Integra DPS-5.5 Service Manual
  1. Manuals
  2. Brands
  3. Integra Manuals
  4. CD Player
  5. DPS-5.5
  6. Service manual

Integra DPS-5.5 Service Manual

Dvd disc player
Hide thumbs Also See for DPS-5.5:
Table of Contents

Advertisement

Quick Links

Download this manual See also: Instruction Manual
QQ
3 7 63 1515 0
TE
L 13942296513
www
.
http://www.xiaoyu163.com
SERVICE MANUAL
SERVICE MANUAL
DVD DISC PLAYER
MODEL
B MUD1N
B MUP4P
SAFETY-RELATED COMPONENT
WARNING!!
COMPONENTS IDENTIFIED BY MARK
SCHEMATIC DIAGRAM AND IN THE PARTS LIST ARE
CRITICAL FOR RISK OF FIRE AND ELECTRIC SHOCK.
REPLACE THESE COMPONENTS WITH ONKYO
PARTS WHOSE PART NUMBERS APPEAR AS SHOWN
IN THIS MANUAL.
MAKE LEAKAGE-CURRENT OR RESISTANCE
MEASUREMENTS TO DETERMINE THAT EXPOSED
PARTS ARE ACCEPTABLY INSULATED FROM THE
SUPPLY CIRCUIT BEFORE RETURNING THE
APPLIANCE TO THE CUSTOMER.
x
ao
u163
y
i
http://www.xiaoyu163.com
2 9
8
DPS-5.5
Black model
Q Q
3
6 7
1 3
1 5
120V AC, 60Hz
100-240V AC, 50Hz
ON THE
co
.
9 4
2 8
Ref. No. 3805
Jun, 2004
RC-536DV
0 5
8
2 9
9 4
2 8
m
DPS-5.5
9 9
9 9

Advertisement

Table of Contents
loading

Related Manuals for Integra DPS-5.5

Summary of Contents for Integra DPS-5.5

  • Page 1 DPS-5.5 3 7 63 1515 0 Ref. No. 3805 SERVICE MANUAL SERVICE MANUAL Jun, 2004 DVD DISC PLAYER DPS-5.5 MODEL RC-536DV Black model L 13942296513 B MUD1N 120V AC, 60Hz B MUP4P 100-240V AC, 50Hz SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK...

  • Page 2: Specifications

    DPS-5.5 3 7 63 1515 0 SPECIFICATIONS North American model: Standard NTSC, Video system Australian model: PAL/AUTO North American model: 1, Region code Australian model: 4, Laser Semiconductor laser, wavelength 650 nm (DVD), 780 nm (CD) 4 Hz-22 kHz @ 48 kHz sampling rate...

  • Page 3: Protection Of Eyes From Laser Beam During Servicing

    DPS-5.5 3 7 63 1515 0 SERVICE PROCEDURES-1 PROTECTION OF EYES FROM LASER BEAM DURING SERVICING This set employs a laser. Therefore, be sure to follow carefully the instructions below when servicing. Laser Diode Properties WARNING!! Wavelength: 650/780nm (DVD/CD) SERVICE WARNING : DO NOT APPROACH THE LASER EXIT WITH THE EYE TOO CLOSELY.
  • Page 4 DPS-5.5 3 7 63 1515 0 SERVICE PROCEDURES-2 2. Safety-check out (Only U.S.A. model) After correcting the original service problem perform the following safety check before releasing the set to the customer Connect the insulating-resistance tester between the plug of power supply cord and terminal GND on the back panel.
  • Page 5 Standby/On button This button is used to open and close the disc tray. This button is used to set the DPS-5.5 to On or Pause button Standby. For models with a Power switch, this but- This button is used to pause playback.
  • Page 6 DPS-5.5 3 7 63 1515 0 PANEL VIEW-2 DISPLAY V CD TITLE TRACK CHP TOTAL REMAIN PROGRESSIVE 13 14 Play indicator D indicator This indicator is shown during playback. This indicator appears when playing Dolby Digital material. Pause indicator Disc type indicators This indicator appears when playback is paused.

  • Page 7: Rear Panel

    TV, projector or AV receiver with component to pickup signals from the remote controller when video inputs. the DPS-5.5 is located in another room, installed in VIDEO OUTPUT a rack, or is out of range of the remote controller...

