All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by WS 0770 BU CD Customer Service...
EN 2 LC4.41E AA Technical Specifications, Connections, and Chassis Overview 1. Technical Specifications, Connections, and Chassis Overview Index of this chapter: Maximum power (W : 2 x 15 1.1 Technical Specifications 1.2 Connection Overview 1.1.3 Miscellaneous 1.3 Chassis Overview Power supply:...
Page 3
Technical Specifications, Connections, and Chassis Overview LC4.41E AA EN 3 1.2.2 Rear Connections EXT1: Video RGB - In, CVBS - In/Out, Audio - In/Out AERIAL IN AUDIO IN VIDEO IN Pr Pb Y EXT 2 EXT 1 E_06532_001.eps 050404 HDMI...
Page 4
EN 4 LC4.41E AA Technical Specifications, Connections, and Chassis Overview Chassis Overview LCD PANEL POWER SUPPLY PANEL SMALL SIGNAL BOARD AUDIO PANEL OTC TXT PANEL CONTROL BOARD SIDE I/O PANEL LED & IR PANEL G_16240_024.eps 200206 Figure 1-6 Chassis overview...
Safety Instructions, Warnings, and Notes LC4.41E AA EN 5 2. Safety Instructions, Warnings, and Notes Notes Index of this chapter: 2.1 Safety Instructions 2.2 Warnings 2.3.1 General 2.3 Notes • Measure the voltages and waveforms with regard to the Safety Instructions chassis (= tuner) ground (H), or hot ground (I), depending on the tested area of circuitry.
• Special information for lead-free BGA ICs: these ICs will be delivered in so-called "dry-packaging" to protect the IC Philips CE is producing lead-free sets (PBF) from 1.1.2005 against moisture. This packaging may only be opened onwards. shortly before it is used (soldered). Otherwise the body of the IC gets "wet"...
Mechanical Instructions LC4.41E AA EN 7 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Position due to the different set executions. 4.3 Assy/Panel Removal •...
Page 8
EN 8 LC4.41E AA Mechanical Instructions 4.3.2 Side I/O Panel 4.3.4 Keyboard Control Panel G_16240_012.eps 150206 Figure 4-3 Side I/O panel 1. Remove the rear panel. G_16240_014.eps 170206 2. Remove the screw from the cable clip [1]. 3. Remove the screws [2] from the loudspeaker cabinet.
Page 9
Mechanical Instructions LC4.41E AA EN 9 4.3.5 Small Signal Board G_16240_015.eps G_16240_018.eps 250706 250706 Figure 4-6 SSB connectors Figure 4-9 SSB panel 4.3.6 Audio Amplifier Panel G_16240_016.eps 160206 Figure 4-7 Connector screws 1. Very cautiously disconnect the LVDS cable [1] from the panel (see Figure “SSB connectors”).
Page 10
EN 10 LC4.41E AA Mechanical Instructions 4.3.7 Plasma Panel 10. Release all disconnected cables from the (mostly plastic) guidances on the frame. 11. Loosen screws [9]. 12. Lift the metal frame [10] (together with the SSB) from the plasma panel.
Service Modes, Error Codes, and Fault Finding LC4.41E AA EN 11 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: How to Enter 5.1 Test Points To enter SDM, use one of the following methods: 5.2 Service Modes •...
Page 12
EN 12 LC4.41E AA Service Modes, Error Codes, and Fault Finding After entering SAM, the following screen is visible, with SAM in the upper right corner of the screen to indicate that the LLLLL AAABCD X.YY/EEEEE F.GG television is in Service Alignment Mode.
Page 13
Service Modes, Error Codes, and Fault Finding LC4.41E AA EN 13 12. NVM Editor. Can be used to change the NVM data in the television set. See table “NVM data” further on. 1 LLLLL AAABCD X.YY/EEEEE F.GG CSM 13. SC NVM Editor. Can be used to edit Scaler NVM.
Page 14
4. Press the MENU LEFT/RIGHT keys to enter the PICTURE Introduction sub menu. ComPair (Computer Aided Repair) is a service tool for Philips 5. Use the MENU UP/DOWN keys (if necessary) to select Consumer Electronics products. ComPair is a further BRIGHTNESS.
Page 15
Service Modes, Error Codes, and Fault Finding LC4.41E AA EN 15 How to Connect Note: To use the LVDS tool, you must have ComPair release This is described in the chassis fault finding database in 2004-1 (or later) on your PC (engine version >= 2.2.05).
