Page 1
3 7 63 1515 0 SERVICE MANUAL CD/CASSETTE RECEIVER MA099 2004 KW-XC88 Area suffix UN --------------------------Asean CD / CH KW-XC88 CD/CASSETTE RECEIVER L 13942296513 FM / AM DISP 45Wx4 TAPE / AUX PROG TAPE MODE TABLE OF CONTENTS PRECAUTIONS ............... 1-3 SPECIFIC SERVICE INSTRUCTIONS .
Page 2
http://www.xiaoyu163.com 3 7 63 1515 0 SPECIFICATION AUDIO AMPLIFIER SECTION Maximum Power Output Front 45 W per channel Rear 45 W per channel Ω Continuous Power Output Front 17 W per channel into 4 , 40 Hz to 20 000 Hz at no more than 0.8% total har- (RMS) monic distortion.
Page 3
http://www.xiaoyu163.com SECTION 1 3 7 63 1515 0 PRECAUTIONS Safety Precautions Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system. Please use enough caution not to see the beam directly or touch it in case of an adjustment or operation check.
Page 4
http://www.xiaoyu163.com Preventing static electricity 3 7 63 1515 0 Electrostatic discharge (ESD), which occurs when static electricity stored in the body, fabric, etc. is discharged, can destroy the laser diode in the traverse unit (optical pickup). Take care to prevent this when performing repairs. 1.2.1 Grounding to prevent damage by static electricity Static electricity in the work area can destroy the optical pickup (laser diode) in devices such as CD players.
Page 5
http://www.xiaoyu163.com Important for laser products 3 7 63 1515 0 5.CAUTION : If safety switches malfunction, the laser is able 1.CLASS 1 LASER PRODUCT to function. 2.DANGER : Invisible laser radiation when open and inter 6.CAUTION : Use of controls, adjustments or performance of lock failed or defeated.
Page 6
http://www.xiaoyu163.com SECTION 2 3 7 63 1515 0 SPECIFIC SERVICE INSTRUCTIONS This service manual does not describe SPECIFIC SERVICE INSTRUCTIONS. L 13942296513 u163 1-6 (No.MA099) http://www.xiaoyu163.com...
Page 7
http://www.xiaoyu163.com SECTION 3 3 7 63 1515 0 DISASSEMBLY Main body 3.1.1 Removing the front panel assembly (See Fig.1, 2) (1) From the both side of the main body, remove the four Front panel assembly screws A attaching the front panel assembly. (See Figs.1, (2) Release the four joints a using a screwdriver, then remove Joints a the front panel assembly toward the front.
http://www.xiaoyu163.com 3.1.4 Removing the top chassis assembly and bottom chassis assembly 3 7 63 1515 0 (See Fig.5 to 7) • Prior to performing the following procedures, remove the front CN702 panel assembly, rear bracket and heat sink. (1) From the back side of the main body, disconnect the card wire from the connector CN702 on the main board in the...
http://www.xiaoyu163.com 3.1.6 Removing the CD mechanism assembly 3 7 63 1515 0 (See Fig.9) • Prior to performing the following procedures, remove the front CD mechanism assembly panel assembly, rear bracket, heat sink, top chassis assembly, main board and CD mecha control board. (1) Remove the three screws J attaching the CD mechanism assembly to the top chassis assembly.
Page 10
http://www.xiaoyu163.com 3.1.8 Removing the mecha control board 3 7 63 1515 0 (See Fig.12) • Prior to performing the following procedures, remove the front CJ402 CN403 Joints g panel assembly, rear bracket, heat sink, bottom chassis as- sembly and changer control board. (1) From the back side of the bottom chassis assembly, re- move the screw L attaching the mecha control board, and release the joints g from the bottom chassis assembly.
Page 11
http://www.xiaoyu163.com 3.1.11 Removing the switch board 3 7 63 1515 0 (See Fig.15) • Prior to performing the following procedures, remove the front Solder points j Front panel assembly panel assembly. (1) From the back side of front panel assembly, remove the five screws P attaching the switch board.
Page 12
http://www.xiaoyu163.com CD mechanism section 3 7 63 1515 0 3.2.1 Removing the CD mechanism control board (See Fig.1 and 2) (1) Unsolder the part a and b on the CD mechanism control Damper bracket CD mechanism assembly board. (2) Remove the stator fixing the CD mechanism control board and the damper bracket (To remove the stator smoothly, pick up the center part).
http://www.xiaoyu163.com 3.2.2 Removing the loading motor 3 7 63 1515 0 (See Fig.3 to 5) • Rrior to performing the following procedure, remove the CD CD mechanism control board mechanism control board. (1) Remove the two springs f attaching the CD mechanism as- sembly and the front bracket.
http://www.xiaoyu163.com 3.2.3 Removing the CD mechanism assembly 3 7 63 1515 0 (See Fig.1, 6 to 9) • Prior to performing the following procedure, remove the CD assembly CD mechanism mechanism control board and the front bracket (loading mo- Damper bracket tor).
Page 15
http://www.xiaoyu163.com 3.2.4 Removing the feed motor assembly 3 7 63 1515 0 (See Fig.10) • Prior to performing the following procedure, remove the CD FD screw Part i mechanism control board, the front bracket (loading motor) Feed motor assembly and the CD mechanism assembly. (1) Remove the two screws F and the feed motor assembly.
