Page 1
OPERATOR’S MANUAL & PARTS LIST MODEL – THEM1000 1000W ELECTRIC LAWNMOWER Spares & Support: 01793 333212 Please read & understand this manual, paying particular attention to the safety instructions, before use. The manufacturer reserves the right to change the product specification and livery according to continued product improvements.
SPECIFICATIONS Model THEM1000 Product Number 193886001 Motor Power 1000 watt Motor Voltage & Frequency 230-240V/50HZ No Load Speed 3450 r/min Cutting Heights 20mm, 40mm &60mm Max Cutting Diameter 320mm Cable Length 8.8 kg IP Protection IPX4 82.5dB(A) KpA=3dB(A) 90.7dB(A) LwA Guaranteed...
GENERAL SAFETY INSTRUCTIONS Read and understand the owner’s manual and labels affixed to the machine. Learn its application and limitations as well as the specific potential hazards. Retain these instructions for future reference. The operator is responsible for following the warnings & instructions in this manual and on the product.
Page 6
STAY ALERT Do not operate the machine while under the influence of drugs, alcohol, or any medication that could affect your ability to use it properly. Do not use this machine when you are tired or distracted from the job at hand. Be aware of what you are doing at all times.
DO NOT FORCE TOOL Always work within the rated capacity. Do not use the machine for a purpose for which it was not intended. NEVER LEAVE MACHINE RUNNING UNATTENDED Do not leave the machine unattended until it has come to a complete stop. MAINTAIN YOUR MACHINE WITH CARE Clean the machine immediately after use.
MAINTENANCE & STORAGE WARNING Improper maintenance & storage of the machine may void your warranty. Keep the machine clean for better and safer performance. MAINTENANCE Before each use, check all nuts & bolts to be sure they are sufficiently tightened. ...
BLADE REPLACEMENT CAUTION Disconnect the mains and wear protective gloves when you attempt any kind of maintenance to the blade. WARNING When the motor has been switched off, the blade will continue to rotate for several seconds, do not touch the underside of the machine, until the cutting blade has come to a complete stop. WARNING Unbalanced blades will cause the lawnmower to vibrate violently - creating a risk of accident.
ASSEMBLY Remove the machine and contents from the carton. Be sure the carton is empty before discarding. If you require any assistance with regards to the contents of the machine, please contact us: Tel: 01793 333212 - Mon – Fri 8.30am – 5.30pm (excl. Bank Holidays) Email: customerservice@handydistribution.co.uk DESCRIPTION 1.
Page 11
HANDLE ASSEMBLY 1. Assemble the upper handle (2) to the lower handle (4) with the knob (16), washer (15) and bolt (14). (See Fig. 5). 2. Plug the two lower handle tubes in the main body holes. (See Fig. 4). 3.
Page 12
5. Assemble the other three hooks in the left side: Align the three hooks in this side on the lower box (5) to the hook holes in the box cover (7), and keep it in the position. As you do this step, you should make sure that the plastic piece on the lower box is under the cover box (7), and then keep it in the position.
OPERATION Before operating the machine, please ensure you are fully aware of the below instructions, failure to do so, could invalidate your manufacturer’s warranty. Completely unwind the electrical cable. SWITCH ON YOUR LAWNMOWER Before starting the machine, adjust the lawn mower to the cutting height you need. (Refer to the Lawn Mower Height Adjustment section).
TIPS DURING OPERATION MOWING PROCEDURE Always lay the cord on the ground near the outlet in neat, loose coils with the mower end of the cord on top. It is important to arrange the cord systematically to avoid annoying loops and knots. Starting at the point nearest the electrical outlet, move back and forth across the lawn.
PARTS LIST Part No. Description Part No. Description QG104‐01 Switch Box Assembly QG104‐25 Motor Support QG104‐02 Tapping Screw ST4.2*25 B QG104‐26 Bearing 6002 QG104‐03 Upper Handle QG104‐27 Big Pulley QG104‐04 Hang Line Hook QG104‐28 Belt 4PJ457 QG104‐05 Cable Hook QG104‐29 Cord Clamp QG104‐06 Flat Gasket Φ6xφ16x1.5...
Page 20
GJ HANDY & CO LTD USER WARRANTY POLICY 1. Users Statement of Warranty Each new machine is warranted against defective material or assembly of material under normal usage. The warranty applies to the original purchaser and covers faulty parts and the labour involved in replacing and repairing those parts, which are of original manufacture.
Page 21
GJ HANDY & CO LTD USER WARRANTY POLICY 3. Not covered by this warranty The warranty policy does not cover any depreciation or damages caused by ordinary wear, rusting or corrosion, lack of correct maintenance or operation, misuse, abuse, lack of transportation or accident.
EC Declaration of Conformity We, Importer Handy Distribution, Murdock Road, Dorcan, Swindon, SN3 5HY Declare that the product Model: THEM1000 1000W ELECTRIC LAWNMOWER Complies with the following directives: Machinery Directive 2006/42/EC Relevant Standard(s), Specification(s) referred to: EN 60335-1: 2012 EN60335-2-77:2010...
Page 24
For Spares or Support of your Handy product, please contact us: Tel: 01793 333212 (Mon – Fri 8.30am to 5.00pm) Email: customerservice@handydistribution.co.uk To see our complete range of garden machinery and equipment visit: www.thehandy.co.uk Distributed by Handy Distribution, Murdock Road, Dorcan, Swindon, SN3 5HY...