PERIODIC MAINTENANCE
Adjusting Propeller Shaft Alignment
The flexible engine mounts are compressed
slightly during initial engine operation and
may cause misalignment between the
engine and the propeller shaft.
After the first 50 hours of operation, the
alignment should be checked and
readjusted if necessary. This is considered
normal maintenance and the adjustment
requires specialized knowledge and
techniques. Consult your authorized
Yanmar Marine dealer or distributor.
56
Every 50 Hours of Operation
When completing the initial 50 hour
maintenance procedures, perform the
following procedures every 50 hours
thereafter or monthly, whichever comes
first.
• Draining Fuel Filter / Water Separator
• Checking Battery Electrolyte Level
Draining Fuel Filter / Water
Separator
WARNING! When removing any fuel
system component to perform
maintenance (such as changing the fuel
filter), put an approved container under
the opening to catch the fuel. NEVER
use a shop rag to catch the fuel. Vapors
from the rag are flammable and
explosive. Wipe up any spills
immediately. Wear eye protection. The
fuel system is under pressure and fuel
could spray out when removing any fuel
system component.
YM Series Operation Manual
© 2007 Yanmar Marine International