Page 16
http://www.xiaoyu163.com Cassette mechanism assembly 3 7 63 1515 0 REFERENCE: Prior to performing the following procedures, turn the mode gear on the bottom of the body until the respective part comes to the EJECT position (Refer to Fig.1). Mode gear Fig.1 3.3.1 Removing the cassette guide (See Fig.2)
Page 17
http://www.xiaoyu163.com 3.3.3 Removing the cassette hanger assembly / cassette holder 3 7 63 1515 0 (See Fig.4 to 7) (1) Check the mode is set to EJECT. Push down the front part Cassette holder assembly of the cassette holder and move in the direction of the ar- row to release the joint c.
Page 18
http://www.xiaoyu163.com 3.3.4 Removing the side bracket assembly 3 7 63 1515 0 Side bracket assembly (See Fig.8 to 10) Joint i (1) Remove the screw A attaching the side bracket assembly. (2) Detach the front side of the side bracket assembly upward and pull out forward to release the joint i and j in the rear.
Page 19
http://www.xiaoyu163.com 3.3.5 Removing the pinch arm (F) assembly 3 7 63 1515 0 (See Fig.11 and 12) (1) Remove the polywasher and pull out the pinch arm (F) as- sembly. (2) Remove the compulsion spring. 3.3.6 Removing the pinch arm (R) assembly (See Fig.11 and 12) (1) Remove the polywasher and pull out the pinch arm (R) as- sembly.
Page 20
http://www.xiaoyu163.com 3.3.8 Removing the head / tape guide 3 7 63 1515 0 Flywheel assembly (F) Belt (See Fig.16 and 17) REFERENCE: It is not necessary to remove the slide chassis assembly. (1) Remove the band attaching the wire to the head. (2) Remove the two screws B, the head and the head support spring.
Page 21
http://www.xiaoyu163.com 3.3.10 Disassembling the flywheel assembly (F) 3 7 63 1515 0 FFC pad (See Fig.19 and 20) (1) Push and turn counterclockwise the spring holder (F) to re- lease the three joints p on the bottom of the flywheel. (2) The spring holder (F), the TU spring and the friction gear play come off.
Page 22
http://www.xiaoyu163.com 3.3.13 Removing the gear base arm / gear base link assembly 3 7 63 1515 0 (See Fig.23 to 25) (1) Move the gear base arm in the direction of the arrow. Gear base arm (2) Insert a slotted screwdriver to the gear base spring under Joint t Joints s the gear base arm, and release the gear base arm upward...
Page 23
http://www.xiaoyu163.com 3.3.15 Removing the mode gear 3 7 63 1515 0 Mode gear Mode switch actuator (See Fig.26 and 29) (1) Remove the polywasher on the bottom and pull out the mode gear. 3.3.16 Removing the mode switch actuator (See Fig.26, 27 and 29) (1) Pull out the mode switch actuator at the bottom.
Page 24
http://www.xiaoyu163.com 3.3.19 Removing the gear base assembly / take up gear / reflector gear 3 7 63 1515 0 (See Fig.30 to 32) (1) Push in the pin d’ of the gear base assembly on the upper Slot e' side of the body and move the reflector gear toward the bottom, then pull out.
Page 25
http://www.xiaoyu163.com 3.3.21 Removing the side bracket assembly 3 7 63 1515 0 Side bracket assembly (See Fig.33 to 37) Boss g' (1) Remove the eject cam plate spring. (2) Push the joint f’ through the slot to remove the load rack downward.
Page 26
http://www.xiaoyu163.com 3.3.22 Removing the main motor assembly / sub motor assembly 3 7 63 1515 0 (See Fig.38 to 40) (1) Remove the belt at the bottom. Main motor (2) Remove the polywasher and pull out the mode gear. assembly (3) Pull out the reduction gear (B).
Page 27
• VT712 : For wow flutter & tape speed measurement • VT703 : For head azimuth measurement (6) Torque gauge : Cassette type for CTG-N (Mechanism adjustment) (7) Test disc (JVC : CTS1000) Standard volume position Balance and Bass, Treble volume, Fader : Center (Indication "0") Loudness, Dolby NR, Sound, Cruise : Off Volume position is about 2V at speaker output with following conditions, Playback the test tape VT721.
Page 28
http://www.xiaoyu163.com Information for using a car audio service jig 3 7 63 1515 0 (1) We're advancing efforts to make our extension cords common for all car audio products. Please use this type of extension cord as follows. (2) As a U-shape type top cover is employed, this type of extension cord is needed to check operation of the mechanism assembly after disassembly.
Page 29
Service mode 3 7 63 1515 0 1.Service mode setting operation Power off condition, then press button, CD / CH CD/CASSETTE RECEIVER KW-XC88 FM / AM DISP 45Wx4 button and button together more TAPE / AUX than 2sec. PROG 2.Service mode menu...
