Periodic Lubrication Schedule - Club Car TURF 1 2001 Owner's Manual

PERIODIC SERVICE SCHEDULE
REGULAR INTERVAL
Semiannual Service by
Trained Technician Only
(Every 50 hours of
operation).
Annual Service by
Trained Technician Only
(Every 100 hours of
operation).
Two year Service by
Trained Technician Only
(Every 200 hours of
operation).
WARNING
• IF ANY PROBLEMS ARE FOUND, DO NOT OPERATE THE VEHICLE UNTIL REPAIRS ARE
MADE. FAILURE TO MAKE NECESSARY REPAIRS COULD RESULT IN FIRE, PROPERTY
DAMAGE, SEVERE PERSONAL INJURY, OR DEATH.

PERIODIC LUBRICATION SCHEDULE

PERIODIC LUBRICATION SCHEDULE
REGULAR INTERVAL
Semiannually by Owner
or Trained Technician
(Every 50 hours of
operation).
Periodic Lubrication Schedule continued on next page...
SERVICE
Battery
Front Wheel Alignment and Camber
Electrical wiring and connections
Brake System
Engine
Engine Air Intake System
General Vehicle
Fuel Filters
SERVICE
Brake Pedal shaft bearings
Brake Linkage and Pivots
Accelerator push rod pivots, mounts,
and shifter cable pivots
Clean terminals and wash dirt from casing; check
electrolyte level. See page 32.
Check and adjust as required.
See Maintenance & Service Manual.
Check for tightness and damage.
Check brake shoes; replace if necessary. See Mainte-
nance and Service Manual.
Lubricate brake slides per Lubrication Schedule. See
Maintenance and Service Manual.
Check brake cables for damage; replace as required.
Check for leaks around gaskets, fill plugs, etc.
Inspect, clean and regap spark plug; replace if necessary.
Check air filter element; clean or replace if necessary.
Dispose of used filter element properly.
Check clamps for tightness; check hose for cracks.
Check for loose hardware and tighten as required.
Replace. Dispose of used filters properly.
*
RECOMMENDED LUBRICANT
PLACE
1. Dry Moly Lube – Club Car Part No. 1012151
2. Dry Moly Lube – Club Car Part No. 1012151
3. Dry Moly Lube – Club Car Part No. 1012151
2001 Turf Utility Gasoline Vehicle Owner's Manual
Periodic Lubrication Schedule
29