Summary of Contents for Star Micronics TSP700 Series
Page 1
THERMAL PRINTER TSP700 Series TECHNICAL MANUAL [ FIRST EDITION ]...
Page 2
NOTICE • All rights reserved. Reproduction of any part of this manual in any form whatsoever, without STAR’s express permission is forbid- den. • The contents of this manual are subject to change without notice. • All efforts have been made to ensure the accuracy of the contents of this manual at the time of going to press.
Page 3
INTRODUCTION This manual describes the thermal printer TSP700 series. It is designed for use as a reference for periodic inspections and maintenance procedures to be executed by service personnel. It is not intended for the general user. Users of this manual should have a basic knowledge and understanding of the English language.
CHAPTER 1 PARTS REPLACEMENT This chapter explains disassembly and reassembly of the printer. Note the following precautions during disassembly and reassembly. Disconnect the printer power cord plug from the wall outlet before servicing it. Assembly is the reverse of disassembly unless otherwise specified. After reassembly, coat the screw heads with locking sealant.
PARTS REPLACEMENT Lower Case Unit Turn off the power switch 1, disconnect the power cord from the wall outlet. Remove • Two tapping screws 2 • Two tapping screws 3 • Lower case unit 4 Upper Case Unit Turn off the power switch1, disconnect the power cord from the wall outlet.
PARTS REPLACEMENT Board Chassis Unit Turn off the power switch1, disconnect the power cord from the wall outlet. Remove • Upper case according to the procedure described in item 2. • Three screws 2 • Screw 3 • Screw 4 •...
PARTS REPLACEMENT Platen Unit Turn off the power switch, disconnect the power cord from the wall outlet. Push the cover open lever 1, and open the printer cover 2. Remove • Stop ring 3 • Bearing 4 • Platen unit 5 Paper Feed Motor Turn off the power switch, disconnect the power cord from the wall outlet.
Page 11
CHAPTER 2 MAINTENANCE AND LUBRICATION Maintenance......................1-1. Cleaning ........................9 1-2. Checks ........................9 Lubrication ......................10 2-1. Type of oil ......................10 2-2. Lubrication method ....................10 2-3. Lubrication locations ................... 10...
MAINTENANCE AND LUBRICATION Maintenance Carry out maintenance control items listed below to maintain the original performance of this printer and prevent trouble from occurring. 1-1. Cleaning Removal of dirt. Clean the dirt with tissure or soft cloth. Note: Do not use thinners or trichlene/ketone base solvents for cleaning as they can damage plastic parts. Be careful not to damage electrical parts, wired areas or mechanisms and avoid getting them wet.
Page 14
MAINTENANCE AND LUBRICATION Lubrication Lubrication is extremely important for preserving the original performance of the printer over a long period of time. 2-1. Type of oil The type of oil used has a major influence on the performance and durability of the printer.You should pay particular attention to the cold temperature properties of the oil.
Page 15
MAINTENANCE AND LUBRICATION Fig. 2-1 Lubricated Area – 11 –...
Page 17
CHAPTER 3 PARTS LIST HOW TO USE PARTS LIST DRWG. NO. This column shows the drawing number of the illustration. REVISED EDITION MARK This column shows a revision number. PART NO. Parts numbers must be notified when ordering replacement parts. Parts described as “NPN” have no parts number and are not in stock, i.e., unavailable.
3-1-2. Parts List Printer Assembly DRWG.NO. REV. PARTS NO. PARTS NAME Q'TY REMARKS RANK 37450030 LOWER CASE UNIT TSP7 BOARD CHASSIS TSP7 30970040 THERMAL ROLL PAPER 80X35D 37457020 MAIN LOGIC BOARD UNIT TSP7 37457210 SUB-BOARD UNIT TSP7 38440000 TMP743-24 37451030 UPPER CASE UNIT TSP7 39607200 INTERFACE BOARD IFBD-HD03 OPTION:SERIAL 25 PIN...
3-2-2. Parts List Printer Mechanism DRWG.NO. REV. PARTS NO. PARTS NAME Q'TY REMARKS RANK WIRE 26UL1007BLK060TT 33215020 BEARING TMP8 COVER A TMP7 30903040 CUTTER UNIT ORC-RSY90 PAPER GUIDE B TMP7 PAPER GUIDE A TMP7 PE DETECTOR COVER UNIT TMP8 PE DETECTOR UNIT TMP8 37463110 PLATEN UNIT TMP7...