Page 30
http://www.xiaoyu163.com Arrangement of adjusting & test points 3 7 63 1515 0 Cassette mechanism (Surface) Motor assembly Tape speed adjust Azimuth screw A (Forward) Playback head Azimuth screw B (Reverse) L 13942296513 Head section view Playback head Azimuth screw B Azimuth screw A (Reverse) (Forward)
Page 31
http://www.xiaoyu163.com 3 7 63 1515 0 Item Conditions Adjustment and Confirmation methods S.Values Adjust Head Head height adjustment Test tape: azimuth Adjust the azimuth directly. When you SCC-1659 adjustment adjust the height using a mirror tape, VT703 (10kHz) remove the cassette housing from the mechanism chassis.
http://www.xiaoyu163.com SECTION 5 3 7 63 1515 0 TROUBLESHOOTING Flow of functional operation unit TOC read Power ON Set Function CD When the laser diode correctly When the pickup correctly moves emits to the inner area of the disc Microprocessor $82 $81 Microprocessor Disc inserted...
Page 33
http://www.xiaoyu163.com Feed section 3 7 63 1515 0 Is the voltage output at Is the wiring for IC621 Is 3.3V present at IC621 IC621 pin "40" 5V or 0V? (56)~(64) correct? pin "6"? Check CD 8V Check the vicinity of and 5V.
Page 34
http://www.xiaoyu163.com Maintenance of laser pickup 3 7 63 1515 0 Replacement of laser pickup (1) Cleaning the pick up lens Before you replace the pick up, please try to clean the lens Turn of the power switch and, disconnect the with a alcohol soaked cotton swab.
Page 35
http://www.xiaoyu163.com 16 PIN CORD DIAGRAM 3 7 63 1515 0 Black Green OR/WH Violet BL/WH Gray Blue WH White Yellow WH/BK Orange GN/BK VI/BK GY/BK MEMORY 16 YL 8 BK 7 RD 15 OR/WH 3 GN 11 GN/BK L 13942296513 2 VI 10 VI/BK 4 WH...
Page 36
http://www.xiaoyu163.com 3 7 63 1515 0 L 13942296513 u163 Victor Company of Japan, Limited AV & MULTIMEDIA COMPANY CAR ELECTRONICS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan (No.MA099) Printed in Japan http://www.xiaoyu163.com...
3 7 63 1515 0 SERVICE MANUAL CD/CASSETTE RECEIVER MA099B 2005 KW-XC88 Area suffix UN --------------------- Indonesia L 13942296513 Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade) TABLE OF CONTENTS PRECAUTIONS ............... 1-3 SPECIFIC SERVICE INSTRUCTIONS .
Page 38
http://www.xiaoyu163.com 3 7 63 1515 0 SPECIFICATION AUDIO AMPLIFIER SECTION Maximum Power Output Front 45 W per channel Rear 45 W per channel Ω Continuous Power Output Front 17 W per channel into 4 , 40 Hz to 20 000 Hz at no more than 0.8% total har- (RMS) monic distortion.
http://www.xiaoyu163.com SECTION 1 3 7 63 1515 0 PRECAUTIONS Safety Precautions Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system. Please use enough caution not to see the beam directly or touch it in case of an adjustment or operation check.
Page 40
http://www.xiaoyu163.com Preventing static electricity 3 7 63 1515 0 Electrostatic discharge (ESD), which occurs when static electricity stored in the body, fabric, etc. is discharged, can destroy the laser diode in the traverse unit (optical pickup). Take care to prevent this when performing repairs. 1.2.1 Grounding to prevent damage by static electricity Static electricity in the work area can destroy the optical pickup (laser diode) in devices such as CD players.
Page 41
http://www.xiaoyu163.com Important for laser products 3 7 63 1515 0 5.CAUTION : If safety switches malfunction, the laser is able 1.CLASS 1 LASER PRODUCT to function. 2.DANGER : Invisible laser radiation when open and inter 6.CAUTION : Use of controls, adjustments or performance of lock failed or defeated.
http://www.xiaoyu163.com SECTION 2 3 7 63 1515 0 SPECIFIC SERVICE INSTRUCTIONS HOW TO IDENTIFY MODELS 2.1.1 NAME PLATE Discernment sign L 13942296513 u163 1-6 (No.MA099B) http://www.xiaoyu163.com...
http://www.xiaoyu163.com SECTION 3 3 7 63 1515 0 DISASSEMBLY Main body 3.1.1 Removing the front panel assembly (See Fig.1, 2) (1) From the both side of the main body, remove the four Front panel assembly screws A attaching the front panel assembly. (See Figs.1, (2) Release the four joints a using a screwdriver, then remove Joints a the front panel assembly toward the front.
Page 44
http://www.xiaoyu163.com 3.1.4 Removing the top chassis assembly and bottom chassis assembly 3 7 63 1515 0 (See Fig.5 to 7) • Prior to performing the following procedures, remove the front CN702 panel assembly, rear bracket and heat sink. (1) From the back side of the main body, disconnect the card wire from the connector CN702 on the main board in the...
Page 45
http://www.xiaoyu163.com 3.1.6 Removing the CD mechanism assembly 3 7 63 1515 0 (See Fig.9) • Prior to performing the following procedures, remove the front CD mechanism assembly panel assembly, rear bracket, heat sink, top chassis assembly, main board and CD mecha control board. (1) Remove the three screws J attaching the CD mechanism assembly to the top chassis assembly.
