29
Pictorial Schematic Ladder Schematic NOTE: _ _ _ _ _ _ DENOTES NOT ON ALL MODELS COMPRESSOR WIRING Induction Run Compressor with Relay 15 & 17 CUBIC FOOT 18 CUBIC FOOT 21 CUBIC FOOT SERVICE PARTS STATIC DYNAMIC E-STAR STATIC DYNAMIC E-STAR DYNAMIC...
Page 30
SERVICE DATA SHEET ICE MAKER INFORMATION STANDARD - AUTOMATIC ° 5 ° 8 ° 0 ° 2 Test Cycling P/N: 240379015 DEFROST TOP FREEZER MODELS (R134a) Remove cover by inserting screwdriver in notch at bottom and prying ° 2 ° 8 °...
Page 31
Pictorial Schematic Ladder Schematic NOTE: _ _ _ _ _ _ DENOTES NOT ON ALL MODELS COMPRESSOR WIRING Induction Run Compressor with Relay 15 & 17 CUBIC FOOT 18 CUBIC FOOT 21 CUBIC FOOT SERVICE PARTS STATIC DYNAMIC E-STAR STATIC DYNAMIC E-STAR DYNAMIC...
Page 32
SERVICE DATA SHEET - 240389604 ICE MAKER INFORMATION R134a t i c F ° ° 8 F ° ° 2 Test Cycling ICE & WATER - AUTOMATIC DEFROST SIDE BY SIDE MODELS Remove cover by inserting screwdriver in notch at bottom and prying °...
Page 34
SERVICE DATA SHEET - 240389616 ICE MAKER INFORMATION R134a h t i t i c F ° ° 8 F ° ° 2 Test Cycling ICE & WATER - AUTOMATIC DEFROST n i t SIDE BY SIDE MODELS Remove cover by inserting screwdriver in notch at bottom and prying °...
Page 35
23 CUBIC FOOT 26 CUBIC FOOT SERVICE PARTS STANDARD E-STAR STANDARD E-STAR Compressor Kit * 5303918303 5303918299 5303918303 5303918298 Starter/PTC/TSD * 241524604 241527802 241524604 241527801 Run Capacitor * 218909913 218909915 218909913 218909915 Temp. Control-Refr 241507701 241507701 241507701 241507701 Temp. Control-Frzr 450226-07 450226-07 450226-07...
Page 36
SERVICE DATA SHEET - 240389618 ICE MAKER INFORMATION R134a Test Cycling h t i t i c F ° ° 8 F ° ° 2 ICE & WATER - AUTOMATIC DEFROST Press the momemtary contact on the ON/OFF switch for n i t SIDE BY SIDE MODELS approximately 15 seconds.
Page 37
23 CUBIC FOOT 26 CUBIC FOOT SERVICE PARTS STANDARD E-STAR STANDARD E-STAR Compressor Kit * 5303918303 5303918299 5303918303 5303918298 Starter/PTC/TSD * 241524604 241527802 241524604 241527801 Run Capacitor * 218909913 218909915 218909913 218909915 Temp. Control-Refr 241507701 241507701 241507701 241507701 Temp. Control-Frzr 450226-07 450226-07 450226-07...
Page 38
SERVICE DATA SHEET - 240389620 ICE MAKER INFORMATION R134a Test Cycling h t i t i c F ° ° 8 F ° ° 2 ICE & WATER - AUTOMATIC DEFROST Press the momemtary contact on the ON/OFF switch for n i t SIDE BY SIDE MODELS approximately 15 seconds.
23 CUBIC FOOT 26 CUBIC FOOT SERVICE PARTS STANDARD E-STAR STANDARD E-STAR Compressor Kit * 5303918303 5303918299 5303918303 5303918298 Starter/PTC/TSD * 241524604 241527802 241524604 241527801 Run Capacitor * 218909913 218909915 218909913 218909915 Temp. Control-Refr 241507701 241507701 241507701 241507701 Temp. Control-Frzr 450226-07 450226-07 450226-07...
Page 40
SERVICE DATA SHEET - 240389621 ICE MAKER INFORMATION R134a Test Cycling h t i t i c F ° ° 8 F ° ° 2 ICE & WATER - AUTOMATIC DEFROST Press the momemtary contact on the ON/OFF switch for n i t SIDE BY SIDE MODELS approximately 15 seconds.
Page 41
23 CUBIC FOOT 26 CUBIC FOOT SERVICE PARTS STANDARD E-STAR STANDARD E-STAR Compressor Kit * 5303918303 5303918299 5303918303 5303918298 Starter/PTC/TSD * 241524604 241527802 241524604 241527801 Run Capacitor * 218909913 218909915 218909913 218909915 Temp. Control-Refr 241507701 241507701 241507701 241507701 Temp. Control-Frzr 450226-07 450226-07 450226-07...
Page 42
SERVICE DATA SHEET - 240389622 ICE MAKER INFORMATION R134a LEFT SIDE MOUNTED h t i t i c F ° ° 8 F ° ° 2 ICE & WATER - AUTOMATIC DEFROST Test Cycling n i t SIDE BY SIDE MODELS Remove cover by inserting screwdriver in notch at bottom °...
