Advertisement
http://www.chromalox.com
ELECRIC SHOCK HAZARD. Disconnect all power
before servicing or replacing heating elements.
The reflectors should be kept clean to obtain the maximum
radiant output.
Element Replacement
1. Remove Terminal Box Cover.
2. Disconnect lead wires from heater terminals.
3. Remove safety grills (if installed).
4. Remove retainer screw located on the reflector at the terminal end.
5. Loosen (2), 3/8" nuts from the terminal box bracket located on
the back of the heater and slide the entire heating element
assembly out of the reflector assembly.
Model
STAR-02A-11-PC
STAR-02A-81-P
STAR-06A-83-P
STAR-02A-21-P
STAR-06A-23-P
STAR-02A-71-P
STAR-06A-71-P
STAR-02A-41-P
STAR-06A-43-P
STAR-02A-61-P
STAR-06A-63-P
STAR-05A-81-P
STAR-14A-83-P
STAR-05A-21-P
STAR-14A-23-P
STAR-05A-71-P
STAR-14A-71-P
STAR-05A-41-P
STAR-14A-43-P
STAR-05A-61-P
STAR-14A-63-P
*** Includes element supports
Parts Common to All Models:
Bulkhead fitting gasket . . . . . . . . . . . . . . 132-895735-008
Bulkhead fitting washer . . . . . . . . . . . . . . 328-890675-014
Bulkhead fitting nut . . . . . . . . . . . . . . . . . 200-890615-031
Element Support . . . . . . . . . . . . . . . . . . . . 291-304869-002
Vinyl Grip . . . . . . . . . . . . . . . . . . . . . . . . 024-304894-001
MAINTENANCE
RENEWAL PARTS IDENTIFICATION
Element Housing
Element***
Reflector
PCN 106059
PCN 106067
PCN 106075
234-891755-004
PCN 106083
PCN 106091
PCN 106104
PCN 106403
PCN 106411
234-891-755-002
PCN 106796
PCN 106964
PCN 106972
6. Remove wires and jumper straps as required to replace the
failed heating element(s).
7. Remove bulkhead fitting nuts and washers.
8. Remove failed element and replace with a new element.
Replace only with genuine Chromalox "Arctic End" ele-
ments. Use of other elements will cause excess temperatures
inside terminal box.
9. Place gasket on the bulkhead fitting and insert terminals and
fittings into the element holes in the terminal box.
10. Place washers and nuts on bulkhead fittings and tighten.
11. Replace wiring and jumper straps ( see Fig. 4).
12. Reassemble by following the reverse procedures (steps 5
through 1)
Safety Screen
PCN 111878
PCN 111878
PCN 340638
PCN 111878
PCN 340638
PCN 111878
PCN 340638
PCN 111878
PCN 340638
PCN 111878
PCN 340638
PCN 111894
PCN 340857
PCN 111894
PCN 340857
PCN 111894
PCN 340857
PCN 111894
PCN 340857
PCN 111894
PCN 340857
Parts Common to STAR, 06A-P and 14A-P Models:
Wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 333-557518-001
End Cap . . . . . . . . . . . . . . . . . . . . . . . . . . 039-510848-001
5
Terminal Box
Gasket
132-304879-004
132-304879-004
132-304879-003
132-304879-004
132-304879-003
132-304879-004
132-304879-003
132-304879-004
132-304879-003
132-304879-004
132-304879-003
132-304879-004
132-304879-003
132-304879-004
132-304879-003
132-304879-004
132-304879-003
132-304879-004
132-304879-003
132-304879-004
132-304879-003
Advertisement