Page 46
http://www.xiaoyu163.com 3.1.8 Removing the mecha control board 3 7 63 1515 0 (See Fig.12) • Prior to performing the following procedures, remove the front CJ402 CN403 Joints g panel assembly, rear bracket, heat sink, bottom chassis as- sembly and changer control board. (1) From the back side of the bottom chassis assembly, re- move the screw L attaching the mecha control board, and release the joints g from the bottom chassis assembly.
Page 47
http://www.xiaoyu163.com 3.1.11 Removing the switch board 3 7 63 1515 0 (See Fig.15) • Prior to performing the following procedures, remove the front Solder points j Front panel assembly panel assembly. (1) From the back side of front panel assembly, remove the five screws P attaching the switch board.
Page 48
http://www.xiaoyu163.com CD mechanism section 3 7 63 1515 0 3.2.1 Removing the CD mechanism control board (See Fig.1 and 2) (1) Unsolder the part a and b on the CD mechanism control Damper bracket CD mechanism assembly board. (2) Remove the stator fixing the CD mechanism control board and the damper bracket (To remove the stator smoothly, pick up the center part).
Page 49
http://www.xiaoyu163.com 3.2.2 Removing the loading motor 3 7 63 1515 0 (See Fig.3 to 5) • Rrior to performing the following procedure, remove the CD CD mechanism control board mechanism control board. (1) Remove the two springs f attaching the CD mechanism as- sembly and the front bracket.
Page 50
http://www.xiaoyu163.com 3.2.3 Removing the CD mechanism assembly 3 7 63 1515 0 (See Fig.1, 6 to 9) • Prior to performing the following procedure, remove the CD assembly CD mechanism mechanism control board and the front bracket (loading mo- Damper bracket tor).
Page 51
http://www.xiaoyu163.com 3.2.4 Removing the feed motor assembly 3 7 63 1515 0 (See Fig.10) • Prior to performing the following procedure, remove the CD FD screw Part i mechanism control board, the front bracket (loading motor) Feed motor assembly and the CD mechanism assembly. (1) Remove the two screws F and the feed motor assembly.
Page 52
http://www.xiaoyu163.com Cassette mechanism assembly 3 7 63 1515 0 REFERENCE: Prior to performing the following procedures, turn the mode gear on the bottom of the body until the respective part comes to the EJECT position (Refer to Fig.1). Mode gear Fig.1 3.3.1 Removing the cassette guide (See Fig.2)
Page 53
http://www.xiaoyu163.com 3.3.3 Removing the cassette hanger assembly / cassette holder 3 7 63 1515 0 (See Fig.4 to 7) (1) Check the mode is set to EJECT. Push down the front part Cassette holder assembly of the cassette holder and move in the direction of the ar- row to release the joint c.
Page 54
http://www.xiaoyu163.com 3.3.4 Removing the side bracket assembly 3 7 63 1515 0 Side bracket assembly (See Fig.8 to 10) Joint i (1) Remove the screw A attaching the side bracket assembly. (2) Detach the front side of the side bracket assembly upward and pull out forward to release the joint i and j in the rear.
Page 55
http://www.xiaoyu163.com 3.3.5 Removing the pinch arm (F) assembly 3 7 63 1515 0 (See Fig.11 and 12) (1) Remove the polywasher and pull out the pinch arm (F) as- sembly. (2) Remove the compulsion spring. 3.3.6 Removing the pinch arm (R) assembly (See Fig.11 and 12) (1) Remove the polywasher and pull out the pinch arm (R) as- sembly.
Page 56
http://www.xiaoyu163.com 3.3.8 Removing the head / tape guide 3 7 63 1515 0 Flywheel assembly (F) Belt (See Fig.16 and 17) REFERENCE: It is not necessary to remove the slide chassis assembly. (1) Remove the band attaching the wire to the head. (2) Remove the two screws B, the head and the head support spring.
Page 57
http://www.xiaoyu163.com 3.3.10 Disassembling the flywheel assembly (F) 3 7 63 1515 0 FFC pad (See Fig.19 and 20) (1) Push and turn counterclockwise the spring holder (F) to re- lease the three joints p on the bottom of the flywheel. (2) The spring holder (F), the TU spring and the friction gear play come off.
Page 58
http://www.xiaoyu163.com 3.3.13 Removing the gear base arm / gear base link assembly 3 7 63 1515 0 (See Fig.23 to 25) (1) Move the gear base arm in the direction of the arrow. Gear base arm (2) Insert a slotted screwdriver to the gear base spring under Joint t Joints s the gear base arm, and release the gear base arm upward...
Page 59
http://www.xiaoyu163.com 3.3.15 Removing the mode gear 3 7 63 1515 0 Mode gear Mode switch actuator (See Fig.26 and 29) (1) Remove the polywasher on the bottom and pull out the mode gear. 3.3.16 Removing the mode switch actuator (See Fig.26, 27 and 29) (1) Pull out the mode switch actuator at the bottom.
Page 60
http://www.xiaoyu163.com 3.3.19 Removing the gear base assembly / take up gear / reflector gear 3 7 63 1515 0 (See Fig.30 to 32) (1) Push in the pin d’ of the gear base assembly on the upper Slot e' side of the body and move the reflector gear toward the bottom, then pull out.
Page 61
http://www.xiaoyu163.com 3.3.21 Removing the side bracket assembly 3 7 63 1515 0 Side bracket assembly (See Fig.33 to 37) Boss g' (1) Remove the eject cam plate spring. (2) Push the joint f’ through the slot to remove the load rack downward.