Page 22
Printer Mechanism DRWG.NO. REV. PARTS NO. PARTS NAME Q'TY REMARKS RANK SPRING E043-035-0164 SPRING E050-032-0141 SPRING C068-050-0065 SPRING C075-060-0300 SPRING C075-070-0238 CAUTION SEAL TMP8 PAPER SET SEAL TMP8 WIRE 18UL1007BLK245TT 30903030 STATIONARY KNIFE ORC-RSY90 02841000 CUT WASHER 4.1X6.5X0.5 02852000 CUT WASHER 5.2X8.0X0.5 –...
3-3. Sub-Assembly 3-3-1. Cover Open Lever Unit DRWG.NO. REV. PARTS NO. PARTS NAME Q'TY REMARKS RANK 28-1 SCREW TAT 2-4 28-2 STOP RING SE2.0 28-3 SPRING E038-030-0142 28-4 SHAFT A TMP7 28-5 LEVER PLATE TMP8 28-6 COVER OPEN LEVER TMP8 –...
3-3-2. Head Unit DRWG.NO. REV. PARTS NO. PARTS NAME Q'TY REMARKS RANK 29-1 00926403 SCREW TAT 2.6-4 CT 29-2 01903030 SCREW TR 3-4 FL 29-3 HEAD EARTH PLATE TMP7 29-4 WIRE 18UL1007BRN145TT 29-5 30905050 THERMAL HEAD AE080-H8E801 29-6 31210000 COLLAR TMP8 29-7 HEAD PLATE...
3-5-2. Parts List Main Logic Board DRWG.NO. REV. PARTS NO. PARTS NAME Q'TY REMARKS RANK CERA.CAPA.CHIP1608 0.22UF 10V NOT MOUNTED C03-06 CERA.CAPA.CHIP1608 0.022UF 50V C07-09 NOT MOUNTED C11-19 NOT MOUNTED C21-22 NOT MOUNTED C31-32 NOT MOUNTED CHEM. CAPA. 47UF C34-35 NOT MOUNTED CERA.CAPA.CHIP1608 3900PF 50V NOT MOUNTED...
Page 32
Main Logic Board DRWG.NO. REV. PARTS NO. PARTS NAME Q'TY REMARKS RANK JP1A CHIP RESISTOR 0 OHM 1/16W JP1B NOT MOUNTED NOT MOUNTED LED1-2 LED CHIP LT1E40A* LED3 LED CHIP LT1D40A* R101 CHIP RESISTOR 1.5 KOHM 1/16W R102 CHIP RESISTOR 10 K-OHM 1/16W R103 CHIP RESISTOR 2.2 K-OHM 1/16W R104...
Page 33
Main Logic Board DRWG.NO. REV. PARTS NO. PARTS NAME Q'TY REMARKS RANK R301-305 CHIP RESISTOR 100 K-OHM 1/16W R306 NOT MOUNTED R307-308 CHIP RESISTOR 100 K-OHM 1/16W R310 NOT MOUNTED R311-312 CHIP RESISTOR 330 OHM 1/16W R313-314 CHIP RESISTOR 10 K-OHM 1/16W R315 CHIP RESISTOR 4.7 K-OHM 1/16W R316...
3-10-2. Parts List Parallel Interface Board DRWG.NO. REV. PARTS NO. PARTS NAME Q'TY REMARKS RANK BC1-3 CERA.CAPA.CHIP1608 0.022UF 50V NOT MOUNTED CERA.CAPA.CHIP1608 1000PF 50V C3-4 NOT MOUNTED CHEM. CAPA. CONNECTOR PHEC40P-R111 CONNECTOR 57RE40360-730BD29 08211030 TTL IC HD74LS374FP*EL TTL IC 74ALS32FP*EL 08210126 TTL IC 74LS05FP*EL L1-2 CHIP RESISTOR...
Page 43
ELECTRONIC PRODUCTS DIVISION OVERSEAS SUBSIDIARY COMPANIES STAR MICRONICS U.K. LTD. STAR MICRONICS CO., LTD. STAR MICRONICS AMERICA, INC. Star House, Peregrine Business 536 Nanatsushinya, 1150 King Georges Post Road, Edison, Park, Gomm Road, High Wycombe, Shimizu, Shizuoka, 424-0066 Japan NJ 08837-3729 U.S.A.