Page 16
EN 16 LC4.41E AA Service Modes, Error Codes, and Fault Finding Table 5-1 Error code overview Example of error buffer: 12 9 6 0 0 After entering SDM, the following occurs: Error Error Description Check Item Diagram • 1 long blink of 5 seconds to start the sequence, No Error •...
Page 17
Service Modes, Error Codes, and Fault Finding LC4.41E AA EN 17 5.7.3 Flash New Scaler Software 3. If there is no teletext output, the IC TDA150xx may be defect. When you need to flash new scaler software, follow the instructions in ComPair. Make sure you put the set in one of the 5.7.6...
Page 18
EN 18 LC4.41E AA Service Modes, Error Codes, and Fault Finding Personal Notes: E_06532_012.eps 131004...
Block Diagrams, Test Point Overviews, and Waveforms LC4.41E AA 6. Block Diagrams, Test Point Overviews, and Waveforms Wiring Diagram 42” LG WIRING 42” FHP 8902 8903 AUDIO PLASMA PANEL PDP Y-MAIN PDP X-MAIN CN308 DRIVING BOARD POWER SUPPLY DRIVING BOARD...
Block Diagrams, Test Point Overviews, and Waveforms LC4.41E AA Supply Voltage Overview SUPPLY LINE OVERVIEW TOP CONNECTORS SDRAM TUNER & IF DC-DC CONVERTER POWER SUPPLY 7L02 3B01 PANEL (PSU) IN OUT 5152 5L01 7738 5738 IN OUT 5L11 5153 FLASH / CONTROL...
Circuit Diagrams and PWB Layouts LC4.41E AA SSB: Diversity Tables B1-B6 Item nr. Description Item Nr. Decription 1152 TUN V+U PLL IEC BGHIL B Item Nr. Description 2612 319801741050 CER2 0603 Y5V 10V 1U COL TUNER UV1318SD/A CP H N-4...
Circuit Diagrams and PWB Layouts LC4.41E AA SSB: Diversity Tables B9-B20 B15AB B20 Pac-3 Item Nr. Desciption 1G03 242202518872 CON H 32P F 0.50 SM FPC 0.3 R Item Nr. Description 2G31 202055200005 CER2 0603 X5R 6V3 4U7 PM10 R...
Page 61
Circuit Diagrams and PWB Layouts LC4.41E AA Layout Small Signal Board (Top Side Overview) 1152 E9 1G03 E6 1N03 B1 2213 C7 2234 B8 2250 B7 2269 B9 2291 D8 2710 A5 2763 B4 2B01 D1 2E20 E3 2G22 F3...
Page 62
Circuit Diagrams and PWB Layouts LC4.41E AA Layout Small Signal Board (Top Side Part 1) Part 1 G_16210_022a.eps 170106...
Page 63
Circuit Diagrams and PWB Layouts LC4.41E AA Layout Small Signal Board (Top Side Part 2) Part 2 G_16210_022b.eps 170106...
Page 64
Circuit Diagrams and PWB Layouts LC4.41E AA Layout Small Signal Board (Top Side Part 3) Part 3 G_16210_022c.eps 170106...
Page 65
Circuit Diagrams and PWB Layouts LC4.41E AA Layout Small Signal Board (Top Side Part 4) Part 4 G_16210_022d.eps 170106...
Page 66
Circuit Diagrams and PWB Layouts LC4.41E AA Layout Small Signal Board (Bottom Side Overview) 1151 F2 2204 A4 2609 A2 2730 B5 2810 D8 2913 C7 2937 D7 2B06 C9 2D12 E10 2D48 E9 2E14 E7 2F13 E9 2G55 F8...
Page 67
Circuit Diagrams and PWB Layouts LC4.41E AA Layout Small Signal Board (Bottom Side Part 1) Part 1 G_16210_023a.eps 170106...
Page 68
Circuit Diagrams and PWB Layouts LC4.41E AA Layout Small Signal Board (Bottom Side Part 2) Part 2 G_16210_023b.eps 170106...
Page 69
Circuit Diagrams and PWB Layouts LC4.41E AA Layout Small Signal Board (Bottom Side Part 3) Part 3 G_16210_023c.eps 170106...
Page 70
Circuit Diagrams and PWB Layouts LC4.41E AA Layout Small Signal Board (Bottom Side Part 4) Part 4 G_16210_023d.eps 170106...