Page 62
http://www.xiaoyu163.com 3.3.22 Removing the main motor assembly / sub motor assembly 3 7 63 1515 0 (See Fig.38 to 40) (1) Remove the belt at the bottom. Main motor (2) Remove the polywasher and pull out the mode gear. assembly (3) Pull out the reduction gear (B).
• VT712 : For wow flutter & tape speed measurement • VT703 : For head azimuth measurement (6) Torque gauge : Cassette type for CTG-N (Mechanism adjustment) (7) Test disc (JVC : CTS1000) Standard volume position Balance and Bass, Treble volume, Fader : Center (Indication "0") Loudness, Dolby NR, Sound, Cruise : Off Volume position is about 2V at speaker output with following conditions, Playback the test tape VT721.
Page 64
http://www.xiaoyu163.com Information for using a car audio service jig 3 7 63 1515 0 (1) We're advancing efforts to make our extension cords common for all car audio products. Please use this type of extension cord as follows. (2) As a U-shape type top cover is employed, this type of extension cord is needed to check operation of the mechanism assembly after disassembly.
Page 65
Service mode 3 7 63 1515 0 1.Service mode setting operation Power off condition, then press button, CD / CH CD/CASSETTE RECEIVER KW-XC88 FM / AM DISP 45Wx4 button and button together more TAPE / AUX than 2sec. PROG 2.Service mode menu...
Page 66
http://www.xiaoyu163.com Arrangement of adjusting & test points 3 7 63 1515 0 Cassette mechanism (Surface) Motor assembly Tape speed adjust Azimuth screw A (Forward) Playback head Azimuth screw B (Reverse) L 13942296513 Head section view Playback head Azimuth screw B Azimuth screw A (Reverse) (Forward)
Page 67
http://www.xiaoyu163.com 3 7 63 1515 0 Item Conditions Adjustment and Confirmation methods S.Values Adjust Head Head height adjustment Test tape: azimuth Adjust the azimuth directly. When you SCC-1659 adjustment adjust the height using a mirror tape, VT703 (10kHz) remove the cassette housing from the mechanism chassis.
http://www.xiaoyu163.com SECTION 5 3 7 63 1515 0 TROUBLESHOOTING Flow of functional operation unit TOC read Power ON Set Function CD When the laser diode correctly When the pickup correctly moves emits to the inner area of the disc Microprocessor $82 $81 Microprocessor Disc inserted...
Page 69
http://www.xiaoyu163.com Feed section 3 7 63 1515 0 Is the voltage output at Is the wiring for IC621 Is 3.3V present at IC621 IC621 pin "40" 5V or 0V? (56)~(64) correct? pin "6"? Check CD 8V Check the vicinity of and 5V.
Page 70
http://www.xiaoyu163.com Maintenance of laser pickup 3 7 63 1515 0 Replacement of laser pickup (1) Cleaning the pick up lens Before you replace the pick up, please try to clean the lens Turn of the power switch and, disconnect the with a alcohol soaked cotton swab.
Page 71
http://www.xiaoyu163.com 16 PIN CORD DIAGRAM 3 7 63 1515 0 Black Green Violet OR/WH Gray Blue BL/WH White Yellow Orange WH/BK GN/BK VI/BK GY/BK OR/WH GY/BK WH/BK L 13942296513 VI/BK GN/BK u163 (No.MA099B)1-35 http://www.xiaoyu163.com...
Page 72
http://www.xiaoyu163.com 3 7 63 1515 0 L 13942296513 u163 Victor Company of Japan, Limited AV & MULTIMEDIA COMPANY CAR ELECTRONICS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan (No.MA099B) Printed in Japan http://www.xiaoyu163.com...
Page 73
3 7 63 1515 0 SCHEMATIC DIAGRAMS CD/CASSETTE RECEIVER KW-XC88 CD-ROM No.SML200408 Area suffix UN --------------------------Asean L 13942296513 CD / CH KW-XC88 CD/CASSETTE RECEIVER FM / AM DISP 45Wx4 TAPE / AUX PROG C D C H A N G E R C O N T R O L DOLBY &...
Page 74
http://www.xiaoyu163.com 3 7 63 1515 0 Safety precaution Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system. Please use enough caution not to see the beam directly or touch it in case of an adjustment or operation check.
Page 75
Each block FRONT LCD DATA BUS_SO BUS_I/O COM1 to 8 BUS_SCK SEG1 to 75 IC501 LCD1 LCD DRIVER IC761 IC911 JVC BAS AUXL AUX IN AUXR Cassette mechanism control section CH-Lch BUS SI Changer MAIN CH-Rch BUS SO SUBMO+ control...
Page 81
http://www.xiaoyu163.com 3 7 63 1515 0 < M E M O > L 13942296513 u163 http://www.xiaoyu163.com...
Page 82
http://www.xiaoyu163.com 3 7 63 1515 0 L 13942296513 u163 Victor Company of Japan, Limited AV & MULTIMEDIA COMPANY CAR ELECTRONICS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan Printed in Japan (No.MA099SCH) http://www.xiaoyu163.com...
