Briggs & Stratton Intek Snow 120000 Operating And Maintenance Instructions Manual

Hide thumbs Also See for Intek Snow 120000:

Operator's manual (80 pages)

Operator's manual (100 pages)

Table Of Contents

Table of Contents

Quick Links

Need help?

Do you have a question about the Intek Snow 120000 and is the answer not in the manual?

Questions and answers

Summary of Contents for Briggs & Stratton Intek Snow 120000

Page 1 Operating & Maintenance Instructions IntekE Snow Model Series Covered in This Manual 120000 200000 210000 Industrial PlusE Snow Model Series Covered in This Manual 90000 Model Type Code Note: General Model Series numbers noted above are inclusive of the specific model Month Day Year number found on your engine.
Page 2 The Power That Works For You. Look For Relevant Emissions Durability Period and Air Index Information On Your Engine Emissions Label Engines that are certified to meet the California Air Resources Board (CARB) Tier 2 Emission Standards must display information regarding the Emissions Durability Period and the Air Index. Briggs & Stratton makes this information available to the consumer on our emission labels.
Page 3: Hazard Symbols And Meanings
275697 BEFORE OPERATING ENGINE • Read entire Operating & Maintenance Instructions AND the instructions for the equipment this engine powers.* • Failure to follow instructions could result in serious injury or death. THE OPERATING & MAINTENANCE INSTRUCTIONS CONTAIN SAFETY INFORMATION TO •...
Page 4 SAFETY WARNING WARNING Starting engine creates sparking. Gasoline and its vapors are extremely flammable and explosive. Sparking can ignite nearby flam- mable gases. Fire or explosion can cause severe burns or death. Explosion and fire could result. • If there is natural or LP gas leakage in area, do not WHEN ADDING FUEL start engine.
Page 5: Engine Information
SAFETY WARNING WARNING Rapid retraction of starter cord (kick- Unintentional sparking can result in back) will pull hand and arm toward fire or electric shock. engine faster than you can let go. Unintentional start-up can result in Broken bones, fractures, bruises or entanglement, traumatic amputation, sprains could result.
Page 6 ENGINE INFORMATION IntekE Snow MODELS 120000, 200000, 210000 9. Throttle lever 1. Choke 10. Oil fill/Dipstick (if equipped) 2. Primer bulb 11. Electric starter (if equipped) 3. Push/Pull safety key 12. Oil drain plug 4. Blower housing SPARK PLUG LOCATION 13.
Page 7: Tune-Up Specifications
275697 ENGINE INFORMATION IntekE Snow MODELS 120000, 200000, 210000 MODEL SERIES 120000 Model Series 120000, 200000, 210000 are single cylinder, over- head valve (OHV), air-cooled engines. If your engine is of this se- Bore ......2.677 in.
Page 8: Oil Capacity
SAE Viscosity Grades CAUTION: This engine is shipped from Briggs & Stratton without oil. Check oil level before starting engine. If you start the engine without oil, the engine will be damaged beyond repair and will not be covered under warranty. OIL CAPACITY °...
Page 9: Adding Fuel
FUEL TYPE OF FUEL TO USE ♦ Use clean, fresh, regular unleaded gasoline with a ♦ For engine protection use Briggs & Stratton Gasoline minimum of 85 octane. On Model Series 90000 use Additive available from your Authorized Briggs & fuel with a minimum of 77 octane.
Page 10: Starting And Stopping
STARTING AND STOPPING REWIND (MANUAL) STARTER IntekE Snow MODELS 120000, 200000, 210000 To Start Engine: OPEN [1.] Check oil level. POSITION [2.] Turn fuel shut-off valve 1/4 turn to OPEN (if equipped). [3.] Push safety key IN (if equipped). [4.] Turn rotary choke knob to CHOKE position. Fuel shut-off Rotary Choke Knob [5.] Depress primer.