  • Page 8: Remote Controller

    This button is used to start playback of the selected Standby button title, chapter, or track, and to confirm settings. This button is used to set the DPS-5.5 to Standby. Setup button On button This button is used to open and close the onscreen setup menus.
  • Page 9 DPS-5.5 3 7 6 3 1 5 1 5 0 EXPLODED VIEW A11a P910 P702 A11a P502 P501 P503 P701 L 1 3 9 4 2 2 9 6 5 1 3 A27 x 3 Z91A S731 P901A P910 u 1 6 3 http://www.xiaoyu163.com...
  • Page 10 DPS-5.5 3 7 63 1515 0 EXPLODED VIEW / PARTS LIST LOADING MECHANISM Refer to "2.5 TRAVERSE MECHA. ASSY-S". To DVDM CN101 (Pickup Assy-S) To DVDM CN104 (Stepping Motor) To DVDM CN102 (Spindle Motor) L 13942296513 LOADING MECHA. ASSY par ts List Mark No.
  • Page 11 DPS-5.5 3 7 63 1515 0 EXPLODED VIEW / PARTS LIST TRAVERSE MECHANISM 15 (Torque : 0.15 +/- 0.01 N m) Silicone Adhesive GEM1037 DVDM CN101 (Pickup Assy) 4 (Adjustment screw) Silicone Adhesive GEM1037 Screw Tight 15 (Torque : 0.15 +/- 0.01 N m)

  • Page 12: Schematic Diagram

    http://www.xiaoyu163.com 3 7 63 1515 0 SCHEMATIC DIAGRAM-1 : OUTPUT TERMINAL PC BOARD NAAR-7997 232SCK 232SI 232SO 232RE 232RESET 232BU C354 C355 -27V L351 BK1608LM182-T FLAC1 VDET C356 FLAC2 IRIN EVER+5V L354 BK1608LM DEMO SYSRESET R351 RESET P_ON C351 C363 XSCK L352 223Z...
  • Page 13 DPS-5.5 3 7 63 1515 0 OPTICAL_OUT P201 Q351 JFJ3000 C221 R221 R231 P292A 470/6.3 L201 C360 P/XI R224 ASPECT R232 104Z C222 104K R222 L202 Q356 JFJ3000 C223 R223 R233 C367 L203 R257 SIGNAL 470/6.3 104Z C253 104K...
  • Page 14 3 7 63 1515 0 SCHEMATIC DIAGRAM-2 : MARK Region Model Setup R738 R739 DPS-5.5 R740 R736 : DISPLAY CIRCUIT PC BOARD NADIS-7998 R741 R737 R742 R743 HNV-13SS12T Q702 Q706 R725 Q707 R724 FL_ON/OFF L 13942296513 STB_L K2 20...
  • Page 15 DPS-5.5 3 7 63 1515 0 MUD1N MUA4P : STANDBY SWITCH PC BOARD NADIS-7999 R752 R753 R754 R755 R756 R757 Q705 REMSENS 1.8K 3.9K R751 2.7K STB_L STB_L C706 Q708 100/6.3 R759 R760 R761 R762 R763 R764 RN1407 1.8K 3.9K...
  • Page 16 http://www.xiaoyu163.com 3 7 63 1515 0 SCHEMATIC DIAGRAM-3 DVD MAIN CIRCUIT PC BOARD (1/3) CLAMP DB-VPB501/XJ UNCLAMP OPENC CLOSEC ROT DRV LOAD DRVC XDRV MUTE XDRV MUTE2 L 13942296513 (RF) (RF) (RF) (RF) (RF) u163 (RF) http://www.xiaoyu163.com...
  • Page 17 DPS-5.5 3 7 63 1515 0 (RF) : RF SIGNAL ROUTE : FOCUS SERVO LOOP LINE : TRACKING SERVO LOOP LINE : STEPPING SERVO LOOP LINE (RF) (RF) (RF) L 13942296513 u163 http://www.xiaoyu163.com...
  • Page 18 http://www.xiaoyu163.com 3 7 63 1515 0 SCHEMATIC DIAGRAM-4 DVD MAIN CIRCUIT PC BOARD (2/3) DB-VPB501/XJ L 13942296513 (AD) (AD) u163 http://www.xiaoyu163.com...
  • Page 19 DPS-5.5 3 7 63 1515 0 : FE_DATA SIGNAL ROUTE (RF) : RF SIGNAL ROUTE (C/V) : VIDEO SIGNAL ROUTE (C/V) : S VIDEO SIGNAL ROUTE (Y) : S VIDEO SIGNAL ROUTE (C) (AD) : AUDIO DATA SIGNAL ROUTE...

