Listing And Code Approvals; Appliance Certification; Btu & Efficiency Specifications; Mobile Home Approved (Usa Only) - Quadra-Fire EXPLRMED-PBK Owner's Manual

1

Listing and Code Approvals

A. Appliance Certification
Model: Explorer II Wood Stove
Laboratory:
Intertek
Report No & Date:
10126132PRT
Type: Safety
Standard: UL 1482-07; ULC S627-00
NOTE: This installation must conform with local codes. In the
absence of local codes you must comply with the UL1482-07, (UM)
84-HUD and NPFA211 in the U.S.A. and the ULC S627-00 and
CAN/CSA-B365 Installation Codes in Canada. NOT APPROVED
FOR MOBILE HOME INSTALLATIONS IN CANADA!
B. BTU & Efficiency Specifications
EPA Certification #: 925
EPA Certified Emissions: 2.2 grams per hour
*LHV Tested Efficiency: 78.3 %
**HHV Tested Efficiency: 72.4 %
***EPA BTU Output: 11,200 to 35,900 / hr.
****Peak BTU/Hour Output: 61,000
Vent Size: 6 inches
Firebox Size: 2.42 cubic feet
Maximum Wood Length: 20 inches
Ideal Wood Length: 18 inches
* Weighted average LHV efficiency using Douglas Fir dimension-
al lumber and data collected during EPA emissions test.
**Weighted average HHV efficiency using Douglas Fir dimen-
sional lumber and data collected during EPA emissions test.
***A range of BTU outputs based on EPA Default Efficiency and
the burn rates from the low and high EPA tests, using Douglas
Fir dimensional lumber.
****A peak BTU out of the unit calculated using the maximum first
hour burn rate from the High EPA Test and the BTU content of
cordwood (8600) times the efficiency.
The Quadra-Fire Explorer Series Wood Stove (ACC) meets
the U.S. Environmental Protection Agency's crib wood emis-
sion limits for wood heaters sold after May 15, 2015.
This wood heater needs periodic inspection and repair for
proper operation. It is against federal regulations to operate
this wood heater in a manner inconsistent with operating
instructions in this manual.
August 21, 2015
Fuel Seasoned Cord Wood
C. Mobile Home Approved (USA ONLY)
• This appliance is approved for mobile home installa-
tions in the USA when not installed in a sleeping room
and when an outside combustion air inlet is provided.
• The structural integrity of the mobile home floor, ceil-
ing, and walls must be maintained.
• The appliance must be properly grounded to the frame
of the mobile home with #8 copper ground wire, and
chimney must be listed to UL103 HT or a listed UL-
1777 full length six inch (152mm) diameter liner must
be used.
• Outside Air Kit, part OAK-ACC must be installed in a
mobile home installation.
D. Glass Specifications
This stove is equipped with 5mm ceramic glass. Replace
glass only with 5mm ceramic glass. Please contact your
dealer for replacement glass.
Fire Risk.
Hearth & Home Technologies disclaims any
responsibility for, and the warranty will be
voided by, the following actions:
• Installation and use of any damaged appliance.
• Modification of the appliance.
• Installation other than as instructed by Hearth & Home
Technologies.
• Installation and/or use of any component part not approved by
Hearth & Home Technologies.
• Operating appliance without fully assembling all components.
• Operating appliance without legs attached (if supplied with unit).
• Do NOT Overfire - If appliance or chimney connector glows,
you are overfiring.
Any such action that may cause a fire hazard.
Improper installation, adjustment, alteration, service or
maintenance can cause injury or property damage.
For assistance or additional information, consult a qualified
installer, service agency or your dealer.
NOTE: Hearth & Home Technologies, manufacturer of
this appliance, reserves the right to alter its products, their
specifications and/or price without notice.
Quadra-Fire is a registered trademark of Hearth & Home
Technologies.
7061-196F
Explorer II Medium Wood Stove
WARNING
7