Alignments LC4.41E AA EN 83 8. Alignments Index of this chapter: 8.1 General Alignment Conditions 8.2 Hardware Alignments 8.3 Software Alignments Note: Figures below can deviate slightly from the actual situation, due to the different set executions. General: The Service Default Mode (SDM) and Service Alignment Mode (SAM) are described in chapter 5.
Page 84
EN 84 LC4.41E AA Alignments 8.3.1 SAM Menu LLLLL AAABCD X.YY/EEEEE F.GG ERR 0 0 0 0 0 OP 152 167 015 081 252 127 019 . OP1 . Delta Cool Red . OP2 . Delta Cool Green -1 . OP3 .
Page 85
Alignments LC4.41E AA EN 85 8.3.4 ADC Gain and Grey Scale Alignment 8.3.5 Panel Size Settings The table below shows a number of NVM settings used for The table below shows the NVM settings for panel selection, each model of TV set. Be sure to use the correct editor in the based on panel size and manufacturer.
Page 86
EN 86 LC4.41E AA Alignments 8.3.7 Options Options OP1...OP7 in the SAM menu can be used for quickly restoring 64 features or settings of the HERCULES part of the TV set to their original default factory values (8 groups of 8 features/settings each).
Page 87
Alignments LC4.41E AA EN 87 Table 8-4 Option codes in detail, at bit level Option byte & bit table for restoring the TV set to its original Factory Default settings via the NVM Editor in the SAM menu 42PF3321/10 42PF5411/10...
Page 88
EN 88 LC4.41E AA Alignments Option byte & bit table for restoring the TV set to its original Factory Default settings via the NVM Editor in the SAM menu 42PF3321/10 42PF5411/10 Model number 42PF5321/10/12 (TBD) 42PF7321/10/12 bit 5 OP_AMBILIGHT bit 4...
Circuit Descriptions, Abbreviation List, and IC Data Sheets LC4.41E AA EN 89 9. Circuit Descriptions, Abbreviation List, and IC Data Sheets Index of this chapter: models are shown in the block diagram in the Figure “Block 9.1 Introduction diagram of the internal building blocks“.
EN 90 LC4.41E AA Circuit Descriptions, Abbreviation List, and IC Data Sheets Power Supply Unit Abbreviation List 9.3.1 Description 0/6/12 SCART switch control signal on A/V board. 0 = loop through (AUX to TV), 6 = play 16:9 format, 12 = play 4:3...
Page 91
Vertical sync to the customer's preferences Read Only Memory LATAM LATin AMerica Service Alignment Mode LC04 Philips chassis name for LCD (and Short Circuit SCART Syndicat des Constructeurs Plasma) TV 2004 project Liquid Crystal Display d'Appareils Radiorécepteurs et Light Emitting Diode; A semiconductor Téléviseurs;...
Page 92
EN 92 LC4.41E AA Circuit Descriptions, Abbreviation List, and IC Data Sheets Teletext; TXT is a digital addition to analogue TV signals that contain textual and graphical information (25 rows x 40 columns). The information is transmitted within the first 25 lines...
Circuit Descriptions, Abbreviation List, and IC Data Sheets LC4.41E AA EN 93 IC Data Sheets This section shows the internal block diagrams and pin layouts of ICs that are drawn as "black boxes" in the electrical diagrams (with the exception of "memory" and "logic" ICs).
Page 94
EN 94 LC4.41E AA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.5.2 Diagram B19, Type T6TU5XB (IC7M00, Columbus) Figure 1 Package outline (top view) WEB/ UVA0 UVA2 UVA4 UVA6 UVA8 SEL656 TST1 HREF DAVB /Di0 /Di2 /Di4 /Di6 /Di8...
Page 95
Circuit Descriptions, Abbreviation List, and IC Data Sheets LC4.41E AA EN 95 9.5.3 Diagram B7+B8+B9, Type GM1501 (IC7801, Genesis) Block Diagram Parallel 2-wire IF/external Serial I/F JTAG GPIO micro Infra-red Rx Pulse Width Interface X186 External ndwid Modulator Micro- ROM I/F...
Page 96
EN 96 LC4.41E AA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.5.4 Diagram B12, Type TDA9975EL (IC7D03, HDMI Panellink), Reserved Block Diagram τ ORR/V τ I²C ORB/U τ ORG/Y G/Pb B/Pb1 B/Pb2 B/Pb3 I²C 10/12 I²C I²C CLAMP BIAS I²C...