Page 83
3 7 63 1515 0 SCHEMATIC DIAGRAMS CD/CASSETTE RECEIVER KW-XC88 CD-ROM No.SML200505 Area suffix UN --------------------- Indonesia L 13942296513 Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade) Contents Block diagram (UN) Standard schematic diagrams (UN)
http://www.xiaoyu163.com 3 7 63 1515 0 Safety precaution Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system. Please use enough caution not to see the beam directly or touch it in case of an adjustment or operation check.
Each block FRONT LCD DATA BUS_SO BUS_I/O COM1 to 8 BUS_SCK SEG1 to 75 IC501 LCD1 LCD DRIVER IC761 IC911 JVC BAS AUXL AUX IN AUXR Cassette mechanism control section CH-Lch BUS SI Changer MAIN CH-Rch BUS SO SUBMO+ control...
Each block FRONT LCD DATA BUS_SO BUS_I/O COM1 to 8 BUS_SCK SEG1 to 75 IC501 LCD1 LCD DRIVER IC761 IC911 JVC BAS AUXL AUX IN AUXR Cassette mechanism control section CH-Lch BUS SI Changer MAIN CH-Rch BUS SO SUBMO+ control...
http://www.xiaoyu163.com 3 7 63 1515 0 < M E M O > L 13942296513 u163 http://www.xiaoyu163.com...
Page 98
http://www.xiaoyu163.com 3 7 63 1515 0 L 13942296513 u163 Victor Company of Japan, Limited AV & MULTIMEDIA COMPANY CAR ELECTRONICS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan Printed in Japan (No.MA099BSCH) http://www.xiaoyu163.com...
Page 99
3 7 63 1515 0 PARTS LIST [ KW-XC88 ] * All printed circuit boards and its assemblies are not available as service parts. Area suffix UN ---------------------------Asean L 13942296513 - Contents - 3- 2 Exploded view of general assembly and parts list (Block No.M1) 3- 5 CD mechanism assembly and parts list (Block No.MB)
Page 100
http://www.xiaoyu163.com 3 7 63 1515 0 Exploded view of general assembly and parts list Block No. LCD1 L 13942296513 LCD board Switch board u163 http://www.xiaoyu163.com...
Page 101
http://www.xiaoyu163.com 3 7 63 1515 0 Main board L 13942296513 Mecha control board Changer control board u163 http://www.xiaoyu163.com...
Page 102
http://www.xiaoyu163.com 3 7 63 1515 0 General Assembly Block No. [M][1][M][M] Symbol No. Part No. Part Name Description Local QUB220-09VLVL LUG WIRE QYSDST2004Z TAP SCREW M2 x 4mm LV40847-002A SPACER LV21157-001A MECHA BKT(CA) QYSDST2604Z TAP SCREW M2.6 x 4mm QYSDST2604Z TAP SCREW M2.6 x 4mm(x4)
Page 103
http://www.xiaoyu163.com 3 7 63 1515 0 CD mechanism assembly and parts list Block No. Grease TN-CCD1001Z-138S G-31SA G-31SA(Bottom side) RX-405 L 13942296513 106 29 u163 The parts without symbol number are not service. http://www.xiaoyu163.com...
Page 104
http://www.xiaoyu163.com 3 7 63 1515 0 CD mechanism Block No. [M][B][M][M] Symbol No. Part No. Part Name Description Local 30310101T FRAME 30310103T DANPER PIN (x2) 30310107T UPPER PL 30310108T SEL STOP PL 30310142T SEL ARM (L)L 30310143T SEL ARM (R)L 30310145T S ARM SPRING(L) (x2)
Page 105
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local 303105310T FEED MO ASSY 303105311T SPINDLE MO ASSY 303105312T FEED SCREW ASSY 303111301T LDG MOTOR ASSY 303111302T RDG RLR SFT ASY 303105502T T.T.BASE ASSY L 13942296513 u163 http://www.xiaoyu163.com...
Page 106
http://www.xiaoyu163.com 3 7 63 1515 0 Cassette mechanism assembly and parts list Block No. CDS-802JE3 L 13942296513 u163 The parts without symbol number are not service. http://www.xiaoyu163.com...
Page 107
http://www.xiaoyu163.com 3 7 63 1515 0 Cassette mechanism Block No. [M][P][M][M] Symbol No. Part No. Part Name Description Local X-0802-1009S MAIN CHASSIS AS X-0802-1002S SLIDE CHASSIS A X-0802-1003S SIDE BKT ASSY X-0802-1004S CASSETTE HANGER X-0802-1005S PINCH ARM F ASS X-0802-1006S PINCH ARM R ASS X-0802-1007S...
Page 108
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local 2-1031-7030-C2S SCREW (x2) L 13942296513 u163 3-10 http://www.xiaoyu163.com...
http://www.xiaoyu163.com 3 7 63 1515 0 Electrical parts list Main board Symbol No. Part No. Part Name Description Local Block No. [0][1] NCB31HK-102X C CAPACITOR 1000pF 50V K Symbol No. Part No. Part Name Description Local NCB31HK-103X C CAPACITOR 0.01uF 50V K NCB31HK-103X C CAPACITOR...
Page 112
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local C613 NCB31HK-103X C CAPACITOR 0.01uF 50V K C943 NCB31HK-103X C CAPACITOR 0.01uF 50V K C614 NDC31HJ-5R0X C CAPACITOR 5pF 50V J C944...
