Table Of Contents - Potterton Suprima 30L Installation & Service Instructions Manual

Table of Contents

Table Of Contents2
Technical Data3
Installation Requirements4
Health And Safety Information4
Introduction4
Codes Of Practice4
Gas Supply5
Electricity Supply5
Location Of Boiler5
Dimensions6
Air Supply7
Flue Systems7
Flue Terminal Location8
The System9
Sealed Systems9
Pressure Relief Valve9
Expansion Vessel9
Mains Topping-Up Method10
Cistern Filling Method10
Method Of Make-Up For Sealed Systems10
Filling Point10
Open Vented Fully Pumped System Fitted With A Combined Feed And Vent11
Fully Pumped Sealed System11
Installation12
Unpack & Prepare The Boiler12
Flow Rate12
Circulation Pump Selection12
Install The Flue13
If A In-Line Bend Is Required In The Flue14
The Maximum Equivalent Flue Resistance Allowed When Using Bends14
Connect The Power Supply Cable15
Frost Thermostat15
Install The Optional Programmer16
Connect The Gas Supply16
Connect The Water Supply17
Commissioning18
Commission The Boiler20
Preliminary Electrical System Checks20
Final Adjustments21
Advise The User21
To Service The Boiler & Component Replacement22
Remember To Fill In The Benchmark Log Book22
Notes On Cleaning Boiler Components22
General Access22
To Service The Boiler23
Component Replacement23
Electronic Control Board24
Air Pressure Switch24
Burner 30 - 8025
Injector 30 - 8025
Combustion Chamber Insulation 30 - 8025
Gas Valve 30 - 8026
Burner 10027
Combustion Chamber Insulation 10027
Gas Valve 10028
Fan & Flue Hood29
Injector S10029
Temperature Sensor30
Overheat Thermostat30
Heat Exchanger31
Functional Wiring Diagram32
Boiler Lighting Sequence32
Wiring Diagrams33
Fault Finding34
Sequence Of Events34
Check List In The Event Of A Fault34
Intermittent Lockout - Main Causes34
Short List Of Spares36
Flue Kits38
System And Other Kits40
Installation Instructions Included As Necessary With Each Kit40
Connect The Water System60
First Time Lighting62
To Service The Boiler And Component Replacement64
Venturi, Fan And Burner69
Flue Hood And Internal Flue Tube70
Flues And Other Kits78
To Light82
Reset Button82
To Shut Off82
Temperature Control82
Pump Overrun83
Frost Precautions83
Led Indicators - Normal Modes83
Overheat Limit Thermostat83
Replacement Pcb Kit85
Replacement Of Controls Assembly87
Remove Existing Controls Assembly87
Remove And Refit Integral Timer88
Fit New Controls89