Page 44
SERVICE DATA SHEET - 240389623 ICE MAKER INFORMATION R134a Test Cycling h t i t i c F ° ° 8 F ° ° 2 ICE & WATER - AUTOMATIC DEFROST Press the momemtary contact on the ON/OFF switch for n i t SIDE BY SIDE MODELS approximately 15 seconds.
Page 46
SERVICE DATA SHEET - 240389624 ICE MAKER INFORMATION R134a LEFT SIDE MOUNTED h t i t i c F ° ° 8 F ° ° 2 ICE & WATER - AUTOMATIC DEFROST Test Cycling n i t SIDE BY SIDE MODELS Remove cover by inserting screwdriver in notch at bottom °...
Page 48
SERVICE DATA SHEET ICE MAKER INFORMATION Test Cycling 241532603 ICE & WATER - AUTOMATIC DEFROST Press the momemtary contact on the ON/OFF switch for approximately 15 seconds. Ice maker will continue to PERFORMANCE DATA COUNTER DEPTH SIDE BY SIDE - R134a NO LOAD AND NO DOOR OPENINGS AT MID-POINT CONTROL SETTING complete the cycle.
Page 49
115 VAC 2 TO 5 VDC VARIABLE SPEED COMPRESSOR Variable Speed Compressor FOR E-STAR and E-Star only 23 CUBIC FOOT SERVICE PARTS STANDARD 1 E-STAR 2 Compressor Kit * 5303918298 241547601 Power Board (Sigma Main) 241511102 Inverter 241577501 Starter/PTC 241527801 Run Capacitor 218909915 Sensor, Temperature...
Page 50
SERVICE DATA SHEET ICE MAKER INFORMATION STANDARD - AUTOMATIC ° 5 ° 8 ° 0 ° 2 Test Cycling P/N: 241588200 DEFROST TOP FREEZER MODELS (R134a) Remove cover by inserting screwdriver in notch at bottom and prying ° 2 ° 8 °...
Page 52
SERVICE DATA SHEET ICE MAKER INFORMATION STANDARD - AUTOMATIC ° 5 ° 8 ° 0 ° 2 Test Cycling P/N: 241588201 DEFROST TOP FREEZER MODELS (R134a) Remove cover by inserting screwdriver in notch at bottom and prying ° 2 ° 8 °...
Page 53
Ladder Schematic - TM Dynamic With Optional Water Through The Door Or Mid-level Lighting COMPRESSOR WIRING Induction Run Compressor with Relay...
Page 54
SERVICE DATA SHEET - 241636600 ICE MAKER INFORMATION R134a Test Cycling h t i t i c F ° ° 8 F ° ° 2 ICE & WATER - AUTOMATIC DEFROST Press the momemtary contact on the ON/OFF switch for n i t SIDE BY SIDE MODELS approximately 15 seconds.
Page 56
SERVICE DATA SHEET - 241636601 ICE MAKER INFORMATION R134a Test Cycling h t i t i c F ° ° 8 F ° ° 2 ICE & WATER - AUTOMATIC DEFROST Press the momemtary contact on the ON/OFF switch for n i t SIDE BY SIDE MODELS approximately 15 seconds.
Page 58
SERVICE DATA SHEET ICE MAKER INFORMATION Test Cycling 241639000 ICE & WATER - AUTOMATIC DEFROST Press the momemtary contact on the ON/OFF switch for approximately 15 seconds. Ice maker will continue to PERFORMANCE DATA COUNTER DEPTH SIDE BY SIDE - R134a NO LOAD AND NO DOOR OPENINGS AT MID-POINT CONTROL SETTING complete the cycle.
Page 60
SERVICE DATA SHEET ICE MAKER INFORMATION STANDARD - AUTOMATIC ° 5 ° 8 ° 0 ° 2 Test Cycling P/N: 241643300 DEFROST TOP FREEZER MODELS (R134a) Remove cover by inserting screwdriver in notch at bottom and prying ° 2 ° 8 °...
Page 61
Pictorial Schematic Ladder Schematic NOTE: _ _ _ _ _ _ DENOTES NOT ON ALL MODELS COMPRESSOR WIRING Induction Run Compressor with Relay 15 & 17 CUBIC FOOT 18 CUBIC FOOT 21 CUBIC FOOT SERVICE PARTS STATIC DYNAMIC E-STAR STATIC DYNAMIC E-STAR DYNAMIC...
Page 62
SERVICE DATA SHEET ICE MAKER INFORMATION STANDARD - AUTOMATIC ° 5 ° 8 ° 0 ° 2 Test Cycling P/N: 241643400 DEFROST TOP FREEZER MODELS (R134a) Remove cover by inserting screwdriver in notch at bottom and prying ° 2 ° 8 °...
Page 63
COMPRESSOR WIRING 15 & 17 CUBIC FO OT 18 CUBI C FOO T 21 CUBIC F OOT Induction Run Compressor with Relay S ERV ICE P ART S S TAT IC DYNAM I C E-ST AR S T ATIC DYNAM IC E-S TAR DYNAM IC E-S TAR...
Page 64
The Electrolux Group. The world’s No. 1 choice. The Electrolux Group is the world’s largest producer of powered appliances for kitchen, cleaning and outdoor use combined. More than 55 million Electrolux Group products (such as refrigerators, cookers, washing machines, vacuum cleaners, chain saws and lawn mowers) are sold each year to a value of approximately USD 14 billion in more than 150 countries around the world.