Fuel Requirements; Fuel Ratings; Using Reformulated (Oxygenated) Gasoline (Usa Only); Gasoline Containing Alcohol - Mercury 8.2 MAG Manual

Section 4 - Specifications

Fuel Requirements

IMPORTANT: Use of improper gasoline can damage your engine. Engine damage resulting from the use of improper
gasoline is considered misuse of the engine and will not be covered under the limited warranty.

Fuel Ratings

Mercury MerCruiser engines will operate satisfactorily with any major brand of unleaded gasoline that meets the following
specifications:
USA and Canada ‑ A posted pump Octane Rating of 87 (R+M)/2, minimum. Premium gasoline 92 (R+M)/2 Octane is also
acceptable. Do not use leaded gasoline.
Outside USA and Canada ‑ A posted pump Octane Rating of 91 RON, minimum. Premium gasoline (98 RON) is also
acceptable. If unleaded gasoline is not available, use a major brand of leaded gasoline.

Using Reformulated (Oxygenated) Gasoline (USA Only)

Reformulated gasoline is required in certain areas of the USA and are acceptable for use in your Mercury MerCruiser engine.
The two types of oxygenates used in these fuels are alcohol (ethanol) and ether (MTBE or ETBE). If ethanol is the oxygenate
that is used in the gasoline in your area, refer to Gasoline Containing Alcohol.

Gasoline Containing Alcohol

If the gasoline in your area contains either methanol (methyl alcohol) or ethanol (ethyl alcohol), be aware of possible adverse
effects. These adverse effects are more severe with methanol and worsen according to the percentage of alcohol in the fuel.
Alcohol in gasoline can absorb moisture from the air, causing the water and the alcohol to separate from the gasoline in the fuel
tank.
IMPORTANT: The fuel system components on your Mercury MerCruiser engine will withstand up to 10% alcohol content in the
gasoline. We do not know what percentage your boat's fuel system will withstand. Contact your boat manufacturer for specific
recommendations on your boat's fuel system components (fuel tanks, fuel lines, and fittings).
Be aware that gasoline containing alcohol may cause increased:
• Corrosion of metal parts
• Deterioration of rubber or plastic parts
• Fuel permeation through the rubber fuel lines
• Starting and operating difficulties
Fuel leakage is a fire or explosion hazard, which can cause serious injury or death. Periodically inspect all fuel system
components for leaks, softening, hardening, swelling, or corrosion, particularly after storage. Any sign of leakage or
deterioration requires replacement before further engine operation.
IMPORTANT: If you use gasoline that contains or might contain alcohol, you must increase the frequency of inspection for
leaks and abnormalities.
IMPORTANT: When operating a Mercury MerCruiser engine on gasoline containing alcohol, do not store the gasoline in the
fuel tank for long periods. Cars normally consume alcohol‑blend fuels before they can absorb enough moisture to cause
trouble, boats often sit idle long enough for phase separation to take place. Internal corrosion may take place during storage if
alcohol has washed protective oil films from internal components.

Engine Specifications

8.2 MAG, 8.2 MAG H.O. and SeaCore 8.2 MAG, 8.2 MAG H.O.

NOTE: Performance specifications are obtained and corrected in accordance with SAE J1228/ISO 8665 Crankshaft Power.
All measurements are taken with the engine at normal operating temperature.
RPM range is measured using an accurate service tachometer with the engine at normal operating temperatures.
Oil pressure must be checked with the engine at normal operating temperature.
NOTE: Oil pressure specifications are for reference and may vary.
Page 54
WARNING
!
90-8M0074352 OCTOBER 2012
eng