Specifications; 12 Month Limited Warranty - AEM 30-4100 Installation Instructions Manual

Specifications

Gauge
Supply Current (nominal):
0-5V Analog Outputs:
Measuring Range:
Harness & Connector Temp Limit:
Sensor
Type:
Accuracy:
Exhaust Temp Limit:
Cable & Protector Sleeve Temp Limit:250C
Connector Temp Limit:
Initial Warm-up Time:
Weight:
Heater Current:
Mounting:
Nominal Service Life:
Notes
The sensor contains a ceramic module and should not be subject to mechanical or
thermal shock or it may be damaged. The sensor is not designed for operation on
leaded fuels, doing so will dramatically shorten sensor life. Long term running in the rich
region (Lambda < 0.95) will shorten sensor life. High exhaust temperatures (over 850C)
will shorten sensor life. Engine oil consumption at a rate greater than 1 quart per 1,000
miles will shorten sensor life. With the UEGO Sensor installed, do not run the engine
without power applied to the gauge.

12 MONTH LIMITED WARRANTY

Advanced Engine Management Inc. warrants to the consumer that all AEM High Performance products will be free
from defects in material and workmanship for a period of twelve (12) months from date of the original purchase.
Products that fail within this 12-month warranty period will be repaired or replaced at AEM's option, when
determined by AEM that the product failed due to defects in material or workmanship. This warranty is limited to
the repair or replacement of the AEM part. In no event shall this warranty exceed the original purchase price of the
AEM part nor shall AEM be responsible for special, incidental or consequential damages or cost incurred due to the
failure of this product. AEM does not warranty the UEGO sensor. Warranty claims to AEM must be transportation
prepaid and accompanied with dated proof of purchase. This warranty applies only to the original purchaser of
product and is non-transferable. All implied warranties shall be limited in duration to the said 12 month warranty
period. Improper use or installation, accident, abuse, unauthorized repairs or alterations voids this warranty. AEM
disclaims any liability for consequential damages due to breach of any written or implied warranty on all products
manufactured by AEM. Warranty returns will only be accepted by AEM when accompanied by a valid Return
Goods Authorization (RGA) number. Credit for defective products will be issued pending inspection. Product must
be received by AEM within 30 days of the date the RGA is issued.
AEM CUSTOM GAUGES
1.3 amps
1
0.751 to 1.143 Lambda
120C
Bosch UEGO LSU4.2
+/- 0.7%
1030C
120C
Less than 20 seconds
80 grams
1.2A at 12.0V (each sensor)
M18 X 1.5 thread, Torque to 30 ft-lbs
80,000 km for Unleaded Fuel
50,000 km for Leaded Fuel 0.15g Pb/l
20,000 km for Leaded Fuel 0.40g Pb/l
10,000 km for Leaded Fuel 0.60g Pb/l
CAR GAUGES