Page 113
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R182 NRSA63J-102X MG RESISTOR 1kΩ 1/16W J R676 NRSA63J-333X MG RESISTOR 33kΩ 1/16W J R191 NRSA63J-472X MG RESISTOR 4.7kΩ...
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R907 NRSA63J-473X MG RESISTOR 47kΩ 1/16W J D529 SML-310DT/KL/-X R908 NRSA63J-0R0X MG RESISTOR 0Ω 1/16W J D530 SML-310DT/KL/-X R911...
Page 115
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R551 NRSA63J-621X MG RESISTOR 620Ω 1/16W J IC461 HD74HC126FP-X R552 NRSA63J-621X MG RESISTOR 620Ω 1/16W J R553 NRSA63J-821X MG RESISTOR...
Page 116
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local R446 NRSA63J-473X MG RESISTOR 47kΩ 1/16W J R447 NRSA63J-473X MG RESISTOR 47kΩ 1/16W J R449 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J R450 NRSA63J-473X MG RESISTOR 47kΩ...
Page 118
http://www.xiaoyu163.com 3 7 63 1515 0 Packing materials and accessories parts list Block No. A1, A2 L 13942296513 u163 3-20 http://www.xiaoyu163.com...
Page 119
http://www.xiaoyu163.com 3 7 63 1515 0 Packing and Accessories Block No. [M][3][M][M] Symbol No. Part No. Part Name Description Local LVT1250-001A INST BOOK ENG INA VJC3300-001SS BLIND PLATE QYSDSP5008Z SCREW M5 x 8mm(x6) QAM0397-003 CAR CABLE RM-RK31 REMOCON UNIT ------------ BATTERY LV33876-001A...
Page 120
3 7 63 1515 0 PARTS LIST [ KW-XC88 ] * All printed circuit boards and its assemblies are not available as service parts. Area suffix UN ---------------------- Indonesia L 13942296513 - Contents - Exploded view of general assembly and parts list (Block No.M1) (KW-XC88_UN) Exploded view of general assembly and parts list (Block No.M2)
Page 121
http://www.xiaoyu163.com 3 7 63 1515 0 Exploded view of general assembly and parts list Block No. (KW-XC88_UN) LCD1 L 13942296513 LCD board Switch board u163 http://www.xiaoyu163.com...
Page 122
http://www.xiaoyu163.com 3 7 63 1515 0 Main board Mecha control board L 13942296513 Changer control board u163 http://www.xiaoyu163.com...
Page 123
http://www.xiaoyu163.com 3 7 63 1515 0 General Assembly Block No. [M][1][M][M] Symbol No. Part No. Part Name Description Local QUB220-09VLVL LUG WIRE QYSDST2004Z TAP SCREW M2 x 4mm LV40847-002A SPACER LV21157-001A MECHA BKT(CA) QYSDST2604Z TAP SCREW M2.6 x 4mm QYSDST2604Z TAP SCREW M2.6 x 4mm(x4)
Page 124
http://www.xiaoyu163.com 3 7 63 1515 0 Exploded view of general assembly and parts list Block No. (KW-XC88_UN2) LCD1 L 13942296513 LCD board Switch board u163 http://www.xiaoyu163.com...
Page 125
http://www.xiaoyu163.com 3 7 63 1515 0 ck No. 11 13 Main board L 13942296513 Mecha control board Changer control board u163 http://www.xiaoyu163.com...
Page 126
http://www.xiaoyu163.com 3 7 63 1515 0 General Assembly Block No. [M][2][M][M] Symbol No. Part No. Part Name Description Local LV10611-005A TOP CHASSIS LV10612-004A BOTTOM CHASSIS LV33135-001A HEAT SINK LV21156-002A REAR BRACKET QYSDST2604ZA TAP SCREW M2.6 x 4mm(x3) QYSDST2604ZA TAP SCREW M2.6 x 4mm(x4) QYSDST2606ZA TAP SCREW...
Page 127
http://www.xiaoyu163.com 3 7 63 1515 0 CD mechanism assembly and parts list Block No. Grease TN-CCD1001Z-138S G-31SA G-31SA(Bottom side) RX-405 L 13942296513 u163 106 29 The parts without symbol number are not service. http://www.xiaoyu163.com...
Page 128
http://www.xiaoyu163.com 3 7 63 1515 0 CD mechanism Block No. [M][B][M][M] Symbol No. Part No. Part Name Description Local 30310101T FRAME 30310103T DANPER PIN (x2) 30310107T UPPER PL 30310108T SEL STOP PL 30310142T SEL ARM (L)L 30310143T SEL ARM (R)L 30310145T S ARM SPRING(L) (x2)
Page 129
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local 303105310T FEED MO ASSY 303105311T SPINDLE MO ASSY 303105312T FEED SCREW ASSY 303111301T LDG MOTOR ASSY 303111302T RDG RLR SFT ASY 303105502T T.T.BASE ASSY L 13942296513 u163 3-10 http://www.xiaoyu163.com...
Page 130
http://www.xiaoyu163.com 3 7 63 1515 0 Cassette mechanism assembly and parts list Block No. CDS-802JE3 L 13942296513 u163 The parts without symbol number are not service. 3-11 http://www.xiaoyu163.com...
