Storage; Troubleshooting - Gravely MINI-ZT 915054 Owner's/Operator's Manual

Short Term Storage
IMPORTANT: NEVER clean unit with
high-pressure water or store unit outdoors.
Remove all dirt, grease, leaves, etc. Store in
a clean dry area.
Inspect unit for signs of wear or damage.
Ensure all fasteners are properly tightened.
PROBLEM
1. Safety interlock system is not
2. Fuel tank empty.
3. Discharged battery.
Engine will
4. Poor connection between battery
not
crank/start.
5. Spark plug wire(s) loose or spark
6. Faulty electrical system.
7. Faulty engine.
1. Choke engaged.
Engine
2. Air filter cartridge plugged.
runs
rough.
3. Faulty engine.
1. The transmission bypass lever is
Unit does
not move
with engine
running 2. Faulty hydrostatic belt.
when using
steering
levers.
3. Faulty transmission.

STORAGE

TROUBLESHOOTING

PROBABLE CAUSE
engaged or is faulty.
and battery cables.
plug(s) faulty.
engaged.
Long Term Storage
Follow all instructions under Short Term
Storage.
Remove and fully charge battery. Store in a
clean dry area.
Drain fuel from fuel tank.
Refer to Engine Manual for the proper engine
storage procedures.
Touch up all scratched or chipped paint
surfaces.
1. Check safety interlock system
(see Safety Interlock System on
page 10).
2. Fill fuel tank (see FILLING FUEL
TANK on page 11).
3. Charge battery (see Charging the
Battery on page 19).
4. Tighten battery cables and/or
clean battery and battery cables
(see Cleaning Battery and Battery
Cables on page 18).
5. Connect spark plug wire(s) or
replace spark plug(s). Refer to
Engine Manual for detailed
instructions.
6. Contact your Gravely Dealer.
7. Contact your Gravely Dealer.
1. Disengage choke.
2. Clean or replace air filter
cartridge. Refer to Engine Manual
for detailed instructions.
3. Contact your Gravely Dealer.
1. Disengage transmission bypass
lever (see MOVING UNIT
MANUALLY on page 12).
2. Replace hydrostatic belt (see
REPLACING HYDROSTATIC
BELT on page 21).
3. Contact your Gravely Dealer.
GB - 22
CORRECTION