  • Page 20: Http://Www.xiaoyu163.Com

    http://www.xiaoyu163.com 3 7 63 1515 0 SCHEMATIC DIAGRAM-5 DVD MAIN CIRCUIT PC BOARD (3/3) DB-VPB501/XJ 1.8V Reg. 1.8V Reg. L 13942296513 u163 http://www.xiaoyu163.com...

  • Page 21: Http://Www.xiaoyu163.Com

    DPS-5.5 3 7 63 1515 0 5V Reg. L 13942296513 (C/V) (C/V) (C/V) (PR/R) (PR/R) (PR/R) (PB/B) (PB/B) (PB/B) (CY/G) (CY/G) (CY/G) (C/V) : VIDEO SIGNAL ROUTE (C/V) : S VIDEO SIGNAL ROUTE (Y) : S VIDEO SIGNAL ROUTE (Y)

  • Page 22: Table Of Contents

    DPS-5.5 3 7 6 3 1 5 1 5 0 SCHEMATIC DIAGRAM-6 : RS-232 TERMINAL PC BPARD NAETC-8005 NCETC-8005 100/6.3 RESET C813 BK1608LM182-T SDATAOUT EVER+5V L801 104Z SDATAIN 100/6.3 1/50 1/50 C802 C812 BUSY C803 C810 PORT15 PORT14 30...

  • Page 23: Http://Www.xiaoyu163.Com

    DPS-5.5 3 7 6 3 1 5 1 5 0 SCHEMATIC DIAGRAM-7 : POWER SUPPLY UNIT NGPS-0040-100-120V <MUD1N> NGPS-0041-100-240V <MUP4P> EV+12V C4: 250WXA68M 16x20 <MUD1N> 400WXA68A 18x20 <MUP4P> P-con D1-D4 SJW1 VS1 C1 49101.6PAR SW+8V C30 R32 SW+8V 49101.6PAR...

  • Page 24: Http://Www.xiaoyu163.Com

    DPS-5.5 3 7 6 3 1 5 1 5 0 SCHEMATIC DIAGRAM-1 : OUTPUT TERMINAL PC BOARD NAAR-7997 232SCK OPTICAL_OUT 232SI P201 Q351 JFJ3000 C221 R221 232SO R231 P292A 470/6.3 232RE L201 C360 232RESET P/XI R224 232BU ASPECT R232...

