Power Wheels R0003 Owner's Manual page 28

PROBLEM
Vehicle runs in low speed,
but does not run in
high speed.
Please note: The vehicle is
designed to operate in low
speed only in reverse .
When the foot pedal is
pressed one rear
wheel spins
Sometimes the vehicle
doesn't run, but other times
it does
When the go foot pedal is
pressed, the vehicle won't
run without a push
Battery's thermal fuse
constantly "trips", but the
vehicle is not overloaded
nor the driving conditions
too severe
Loud clacking or grinding
noise from a motor-gearbox
Charger gets warm
during use
Battery makes a sizzling or
gurgling noise when charging
POSSIBLE CAUSE
High speed lock-out
not disconnected
Operation of vehicle in low speed
Loose wire or connector
Motor or electrical switch damage
Loose wire or connector
"Dead Spot" on motor
Damaged battery
Child is switching between
FORWARD and REVERSE
without stopping
Broken gears
It is normal for some chargers to get
warm during use and is not reason
for concern.
It is normal for some batteries to
make noise and swell slightly while
charging and is not reason
for concern.
The vehicle was pre-set to run only in low speed. To allow the
vehicle to run in low and high speed, you must disconnect the
High Speed Lock-Out. Follow the instructions on page 22 to
remove the High Speed Lock-Out screw.
It is possible that only one rear wheel may spin when both rear
wheels are raised off the ground and the vehicle is in low speed.
This does not necessarily indicate a problem. Check for proper
operation of the drive system by raising the rear wheels off the
ground and pressing the foot pedal. If only one rear wheel spins,
carefully press your hand on the spinning wheel to slow it down.
The other rear wheel should begin to spin. If the other rear wheel
does not begin to spin, there may be a problem with the vehicle.
Contact Consumer Relations.
Check all wires around the motors and all connectors to make
sure they are tight.
Contact Consumer Relations.
Check all wires around the motors and all connectors to make
sure they are tight.
Contact Consumer Relations.
Contact Consumer Relations.
Teach your child to stop the vehicle before switching direction.
Contact Consumer Relations.
No action required.
If your charger does not get warm during use, it does not mean
that it is not working properly.
No action required.
If your battery does not make noise or swell slightly during
charging, it does not mean that it is not accepting the charge.
28
SOLUTION
R0003pr-0720