Page 11 STARTING AND STOPPING ELECTRIC STARTER (if equipped) IntekE Snow MODELS 120000, 200000, 210000 To Start Engine: [1.] Check oil level. OPEN POSITION [2.] Turn fuel shut-off valve (if equipped) 1/4 turn to OPEN. [3.] Push safety key IN (if equipped). [4.] Turn rotary choke knob to CHOKE position.
Page 12 STARTING AND STOPPING ELECTRIC STARTER (if equipped) Industrial PlusE Snow MODEL 90000 To Start Engine: [1.] Check oil level. [2.] Move choke lever to start position. [3.] Depress primer (if equipped). Note: If temperature is 15° or higher push primer two times, if below 15° push primer Typical Primer Typical Choke Lever four times.
Page 13: Maintenance
MAINTENANCE MAINTENANCE EMISSION CONTROL Regular maintenance will improve the performance and Maintenance, replacement or repair of the emission extend the life of the engine. See any Authorized Briggs & control devices and systems may be performed by any Stratton Dealer for service. Use only genuine Briggs & nonroad engine repair establishment or individual.
Page 14: Spark Plug
MAINTENANCE ENGINE AND ENGINE PARTS WARNING We recommend that you see an authorized Briggs & Stratton Service Dealer for all maintenance and service of If you perform any maintenance on the engine, begin by removal of safety key (if the engine and engine parts. Use only genuine Briggs & Stratton parts.
Page 15: Throttle Adjustment
MAINTENANCE CLEANING DEBRIS CAUTION: Do not use water to clean engine parts. Water could contaminate fuel system. Use a brush or dry cloth. CLEAN Daily or before every use, clean accumulated debris from engine. Keep linkage, spring and controls clean. Keep area around and behind muffler free of any combustible debris.
Page 16: Service & Storage
SERVICE & STORAGE SERVICE See an Authorized Briggs & Stratton Service Dealer. Each An illustrated shop manual includes common specifica- tions and detailed information covering adjustment, one carries a stock of Genuine Briggs & Stratton Parts and tune-up and repair of Briggs & Stratton engines. It is is equipped with special service tools.
Page 17: Limited Warranty
BRIGGS & STRATTON ENGINE OWNER WARRANTY POLICY Effective January 1, 2003 replaces all undated Warranties and all Warranties dated before January 1, 2003 LIMITED WARRANTY Briggs & Stratton Corporation will repair or replace, free of charge, any part(s) of the engine that is defective in material or workmanship or both. Transportation charges on parts submitted for repair or replacement under this warranty must be borne by purchaser.
Page 18 Briggs & Stratton Corporation (B&S), the California Air Resources Board (CARB) and the United States Environmental Protection Agency (U.S. EPA) Emission Control System Warranty Statement (Owner's Defect Warranty Rights and Obligations) EMISSION CONTROL WARRANTY COVERAGE IS APPLICABLE TO CERTIFIED ENGINES PURCHASED IN CALIFORNIA IN 1995 AND THERE- AFTER, WHICH ARE USED IN CALIFORNIA, AND TO CERTIFIED MODEL YEAR 1997 AND LATER ENGINES WHICH ARE PURCHASED AND USED ELSEWHERE IN THE UNITED STATES (AND AFTER JANUARY 1, 2001 IN CANADA).
Page 19 (Cette page ne s'applique que pour le Canada et les Etats-Unis) La Corporation Briggs & Stratton (B&S), le California Air Resources Board (CARB) et le Bureau de protection environnementale des Etats-Unis (US EPA) Garantie sur le système d'échappement (Garantie contre les défectuosités, droits et obligations du propriétaire) LA GARANTIE SUR LE SYSTÈME D'ÉCHAPPEMENT EST APPLICABLE SUR LES MOTEURS VANTES QUI ONT ÉTÉ...

This manual is also suitable for:

Intek snow 200000 Intek snow 210000 Industrial plus snow 90000