Page 131
http://www.xiaoyu163.com 3 7 63 1515 0 Cassette mechanism Block No. [M][P][M][M] Symbol No. Part No. Part Name Description Local X-0802-1009S MAIN CHASSIS AS X-0802-1002S SLIDE CHASSIS A X-0802-1003S SIDE BKT ASSY X-0802-1004S CASSETTE HANGER X-0802-1005S PINCH ARM F ASS X-0802-1006S PINCH ARM R ASS X-0802-1007S...
Page 133
http://www.xiaoyu163.com 3 7 63 1515 0 Grease point 2/2 L 13942296513 u163 3-14 http://www.xiaoyu163.com...
Page 134
http://www.xiaoyu163.com 3 7 63 1515 0 Electrical parts list Main board (KW-XC88_UN) Symbol No. Part No. Part Name Description Local Block No. [0][1] NCB31HK-102X C CAPACITOR 1000pF 50V K Symbol No. Part No. Part Name Description Local NCB31HK-103X C CAPACITOR 0.01uF 50V K NCB31HK-103X...
Page 135
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local C613 NCB31HK-103X C CAPACITOR 0.01uF 50V K C943 NCB31HK-103X C CAPACITOR 0.01uF 50V K C614 NDC31HJ-5R0X C CAPACITOR 5pF 50V J C944...
Page 136
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R182 NRSA63J-102X MG RESISTOR 1k$ 1/16W J R676 NRSA63J-333X MG RESISTOR 33k$ 1/16W J R191 NRSA63J-472X MG RESISTOR 4.7k$ 1/16W J R691...
Page 137
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R907 NRSA63J-473X MG RESISTOR 47k$ 1/16W J D529 SML-310DT/KL/-X R908 NRSA63J-0R0X MG RESISTOR 0$ 1/16W J D530 SML-310DT/KL/-X R911...
Page 138
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R551 NRSA63J-621X MG RESISTOR 620$ 1/16W J IC461 HD74HC126FP-X R552 NRSA63J-621X MG RESISTOR 620$ 1/16W J R553 NRSA63J-821X MG RESISTOR...
Page 139
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R446 NRSA63J-473X MG RESISTOR 47k$ 1/16W J 1SS355-X SI DIODE R447 NRSA63J-473X MG RESISTOR 47k$ 1/16W J 1SS355-X SI DIODE R449...
Page 140
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local C203 NCS31HJ-331X C CAPACITOR 330pF 50V J C733 NCS31HJ-101X C CAPACITOR 100pF 50V J C204 NCS31HJ-331X C CAPACITOR 330pF 50V J C771...
Page 141
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local NRSA63J-103X MG RESISTOR 10k$ 1/16W J R617 NRSA63J-473X MG RESISTOR 47k$ 1/16W J NRSA63J-473X MG RESISTOR 47k$ 1/16W J R620 NRSA63J-101X...
Page 142
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R768 NRSA63J-331X MG RESISTOR 330$ 1/16W J X702 QAX0401-001 CRYSTAL 32.768KHz R769 NRSA63J-331X MG RESISTOR 330$ 1/16W J R770 NRSA63J-331X MG RESISTOR...
Page 143
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R521 NRSA63J-122X MG RESISTOR 1.2k$ 1/16W J S526 NSW0041-001X TACT SW R522 NRSA63J-122X MG RESISTOR 1.2k$ 1/16W J S527 NSW0041-001X TACT SW...
Page 144
http://www.xiaoyu163.com 3 7 63 1515 0 Symbol No. Part No. Part Name Description Local R412 NRSA63J-101X MG RESISTOR 100$ 1/16W J R413 NRSA63J-183X MG RESISTOR 18k$ 1/16W J R414 NRSA63J-392X MG RESISTOR 3.9k$ 1/16W J R415 NRSA63J-223X MG RESISTOR 22k$ 1/16W J R416 NRSA63J-155X...
Page 145
http://www.xiaoyu163.com 3 7 63 1515 0 Packing materials and accessories parts list Block No. (KW-XC88_UN) A1, A2 L 13942296513 u163 3-26 http://www.xiaoyu163.com...
Page 146
http://www.xiaoyu163.com 3 7 63 1515 0 Packing and Accessories Block No. [M][3][M][M] Symbol No. Part No. Part Name Description Local LVT1250-001A INST BOOK ENG INA VJC3300-001SS BLIND PLATE QYSDSP5008Z SCREW M5 x 8mm(x6) QAM0397-003 CAR CABLE RM-RK31 REMOCON UNIT ------------ BATTERY LV33876-001A...
Page 147
http://www.xiaoyu163.com 3 7 63 1515 0 Packing materials and accessories parts list Block No. (KW-XC88_UN2) A1,A2 L 13942296513 u163 3-28 http://www.xiaoyu163.com...
Page 148
http://www.xiaoyu163.com 3 7 63 1515 0 Packing and Accessories Block No. [M][4][M][M] Symbol No. Part No. Part Name Description Local LVT1250-001B INST BOOK ENG INA VJC3300-001SS BLIND PLATE QYSDSP5008ZA SCREW M5 x 8mm(x6) QAM0659-001 INTERFACE CABLE RM-RK31 REMOCON UNIT ------------ BATTERY LV33876-001A...
Need help?
Do you have a question about the KW-XC88 and is the answer not in the manual?
Questions and answers