  • Page 25: Http://Www.xiaoyu163.Com

    DPS-5.5 3 7 6 3 1 5 1 5 0 SCHEMATIC DIAGRAM-2 MUD1N MUA4P : MARK Region R738 Model Setup R739 DPS-5.5 R740 R736 : DISPLAY CIRCUIT PC BOARD NADIS-7998 R741 R737 R742 : STANDBY SWITCH R743 PC BOARD NADIS-7999...
  • Page 26 DPS-5.5 3 7 6 3 1 5 1 5 0 SCHEMATIC DIAGRAM-3 DVD MAIN CIRCUIT PC BOARD (1/3) CLAMP DB-VPB501/XJ UNCLAMP OPENC CLOSEC (RF) : RF SIGNAL ROUTE ROT DRV : FOCUS SERVO LOOP LINE LOAD DRVC : TRACKING SERVO LOOP LINE...
  • Page 27 DPS-5.5 3 7 6 3 1 5 1 5 0 SCHEMATIC DIAGRAM-4 DVD MAIN CIRCUIT PC BOARD (2/3) DB-VPB501/XJ : FE_DATA SIGNAL ROUTE (RF) : RF SIGNAL ROUTE (C/V) : VIDEO SIGNAL ROUTE (C/V) : S VIDEO SIGNAL ROUTE (Y)
  • Page 28 DPS-5.5 3 7 6 3 1 5 1 5 0 SCHEMATIC DIAGRAM-5 DVD MAIN CIRCUIT PC BOARD (3/3) DB-VPB501/XJ 1.8V Reg. 1.8V Reg. 5V Reg. 1 3 9 4 2 2 9 6 5 1 3 (C/V) (C/V) (C/V)
  • Page 29 DPS-5.5 3 7 6 3 1 5 1 5 0 PC BOARD CONNECTION DIAGRAM P801 MJJ ONLY P291 : RS-232C terminal PC board NAETC-8005 P851B : INLET TERMINAL PCB P292B NAPS-8002 NCPS-8002 P981B P351B P982B P982A WHITE BROWN P292A...
  • Page 30 DPS-5.5 3 7 63 1515 0 PRINTED CIRCUIT BOARD VIEW DVD MAIN CIRCUIT PC BOARD (DB-VPB501/XJ) SIDE A SIDE A SPINDLE STEPPING PICKUP ASSY Output terminal MOTOR MOTOR CN1013 CN601 CN901 CN105 CN104 CN101 IC421 CN101 IC601 CN104 CN105...
  • Page 31 DPS-5.5 3 7 63 1515 0 PRINTED CIRCUIT BOARD VIEW DVD MAIN CIRCUIT PC BOARD (DB-VPB501/XJ) SIDE B SIDE B CN931 R1011 CN111 HEAT-RESISITANCE R1012 CN941 IC603 PRE-FLAX CN911 R452 Q452 Q603 C233 C230 IC501 CN112 NORMAL SOLDER C200...
  • Page 32 http://www.xiaoyu163.com 3 7 63 1515 0 PRINTED CIRCUIT BOARD VIEW SOLDERING SIDE : DISPLAY CIRCUIT PC BOARD NADIS-7998 P731 P702A J723 P701B C701 PLAY STOP OPEN PAUSE X701 S710 J724 S701 S703 S702 MENU J733 TOP_MENU S706 S704 J731 SETUP RETURN J729 S707...
  • Page 33 DPS-5.5 3 7 63 1515 0 J702 NCDIS-7998 25137998 C706 X701 PLAY_MODE DISPLAY J715 S713 S714 Q705 Q705 J707 J712 J713 J708 J703 J711 J709 J714 J704 J705 J706 J710 Q702 R7001 S712 S715 CLEAR DIMMER Q702 Component side...
  • Page 34 http://www.xiaoyu163.com 3 7 63 1515 0 PRINTED CIRCUIT BOARD VIEWFROM SOLDERING SIDE : OUTPUT TERMINAL PC BOARD NAAR-7997 Q356 Q351 P352 P350 P802 P401 P402 P104 Q356 P802 J109 J102 P402 Q351 P350 J101 J108 P352 J149 J128 Q801 J148 J107 J144 Q801...
  • Page 35 DPS-5.5 3 7 63 1515 0 P205 P203 P201 P601 P205 P201 P203 J180 J152 C221 C251 B/CB P292A J159 R/CR C223 C252 J173 J174 J160 J156 J166 J176 J162 C601 C603 J175 J164 J177 J157 CN903 J179 CN902...
  • Page 36 http://www.xiaoyu163.com 3 7 63 1515 0 PRINTED CIRCUIT BOARD VIEW FROM SOLDERING SIDE : OUTPUT TERMINAL PC BOARD NAAR-7997 C367 C360 C354 Q352 R435 Q352 Q407 Q405 Q406 C361 R1003 C903 Q463 C352 Q460 R458 R431 R119 R461 R460 D101 C901 Q403 Q404...
  • Page 37 DPS-5.5 3 7 63 1515 0 R1006 D604 D603 R1014 R1013 D605 D602 Q604 Q607 Q601 D606 Q606 Q608 R608 C602 Q601 R1011 R1015 R1017 D601 R1010 R1012 R1016 Q603 Q602 R601 R602 R603 Q605 R606 L 13942296513 u163...
  • Page 38 DPS-5.5 3 7 63 1515 0 PRINTED CIRCUIT BOARD VIEW FROM BOTTOM SIDE : STANDBY SWITCH PC BOARD NADIS-7999 25137999 NCDIS-7999 Q708 S716 Soldering side Component side : POWER SWITCH PC BOARD NASW-8000 L 13942296513 25138000 NCSW-8000 S991 u163...

