Use & Care Instructions; Gas Safety And Leak Tests - Grand Cafe CSM07ALP Operator's Manual

CORRECT LP GAS TANK USE
LP Gas smoker models are designed for use with
a standard 20 lb. Liquid Propane Gas (LP Gas)
tank, not included with smoker. Never connect your
gas smoker to an LP Gas tank that exceeds this
capacity. A tank of approximately 12 inches in
diameter by 18-1/2 inches high is the maximum size
LP Gas tank to use. You must use an "OPD" gas
tank which offers a listed Overfill Prevention
Device. This safety feature prevents tank from being
overfilled which can cause malfunction of LP Gas
tank, regulator and/or smoker.
The LP Gas tank must be constructed and marked
in accordance with the Specifications for LP-Gas
Cylinders of the U.S. Department of Transportation
(D.O.T.) or the National Standard of Canada, CAN/
CSA-B339, Cylinders, Spheres and Tubes for
Transportation of Dangerous Goods; and Commis-
sion, as applicable.
The LP Gas tank must have a shutoff valve,
terminating in an LP Gas supply tank valve outlet,
that is compatible with a Type 1 tank connection
device. The LP Gas tank must also have a safety
relief device that has a direct connection with the
vapor space of the tank.
The tank supply system must be arranged for
vapor withdrawal.
The LP Gas tank used must have a collar
to protect the tank valve.
Never connect an unregulated LP gas tank to your
gas smoker. The gas regulator assembly supplied
with your gas smoker is adjusted to have an outlet
pressure of 11" water column (W.C.) for connection
to an LP gas tank. Only use the regulator and
hose assembly supplied with your gas smoker.
Replacement regulators and hose assemblies
must be those specified by Grand Hall.
Have your LP Gas dealer check the release valve
after every filling to ensure it remains free of defects.
Always keep LP Gas tank in upright position.
Do not subject the LP Gas tank to excessive heat.
Never store an LP Gas tank indoors. If you store
your gas smoker in the garage always disconnect
the LP Gas tank first and store it safely outside.
LP Gas tanks must be stored outdoors in a well-
ventilated area and out of the reach of children.
Disconnected LP Gas tanks must not be stored in
a building, garage or any other enclosed area.
Keep gas regulator hose away from hot smoker
surfaces and dripping grease. Avoid unnecessary
twisting of hose. The regulator and hose assembly
can be seen after opening the doors (if applicable)
and must be inspected before each use of the
smoker. If there is excessive abrasion or wear or if
the hose is cut, it must be replaced prior to using
the smoker again.
Any attempt to convert the smoker from one fuel
type to another is extremely hazardous and must
be performed by a qualified gas technician only,
using a NG Conversion Kit purchased from Grand
Hall.
USE AND CARE INSTRUCTIONS
Never light your gas smoker with the
or before checking to ensure the burner tube is
fully seated over the gas valve orifice.
Never allow children to operate your smoker. Do
not allow children or pets to play near your smoker.
Use of alcohol or drugs may impair the ability to
assemble and operate the appliance.
Keep fire extinguisher readily accessible. In the
event of a oil/grease fire, do not attempt to extin-
guish with water. Use type B extinguisher or
smother with dirt, sand or baking soda.
In the event of rain, cover the smoker and turn off
the burner and gas supply.
Use your smoker on a level, stable surface in an
area clear of combustible materials.
Do not leave smoker unattended when in use.
Do not move the appliance when in use.
Allow the smoker to cool before moving or storing.
Do not use your smoker as a heater.
This smoker is not intended to be installed in or
on recreational vehicles and/or boats.
The smoker is not intended for commercial use.
WARNING
!
A. Do not store a spare LP-Gas tank under or near
this appliance.
Never fill the tank beyond 80 percent full; and
B.
If the information in "(a)" and "(b)" is not followed
C.
exactly, a fire causing death or serious injury may
occur.
WARNING
!
•
Use your smoker outdoors, at least 3 feet
away from any wall or surface. Use your
smoker at least 3 feet away from combustible
objects that can melt or catch fire (such as
vinyl or wood siding, fences and overhangs) or
sources of ignition including pilot lights on
water heaters and live electrical appliances.
•
Never use your gas smoker in a garage, porch,
shed, breezeway or any other enclosed area.
•
Never obstruct the flow of ventilation air around
your gas smoker housing.
10
doors closed
!
!