Blaze BLZ-3NG Use & Care Manual
  1. Manuals
  2. Brands
  3. Blaze Manuals
  4. Grill
  5. BLZ-3-NG
  6. Use & care manual

Blaze BLZ-3NG Use & Care Manual

Hide thumbs Also See for BLZ-3NG:
Table of Contents

Advertisement

Quick Links

See also: Owner's Manual
GAS GRILLS BLZ-3(NG/LP), BLZ-4(NG/LP), BLZ-5(NG/LP)
DANGER
- IF YOU SMELL GAS:
I) Shut off the gas supply to the appliance at its source.
2) Extinguish any open flames.
3) Open grill hood to release any accumulation of gas
vapor.
4) If a gas odor persists, Keep aw ay from your
appliance and contact your gas supplier or fire
department immediately.
ATTENTION:
INSTALLER: PLEASE LEAVE THESE INSTRUCTIONS WITH THE CONSUMER.
CONSUMER: PLEASE READ & RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE AND BEFORE
INSTALLING OR OPERATING.
Blaze Outdoor Products: 6620 Greenwell Springs Rd, Baton Rouge, LA
Version 1.6
USE & CARE GUIDE
- CONTACT INFORMATION -
70805 USA Phone: 866-976-9510 email:
CustomerService@BlazeGrills.com BLAZEGRILLS.COM
Blaze Outdoor Products Instructional Book
WARNING
I) Do not store or use gasoline or other flammable
liquids or vapor in the vicinity of this or any other
appliance
2) A LP cylinder not connected for use shall not be
stored in the vicinity of this or any other appliances.
Page | 1

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the BLZ-3NG and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Blaze BLZ-3NG

Summary of Contents for Blaze BLZ-3NG

  • Page 1 CONSUMER: PLEASE READ & RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE AND BEFORE INSTALLING OR OPERATING. - CONTACT INFORMATION - Blaze Outdoor Products: 6620 Greenwell Springs Rd, Baton Rouge, LA 70805 USA Phone: 866-976-9510 email: CustomerService@BlazeGrills.com BLAZEGRILLS.COM Blaze Outdoor Products Instructional Book Page | 1 Version 1.6...

  • Page 2: Table Of Contents

    Outdoor Kitchen Ventilation 23-25 ii. Building BBQ Specifications + Instruction Diagrams 26-27 VII. First Time Operation i. Lighting the Appliance ii. Manually Lighting the Appliance 29-30 iii. Flame Adjustment Blaze Outdoor Products Instructional Book Page | 2 Version 1.6...
  • Page 3 Infrared Burner Cleaning Fuel Conversion i. Gas Regulator 34-35 Main Burner iii. Rear Burner XI. Warranty Registration XII. Grill Parts 38-39 XIII. Product Serial Number XIV. Blaze Product Registration Blaze Outdoor Products Instructional Book Page | 3 Version 1.6...
  • Page 4 THIS MANUAL APPLIES TO THE FOLLOWING BLAZE GRILLS: Model: BLZ-3LP / BLZ-3NG 3 BURNER Model: BLZ-4LP / BLZ-4NG 4 BURNER Cutout Dimensions 23 1/4”W x 21 1/4”D x 8 1/2”H Cutout Dimensions 30 5/8”W x 21 1/4”D x 8 1/2”H...
  • Page 5 *1 Year – Ignition components and all other components *Appliances must be registered w ithin 30 days of purchase to validate this w arranty. *See w arranty section for details. Blaze Outdoor Products Instructional Book Page | 5 Version 1.6...

  • Page 6: Bbq Specifications

    BBQ SPECIFICATIONS NOTE: ALWAYS have equipment measured by Contractor before beginning any project. Blaze Outdoor Products Instructional Book Page | 6 Version 1.6...

  • Page 7: General Safety And Installation Warnings

    General Safety and Installation Warnings Safe operation of the BLAZE GRILL depends upon its proper installation. Only a qualified professional installer and service technician must perform adjustments and service of the grill. Proper location and proper use is essential to insure safe and continued trouble-free operation.
  • Page 8 “T” handle type manual gas valve must be installed in the gas supply line to this appliance. This applies to permanently installed natural gas and propane installations. This does not apply to propane portable installations using a 20 pound tank. Blaze Outdoor Products Instructional Book Page | 8 Version 1.6...
  • Page 9 Although an obstructed burner tube not the only cause “FLASH-BACK” it is the most common cause, and frequent inspection and cleaning of the burner tubes is necessary. Blaze Outdoor Products Instructional Book Page | 9...