  • Page 39: Ncetc-

    DPS-5.5 3 7 63 1515 0 PRINTED CIRCUIT BOARD VIEW FROM SOLDERING SIDE : RS-232C terminal PC board NAETC-8005 P851B P802 R8001 L801 J801 X801 J802 R807 J804 R801 C811 R808 J803 R806 R805 R811 R804 R802 R809 L803...
  • Page 40 DPS-5.5 3 7 63 1515 0 PRINTED CIRCUIT BOARD VIEW LOAB ASSY SIDE A SIDE B LOAB S101 LOAD+ VWG2426- CN602 C102 CN602 LOAD- PYKC F6 VNP1910- C101 CN601 CN601 CN602 CN601 CN601 CN602 CN103 L 13942296513 LOADING MOTOR...
  • Page 41 DPS-5.5 3 7 63 1515 0 MICROPROCESSOR TERMINAL DESCRIPTION PIN NAME SIGNAL DESCRIPTION 1 VDD1 VDD1 Power supply port 2 VSS1 VSS1 Ground port 3 X1 Connect to clock oscillator of main micro processor 4 X2 Connect to clock oscillator of main micro processor...
  • Page 42 DPS-5.5 3 7 6 3 1 5 1 5 0 PRINTED CIRCUIT BOARD VIEW SOLDERING SIDE : DISPLAY CIRCUIT PC BOARD NADIS-7998 P731 P702A J723 P701B J702 NCDIS-7998 25137998 C701 C706 PLAY STOP OPEN PAUSE X701 S710 S701 J724...
  • Page 43 DPS-5.5 3 7 6 3 1 5 1 5 0 PRINTED CIRCUIT BOARD VIEWFROM SOLDERING SIDE : OUTPUT TERMINAL PC BOARD NAAR-7997 Q356 Q351 P352 P205 P350 P802 P401 P402 P203 P104 Q356 P802 J109 J102 P402 Q351 P350...
  • Page 44 DPS-5.5 3 7 6 3 1 5 1 5 0 PRINTED CIRCUIT BOARD VIEW FROM SOLDERING SIDE : OUTPUT TERMINAL PC BOARD NAAR-7997 C367 C354 C360 R1006 Q352 R435 Q352 Q407 Q405 Q406 C361 R1003 Q463 C903 C352 D604...
  • Page 45 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM / TERMINAL DESCRIPTION Q803: MPD4721GS RS-232C LINE DRIVER/ RECEIVER BLOCK DIAGRAM 20 Pin Plastic Shrink SOP +10V +3.3V -10V STBY NOTE1 300 ohm OUT1 300 ohm OUT2 OUT1 5.5k ohm...

