JVC AV42PD20ES Service Manual page 16

AV42PD20ES
MONITOR UNIT
REMOVING THE MONITOR UNIT
[1] REMOVING THE REAR COVER / SIDE COVER
＊ Take out the MONITOR UNIT.
＊ Take out the RECEIVER UNIT.
1. Remove the 18 screws marked A as shown in Fig.1.
2. Remove the 17 screws marked B as shown in Fig.1.
3. Remove the 2 screws marked C as shown in Fig.1.
4. Remove the 3 screws marked D as shown in Fig.1.
5. Withdraw the REAR & SIDE COVER toward you.
＊ If nec essary, take off the wire clamp, connectors, plug. etc .
[2] REMOVING THE SW PWB COVER
• Take out the REAR COVER / SIDE COVER.
1. Remove the 2 screws marked A as shown in Fig.2.
2. Remove the 2 screws marked B as shown in Fig.2.
3. Withdraw the SW PWB COVER toward you.
[3] REMOVING THE SPEAKER / TERMINAL COVER
• Take out the REAR COVER / SIDE COVER.
• Take out the SW PWB COVER.
1. Remove the 6 screws marked C as shown in Fig.2.
2. Remove the 4 screws marked D as shown in Fig.2.
3. Withdraw the SPEAKER and TERMINAL COVER toward
you.
[4] REMOVING THE INPUT TERMINAL COVER
• Take out the REAR COVER / SIDE COVER.
1. Remove the 5 screws marked E as shown in Fig.2.
2. Remove the 2 screws marked F as shown in Fig.2.
3. Pull out the INPUT TERMINAL COVER back ward.
[5] REMOVING THE PDP UNIT
• Take out the REAR COVER / SIDE COVER.
• Take out the SW PWB COVER.
• Take out the TERMINAL COVER.
• Take out the INPUT TERMINAL COVER.
1. Remove the 6 screws marked A as shown in Fig.3.
2. Take out the MONITOR UNIT from the FRONT PANEL
ASS'Y(with OPTICAL FILTER).
＊ The remove of PDP UNIT should be performed by 2 or more
persons.
CAUTION : Do not damage the gas inlet ！ ！ ！ ！
If the gas inlet is damaged, the PDP UNIT must be replaced.
So extr eme care should be taken not to dam age the gas
inlet when you remove the PDP UNIT.
16
REAR COVER
B
(× × × × 17)
INPUT TERMINAL COVER
PDP UNIT
B
( × × × × 2)
SW PWB COVER
PDP UNIT
GAS INLET
FRONT PANEL ASS'Y
No. 51955
SIDE COVER
C
D
( × × × × 2)
(× × × × 3)
A
( × × × × 18)
PDP UNIT
POWER SW
Fig.1
F
(× × × × 2)
E
(× × × × 5)
D
( × × × × 4)
C
(× × × × 6)
TERMINAL
COVER
A
(× × × × 2)
Fig.2
A
(× × × × 6)
OPTICAL FILTER
Fig.3