  • Page 10: Location Of Appliance

    This outdoor cooking gas appliance is not approved to be installed in or on any recreational vehicles and /or boats. Blaze Grills are for single family/residential use only. When determining a suitable location take into account concerns such as exposure to wind, proximity to traffic paths and keeping any gas supply lines as short as possible.
  • Page 11 Do not locate the BLAZE GRILL where an overhang or awning may cover it.  DO NOT obstruct the flow of combustion and ventilation air to this appliance  Keep any electrical supply cords and the fuel supply hoses away from any heated surfaces and/or sharp and aggressive edges.
  • Page 12 Do not leave the appliance unattended while in use.  Do not use water on grease fires! A violent steam explosion may result. Instead, smother the fire with a multipurpose ABC extinguisher. Blaze Outdoor Products Instructional Book Page | 12 Version 1.6...

  • Page 13: Electrical Safety And Installation Warnings

    This appliance conforms to all uniform electrical safety codes and electrical grounding regulations. Install unit according to I.A.W. local codes or with National Electrical Code ANSI/NFPA 70 or CSA C22.1 in their absence. Blaze Outdoor Products Instructional Book Page | 13 Version 1.6...

  • Page 14: Gas Safety And Installation Warnings

    CHECK TO ENSURE THAT THE GAS SUPPLY HOSE DOES NOT COME IN CONTACT WITH ANY HOT SURFACE, SHARP OR ROUGH EDGES OF THE GRILL OR OUTDOOR KITCHEN CONSTRUCTION. DO NOT KINK THE GAS LINE WHEN INSTALLING. Blaze Outdoor Products Instructional Book Page | 14 Version 1.6...
  • Page 15 WARNING: DO NOT USE OPEN FLAME TO CHECK FOR LEAKS. USE OF AN OPEN FLAME COULD RESULT IN A FIRE, EXPLOSION AND BODILY HARM. DO NOT SMOKE WHILE PERFORMING THE LEAK TEST. Any Open Flame will Ignite the gas. Blaze Outdoor Products Instructional Book Page | 15 Version 1.6...

  • Page 16: Checking For Gas Leaks

    Check to ensure that flexible hoses do not have any cuts and wear that may affect the safety before each use. Only the factory supplied hose and regulator must be used. Use only replacement regulator and hose assemblies specified by BLAZE OUTDOOR PRODUCTS. Checking for Gas Leaks Perform a leak test before each use.

  • Page 17: Leak Testing

    Ensure the leak test includes all valves, pipe connections, joints, lines and every point from the gas source to the burners. NEVER USE AN OPEN FLAME TO CHECK FOR LEAKS. Blaze Outdoor Products Instructional Book Page | 17 Version 1.6...

  • Page 18: Unpacking Unit

    Your Blaze Series Appliance comes pre-assembled and requires very little setup. We do however; recommend the use of professional help during the installation of your unit as improper installation may affect your warranty.

  • Page 19: Gas Connections

    An installer supplied gas shutoff valve must be installed in an accessible place. Liquid Propane (LP) Gas and Tank Requirement  If your BLAZE Grill is for a Liquid Propane application, a L.P regulator set for 11” WC must be used and is for use with L.P. gas only. ...

  • Page 20: Transporting And Storing Lp Gas

    3/4” open wrench. Do not apply pipe sealant. (These are flared fittings). Note: remember the rubber line on the hose and regulator must be protected from sharp edges, hot surfaces, aggressive Blaze Outdoor Products Instructional Book Page | 20...
  • Page 21 6. To disconnect after you have used the appliance, turn the burner knobs to the OFF position. 7. Close the Cylinder Valve by turning the Hand Wheel counter-clockwise until it stops. 8. Disconnect the regulator from the LP cylinder after use. Blaze Outdoor Products Instructional Book Page | 21 Version 1.6...

  • Page 22: Installing The Appliance In A Bbq Island

    This can back up the heat behind the control panel potentially creating a gas leak, damage to the product, and injury. A wind block behind the grill may be necessary. Blaze Outdoor Products Instructional Book Page | 22 Version 1.6...

  • Page 23: Outdoor Kitchen Ventilation

    (picture shown in owner’s manual), and both the cabinets containing the gas appliances and the gas tank should be ventilated appropriately. If a plenum wall is undesirable, Blaze offers a Propane tank drawer as an alternative. Blaze Outdoor Products Instructional Book Page | 23 Version 1.6...
  • Page 24 These are not the only possible options for venting but instead simply some examples of the more common configurations found. Notice the middle set of vents being positioned lower on the island cavity for LP gas. Blaze Outdoor Products Instructional Book Page | 24 Version 1.6...
  • Page 25 Check to make sure the appliance is level and is supported around the entire outside edge. If the appliance is not level or is unstable, use non-combustible shims under the outside lip to stabilize it. Perform the leak test procedure as described earlier in this manual. Blaze Outdoor Products Instructional Book Page | 25 Version 1.6...

