Every 1000 Hours Of Operation - Yanmar 3TNV82A Service Manual

Periodic Maintenance Procedures

Every 1000 Hours of Operation

Perform the following maintenance every 1000
hours of operation.
• Drain, Flush and Refill Cooling System With
New Coolant
• Adjust Intake / Exhaust Valve Clearance
Drain, Flush and Refill Cooling System With
New Coolant
A
DANGER
SCALD HAZARD!
• NEVER remove the radiator cap if the
engine is hot. Steam and hot engine
coolant will spurt out and seriously
burn you. Allow the engine to cool
down before you attempt to remove
the radiator cap.
• Tighten the radiator cap securely after
you check the radiator. Steam can
spurt out during engine operation if
the cap is loose.
• ALWAYS check the level of the engine
coolant by observing the reserve tank.
• Failure to comply will result in death or
serious injury.
TNV DI Service Manual
• Wait until the engine cools before you
drain the engine coolant. Hot engine
coolant may splash and burn you.
• Failure to comply could result in death
or serious injury.
• Wear eye protection and rubber gloves
when you handle long life or extended
life engine coolant. If contact with the
eyes or skin should occur, flush eyes
and wash immediately with clean
water.
• Failure to comply may result in minor
or moderate injury.
0000002en
PERIODIC MAINTENANCE
A
WARNING
BURN HAZARD!
A
CAUTION
COOLANT HAZARD!
0000016en
0000005en
5-35