  • Page 46: Port14

    DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM/ TERMINAL DESCRIPTION Q802 : MPD789071MC 8-Bit Microprocessor PIN LAYOUT P31/BZO90 RESET P30/TO90 P27/TI80/TO80 P26/INTP2/CPT90 P25/INTP1 P24/INTP0 P23/SS20 P20/SCK20/ASCK20 P22/SI20/Rx20 P21/SO20/TxD20 8-bit TIMER/ EVENT PORT0 P00-P07 COUNTER80 PORT1 P10-P15 16-bit TIMER...
  • Page 47 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM/ TERMINAL DESCRIPTION Q401,Q402,Q403,Q404 NJM4580M-D (2-ch Ope. amp.) Pin description 1. A OUTPUT 2. A -INPUT 3. A +INPUT 4. V- 5. B +INPUT 6. B -INPUT 7. B OUTPUT 8. V+...
  • Page 48 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM/ TERMINAL DESCRIPTION Q703: S-80130CLMC-JKM VOLTAGE DETECTOR (13.0V CMOS, Active L: out) Pin Layout Detection voltage: 3.0V +/-2% Delay time: 200ms typ. Pin Description Symbol Description Top view ON/OFF switch for delay time...
  • Page 49 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM / TERMINAL DESCRIPTION Q352 : TC74VHCU04FT Hex inverter Pin layout 14 Vcc 13 6A 12 6Y 11 5A Truth table 10 5Y 9 4A 8 4Y L 13942296513 u163 http://www.xiaoyu163.com...
  • Page 50 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM / TERMINAL DESCRIPTION IC101 : M63018FP (BTL DRIVER)-1 Pin Arrangement L 13942296513 Block Diagram u163 http://www.xiaoyu163.com...
  • Page 51 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM / TERMINAL DESCRIPTION IC101 : M63018FP (BTL DRIVER)-2 Pin Function L 13942296513 u163 http://www.xiaoyu163.com...
  • Page 52 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM / TERMINAL DESCRIPTION IC601 : STM5589CVA BACK END IC Dir. & l a i L 13942296513 l a i . t i . t i u163 http://www.xiaoyu163.com...
  • Page 53 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM / TERMINAL DESCRIPTION IC601 : STM5589CVA BACK END IC Dir. Pin Function Pin Name t i s t i s t i s t i s t i s t i s...
  • Page 54 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM / TERMINAL DESCRIPTION IC601 : STM5589CVA BACK END IC Pin Name Dir. Pin Function ' L ' L' ' L' ' L' ' : ' L : ' L L 13942296513...
  • Page 55 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM / TERMINAL DESCRIPTION IC601 : STM5589CVA BACK END IC Pin Name Dir. Pin Function r i f ' L ' ' L ' ' L ' t i r ' L '...
  • Page 56 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM / TERMINAL DESCRIPTION IC601 : STM5589CVA BACK END IC Pin Name Dir. Pin Function L 13942296513 ' L ' l a i l a i u163 http://www.xiaoyu163.com...
  • Page 57 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM / TERMINAL DESCRIPTION IC601 : STM5589CVA BACK END IC Pin Name Dir. Pin Function L 13942296513 u163 http://www.xiaoyu163.com...
  • Page 58 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM / TERMINAL DESCRIPTION IC301 : STM6316ATXXA FRONT END IC Block Diagram L 13942296513 u163 http://www.xiaoyu163.com...
  • Page 59 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM / TERMINAL DESCRIPTION IC301 : STM6316AT Pin Name description detail R IF t i c t i c t s i L 13942296513 t s i t s i t s i...
  • Page 60 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM / TERMINAL DESCRIPTION IC301 : STM6316AT Pin Name description detail t s i l l u L 13942296513 / IF / IF i t i l l u - t l...
  • Page 61 DPS-5.5 3 7 63 1515 0 IC BLOCK DIAGRAM / TERMINAL DESCRIPTION IC301 : STM6316AT Pin Name description detail l l i l l i L 13942296513 t i c l i b y t i u163 http://www.xiaoyu163.com...
  • Page 62 DPS-5.5 3 7 63 1515 0 FL TUBE VIEW Q702:14-BT-68GNK DVD - AUDIO SACD V CD VIDEO OFF RANDOM MEMORY D PRO LOGIC TITLE GROUP TRACK CHP PROGRAM TOTAL REMAIN PROGRESSIVE L 13942296513 (1G-10G) GROUP REMAIN TITLE TOTAL PRO LOGIC...