  • Page 26: Building Bbq Specifications + Instruction Diagrams

    (such as a combustible wall) be located behind the grill that the needed 5” for lid clearance doesn’t satisfy the distance required from a combustible surface. Blaze Outdoor Products Instructional Book Page | 26 Version 1.6...
  • Page 27 Installation Diagram (5 Gallon LP tank shown) Installation Method for Low Pressure Gas Source- ( Natural Gas Regulator shown ) Blaze Outdoor Products Instructional Book Page | 27 Version 1.6...

  • Page 28: First Time Operation

    To ignite burners, push the burner knob in and slowly rotate counter-clockwise to the high position. You will hear a loud click as the electronic lighter produces a spark. Listen for the sound of the gas Blaze Outdoor Products Instructional Book Page | 28...

  • Page 29: Manually Lighting The Appliance

    Hold your open flame to the top of the Lighting Tube. See below picture. Push in and turn the control knob to HIGH. Blaze Outdoor Products Instructional Book Page | 29 Version 1.6...
  • Page 30 6. Wait five minutes until the gas clears before attempting to light it again. 7. If the burner does not light after several attempts, immediately close all gas valves and consult an authorized service technician. Blaze Outdoor Products Instructional Book Page | 30 Version 1.6...

  • Page 31: Flame Adjustment

    After the first use, it is normal for your appliance to become discolored in certain areas from the heat produced by the burners. A video for cleaning your grill is located on the blaze website to assist with the below instructions, www.blazegrills.com...
  • Page 32 Failure to meet these conditions can cause dangerous conditions that can cause personal injury and/or property damage. Blaze Outdoor Products Instructional Book Page | 32...

  • Page 33: Optional Infrared Sear Burner

    Optional Infrared Sear Burner How to Replace Conventional Burner with Infrared Sear Burner (A video for installing the infrared sear burner is located on the blaze website to assist with the below instructions, www.blazegrills.com 1. To install the optional infrared burner, begin by removing the far left cooking grid, flame stabilizing grid and zone divider.

  • Page 34: Fuel Conversion

    Fuel Conversion A video converting your blaze grill is located on the blaze website to assist with the below instructions, www.blazegrills.com Gas Regulator : Currently all Natural gas grills are supplied with a regulator which is appropriate for use with Natural Gas or Propane.
  • Page 35 Blaze Outdoor Products Instructional Book Page | Version 1.6...

  • Page 36: Main Burner

    Rear Burner For the Blaze 4 & 5 Burner, replace the back burner orifice by removing the plate on the rear of the BBQ and carefully removing the fitting. Replace with the provided conversion back burner orifice – large brass fitting (differs from small BBQ burner orifice).

  • Page 37: Warranty Registration

    Warranty Registration If you have purchased a Blaze Series Grill you must register your product w ithin 30 days of purchase to validate the w arranty and maintain your original receipt to get parts for the appliance. You may register your appliance at blazegrills.com by selecting Support, and then selecting Register your Product.

  • Page 38: Grill Parts

    BLZ-32-057 Rear Burner Orifice LP BLZ-32-054 Valve Grommet BLZ-32-053 Rotis Ignitor Cover BLZ-32-016 Rear Burner Orifice Elbow BLZ-32-080 Burner Cotter Pin BLZ-32-074 Burner Air Shutters BLZ-32-040 Peg for Flame Tamer BLZ-32-061 Blaze Outdoor Products Instructional Book Page | Version 1.6...
  • Page 39 BLAZE 3 Burner BLAZE 4 & 5 Burner Note: Add one burner, one flame tamer, one heat separator and one grid for the Blaze 5 Burner. Blaze Outdoor Products Instructional Book Page | Version 1.6...

  • Page 40: Product Serial Number

    Locating the Product Serial Number: The serial number for your BLAZE appliance is located on the left hand out s ide of the Firebox (see picture on page 14.) You will need this number to properly register your appliance and activate coverage. Write this...

  • Page 41: Blaze Product Registration

    Please take a minute to let us know what you bought. This makes sure we keep you up to date and have your info ready if you ever need warranty help! You may register your product electronically on the blaze website vs mailing in the below paperwork, blazegrills.com.

This manual is also suitable for:

Blz-4ngBlz-4lpBlz-5ngBlz-3lpBlz-5lp

Table of Contents