  • Page 63 DPS-5.5 3 7 63 1515 0 MICROPROCESSOR TERMINAL DESCRIPTION Q701 : MPD780232GC VDD1 VLOAD VDD1 VLOAD VSS1 VSS1 VDD2 VDD2 -- > FIP20 FIP21 -- > -- > -- > FIP22 RESET -- > -- > ~RESET FIP23 -- >...
  • Page 64 DPS-5.5 3 7 63 1515 0 ADJUSTMENT OF MECHANISM-1 1. ADJUSTMENT ITEMS AND LOCATION Adjustment Items Adjustment Points (Mechanism Part) [Mechanism Part] Cautions: After adjustment, adjustment screw locks with the Tangential and Radial Height Coarse Adjustment Screw tight. DVD Jitter Adjustment...
  • Page 65 DPS-5.5 3 7 63 1515 0 ADJUSTMENT OF MECHANISM-2 3. NECESSARY ADJUSTMENT POINTS When Adjustment Points Exchange Parts of Mechanism Assy Mechanical After adjustment, screw locks Exchange the Pickup point with the Screw tight. Electric point Mechanical Exchange the Traverse Mechanism...
  • Page 66 DPS-5.5 3 7 63 1515 0 ADJUSTMENT OF MECHANISM-3 4. TEST MODE Setting the special mode of the RC-484M TEST MODE: ON RC-484M STANDBY/ON TEST MODE: DISC SET CHECK <TRAY OPEN> DVD, CD DVD disc OPEN/CLOSE OPEN/CLOSE unit unit...
  • Page 67 DPS-5.5 3 7 63 1515 0 ADJUSTMENT OF MECHANISM-4 5. MECHANISM ADJUSTMENT Tangential and Radial Height Coarse Adjustment START Cautions: Remove the Loading Mecha. Assy. Because there is not a Spacer for height adjustment in Remove a Spacer for height adjustment adjustment after the second time, will keep it at need.
  • Page 68 DPS-5.5 3 7 63 1515 0 ADJUSTMENT OF MECHANISM-5 DVD Jitter Adjustment Playback method of inner and outer address for the purpose is refererd to "TEST MODE". Jitter indication of the monitor is refererd to "DISPLAY SPECIFICATION OF THE TEST MODE".
  • Page 69 DPS-5.5 3 7 63 1515 0 ADJUSTMENT OF MECHANISM-6 Initialize the Focus Sweep Setting Purpose: To set the sweep which was correct with the individual Traverse mechanism. Push the power switch CLEAR STANDBY/ON Note: Be sure to perform this step when replaced the Pickup or Traverse mechanism.
  • Page 70 DPS-5.5 3 7 63 1515 0 ADJUSTMENT OF MECHANISM-7 Self-diagnosis functions of pickup Setting the test mode. Press "RETURN" and "SETUP/TV/VCR" key of remote controller RC-484M. RC-484M 1. Set a TEST MODE by the RC-484M. 2. When diagnosis 650nm (laser diode), 3.
  • Page 71 DPS-5.5 3 7 63 1515 0 ADJUSTMENT OF MECHANISM-8 DISPLAY SPECIFICATION OF THE TEST MODE Character in bold : Item name : Information display Address indication Disc sensing [DSC - The address being traced is displayed in number. The type of discs loaded is displayed.
  • Page 72 3 7 63 1515 0 UPGRADE FIRMWARE-1 HOME MENU Confirm the Regional code and Firmware version. 1. Connect the TV monitor to the DPS-5.5. Audio Settings Video Adjust 2.Turn ON the power switch and standby switch ON. (No Disc) 3. Press the "SETUP" key on the front panel.
  • Page 73 Using for Window tool 6. Connect the JIG (0J13), FFC and connection cable (RS-232C straight type). 7. Turn the power switch and standby "ON" of the DPS-5.5. Writing the firmware as below. No disc condition. 8. Press the start key.
  • Page 74 DPS-5.5 3 7 63 1515 0 ID NUMBER AND DATA SETTING Caution: It is necessory to enter individual ID number and ID data to each player when you repair it. Note: When previous ID number and ID data, such as a factory present ID number and ID data, are maintained, the unit enters ID Number Confirmation Mode when the above keys are pressed.
  • Page 75 http://www.xiaoyu163.com DPS-5.4 3 7 63 1515 0 ID NUMBER AND DATA SETTING TV monitor : ID DATA Input Mode [Player's ID Number Setting] [ Remote controller RC-484M ID Number ? > 0 0 1 5 1 * * * * 1.
  • Page 76 DPS-5.5 3 7 63 1515 0 PACKING VIEW A901 A905 RC-536DV A530 A906 A911 A903 A902 Tape A601 P981 A605 A601 A604 L 13942296513 A607 A451 A450 A455 u163 http://www.xiaoyu163.com...

  • Page 77: Exploded View Parts List

    28141542 COVER L 13942296513 F PANEL DPS-5.5(B) 27212663 BADGE 28135278 FACET 28198906 SCREW 3TTB+8B(BC) 838430088 FPANEL REAR PANEL DPS-5.5 MUD1N 27123294 <MUD1N> N REAR PANEL DPS-5.5 MUA4P 27123295 <MUA4P> N SCREW 3TTB+8B(BC) 838430088 REARPANEL SCREW 4TTB+8C(BC) 838440089 AC INLET FUSE 1.6A-T/UL-ST2...
  • Page 78 Power supply unit NGPS-0041-100-240V 24150041 <MUA4P> ! ! : Safety mark N : New parts <MUD1N> : North American area <MUP4P> : Australian area PACKING PARTS LIST DPS-5.5 REF. NO. PART NAME DESCRIPTION PART NO. REMARK A450 CARTON DPS-5.5MDD 29054217...
  • Page 79 PRINTED CIRCUIT BOARD PARTS LIST DPS-5.5 U1 : OUTPUT TERMINAL PC BOARD NAAR-7997 3 7 63 1515 0 UNIT NO. CIRCUIT NO. PART NAME DESCRIPTION PART NO. REMARK AR-7997 C101 C-CERA C CK725F1E-104Z1 332161040R1 AR-7997 C221 VR C CE04W6.3V-470M(VR)
  • Page 80 http://www.xiaoyu163.com AR-7997 C903 C-CERA C CK725F1E-104Z1 332161040R1 AR-7997 C904 VR C CE04W6.3V-220M(VR) 394622217 3 7 63 1515 0 AR-7997 C905 C-CERA C CK725F1E-104Z1 332161040R1 AR-7997 C906 VR C CE04W16V-220M(VR) 394642217 AR-7997 C907 C-CERA C CK725F1E-104Z1 332161040R1 AR-7997 C908 VR C CE04W16V-1000M(VR) 394641027 AR-7997...
  • Page 81 http://www.xiaoyu163.com AR-7997 P002 NCDIS-7998 25137998 AR-7997 P003 NCDIS-7999 25137999 3 7 63 1515 0 AR-7997 P004 NCSW-8000 25138000 AR-7997 P006 NCPS-8002 25138002 AR-7997 P007 NCETC-8003 25138003 AR-7997 P009 NCETC-8005 25138005 AR-7997 P104 SOCKET NSCT-7P2241 25052344 AR-7997 P104 or SOCKET NSCT-7P1676 25051889 AR-7997 P104 or...
  • Page 82 http://www.xiaoyu163.com AR-7997 R1005 C-CARBON R RN72K1J-000JE 435030004R1 AR-7997 R1006 C-CARBON R RN72K1J-000JE 435030004R1 3 7 63 1515 0 AR-7997 R1007 C-CARBON R RN72K1J-000JE 435030004R1 AR-7997 R1008 C-CARBON R RN72K1J-000JE 435030004R1 AR-7997 R1009 C-CARBON R RN72K1J-000JE 435030004R1 AR-7997 R101 C-CARBON R RN72K1J-103JE 435031034R1 AR-7997...
  • Page 83 http://www.xiaoyu163.com AR-7997 R235 C-CARBON R RN72K1J-000JE 435030004R1 AR-7997 R236 C-CARBON R RN72K1J-000JE 435030004R1 3 7 63 1515 0 AR-7997 R241 C-CARBON R RN72K1J-000JE 435030004R1 AR-7997 R242 C-CARBON R RN72K1J-000JE 435030004R1 AR-7997 R243 C-CARBON R RN72K1J-000JE 435030004R1 AR-7997 R244 C-CARBON R RN72K1J-750JE 435037504R1 AR-7997...
  • Page 84 http://www.xiaoyu163.com AR-7997 R433 C-CARBON R RN72K1J-101JE 435031014R1 AR-7997 R434 C-CARBON R RN72K1J-101JE 435031014R1 3 7 63 1515 0 AR-7997 R441 C-CARBON R RN72K1J-104JE 435031044R1 AR-7997 R442 C-CARBON R RN72K1J-104JE 435031044R1 AR-7997 R443 C-CARBON R RN72K1J-271JE 435032714R1 AR-7997 R444 C-CARBON R RN72K1J-271JE 435032714R1 AR-7997...
  • Page 85 http://www.xiaoyu163.com DIS-7998 Q702 FL TUBE HNV-13SS12T 212238 DIS-7998 Q702A CUSHION t3*10*25 28141513 3 7 63 1515 0 DIS-7998 Q703 S-80130CLMC-JIP-T2 22241924R2 DIS-7998 Q704 KRA103S 2216230R2 DIS-7998 Q704 or RN2403 2214540R2 DIS-7998 Q705 REMO SENS RPM7138-H9 241348 DIS-7998 R701 C-CARBON R RN72K1J-103JE 435031034R1 DIS-7998 R702...
  • Page 86 http://www.xiaoyu163.com DIS-7998 R764 C-CARBON R RN72K1J-392JE 435033924R1 DIS-7998 R765 C-CARBON R RN72K1J-103JE 435031034R1 3 7 63 1515 0 DIS-7998 R766 C-CARBON R RN72K1J-272JE 435032724R1 DIS-7998 R767 C-CARBON R RN72K1J-391JE 435033914R1 DIS-7998 R768 C-CARBON R RN72K1J-471JE 435034714R1 DIS-7998 R769 C-CARBON R RN72K1J-821JE 435038214R1 DIS-7998 R770...
  • Page 87 http://www.xiaoyu163.com PS-8002 P982A CRIMP AS CRIMP AS 2069943301UL PS-8002 P982B SOCKET AS NSAS-2P0921 2009990661UL 3 7 63 1515 0 U7 : RS-232 TERMINAL PC BOARD NAETC-8005 UNIT NO. CIRCUIT NO. PART NAME DESCRIPTION PART NO. REMARK ETC-8005 C801 VR C CE04W50V-1M(VR) 394680107 ETC-8005 C802...
  • Page 88 DPS-5.5 3 7 63 1515 0 L 13942296513 Integra Division of ONKYO CORPORATION Sales & Product Planning Div. : 2-1, Nisshin-cho, Neyagawa-shi, OSAKA 572-8540, JAPAN Tel: 072-831-8023 Fax: 072-831-8124 http://www.onkyo.com/jp/ Integra Division of ONKYO U.S.A. CORPORATION 18 Park Way, Upper Saddle River, N.J. 07458, U.S.A.

This manual is also suitable for:

Dps-5.5 b mud1nDps-5.5 b mup4p

Table of Contents