Page 1
MINI-ZT Owner/Operator Manual Models 915054 - 1540 915064 - 1534 915070 - 1534 ENGLISH FRANÇAIS ESPAÑOL Transfer Coller l’autocollant du modèle et du numéro de model & série dans cet encadré. serial num- ber label from Transferir aquí la etiqueta del product regis- modelo y número de serie del registro del producto.
INTRODUCTION THE MANUAL PRODUCT REGISTRATION Before operation of unit, carefully and The Gravely dealer must register the product completely read your manuals. The contents at the time of purchase. Registering the will provide you with an understanding of product will help the company process...
Before Attempting to Operate Your 5. Review Limited Warranty Policy. Unit: 6. Fill out a product registration card and return the card to the Gravely Company 1. Make sure all assembly has been or go to www.gravely.com. properly completed. 2. Understand all Safety Precautions DISCLAIMER provided in the manuals.
Page 4
077541 OE0050 Figure 2 1. Caution! Always stand clear of discharge • Maximum Tongue weight: 30 lbs. area. Do not direct discharge toward other people. • Maximum Trailer weight: 300 lbs. OL1810 • Do not use hitch with bagger attached. •...
6. Hot Surfaces! Do not operate mower unless bagger is attached or guards DO NOT touch parts which are are in operating position. hot from operation. ALWAYS OL1815 allow parts to cool. OL1801 5. Danger! To Avoid Serious Injury or Death 7.
Page 6
Avoid uneven or rough terrain. DO NOT Disengage PTO when attachment is not in operate near drop-offs, ditches, or use and when crossing gravel surfaces. embankments. Unit can suddenly turn over if DO NOT operate unit if safety interlock a wheel is over the edge of a cliff or ditch, or if system is damaged or disabled.
Page 7
Follow the manufacturer’s recommendations Explosive Gases from battery can cause for weight limits for towed equipment and death or serious injury. Poisonous battery towing on slopes. fluid contains sulfuric acid and its contact with skin, eyes or clothing can cause severe NEVER allow children or others in or on chemical burns.
Never store the machine or fuel container For extended storage, clean unit thoroughly. inside a building where there is an open See Engine Manual for proper storage. flame, such as a water heater. Use only attachments or accessories Shut off fuel (if provided) and allow engine to designed for your unit.
See figure 4 for all controls and features locations. Perform the following tests to ensure the safety interlock system is working properly. If the unit does not perform as stated contact your Gravely dealer for repairs. Test Steering Lever Parking Brake Engine...
NOTE: The steering levers must be in the FILLING FUEL TANK neutral position to start the engine. 1. Clean fuel cap and surrounding area to NOTE: The parking brake must be prevent dust, dirt, and debris from disengaged prior to moving the steering entering fuel tanks.
OPERATING MOWER 1. Start engine. 2. Set throttle lever to fast. IMPORTANT: Never engage PTO if mower is plugged with grass or other material. 3. Engage PTO to start mower blades. NOTE: The parking brake must be disengaged prior to moving the steering levers from the neutral lockout position.
Parking (see MOVING UNIT MANUALLY on page 12). Push unit. If unit Brake rolls, contact your Gravely Dealer. Clean Unit Clean engine, battery, seat, mower deck, etc. of all dirt and debris. Do not use solvents, hard cleaners, or abrasives.
Interval Task Action Check Keep battery and battery terminals clean (see Cleaning Battery Battery and Battery Cables on page 18). Lubricate Apply grease to zerk (1) on Unit each front wheel 25 Hours or Every Season Check Check mower blade mounting hardware and all other fasteners. 50 Hours Fasteners Replace fasteners that are missing or damaged.
Page 15
OPENING AND CLOSING HOOD To open, tip seat forward and pull up on the back of the hood. To close, put hood down and tip seat back (figure 10). MOWER DECK REMOVAL AND INSTALLATION Remove (Figure 11) 1. Remove PTO belt from electric clutch (see REPLACING PTO BELT on page 20).
Page 16
LEVELLING AND ADJUSTING The Forward Pitch Of The Mower Blades (Figure 13): PITCH OF MOWER DECK • Should be 0.0 in. (0.0 mm) to 1/4 in. NOTE: Adjust on a level surface, with the (6.35 mm) pitched forward. tires inflated to the correct air pressure (see SPECIFICATIONS on page 25).
Discard mower blade if (figure 17): Battery Removal and Installation • more than 1/2 in. (1.27 cm) of metal is Remove (Figure 18) removed. 1. Tip seat forward (see TIPPING SEAT • the air lift erosion area is eroded. FORWARD on page 14). •...
Page 19
OE0018 NOTE: Perform steps 1 and 2 for both Jump-Starting steering levers. Gravely does not recommend jump-starting 1. Remove mounting hardware and move your unit. Jump-starting can damage engine handlebar up or down until the steering and electrical system components. See your levers are at the appropriate height.
Page 20
Forward and Reverse Speed NOTE: The side the unit turns toward indicates that the wheel on that side is turning Adjustment slower than the other wheel. Either the wheel (Figure 20) that is turning faster needs to slow down or the wheel that is turning slower needs to be IMPORTANT: The unit should track within 2 sped up to allow the unit to travel in a straight...
1. Install PTO belt on electric clutch and 2. Disconnect Electric Clutch Connector mower deck. from PTO. 2. Pull idler arm towards outside of unit until CAUTION: Use care when releasing PTO belt can be routed around left idler spring tension. Keep body parts mower deck pulley.
5. Connect spark plug wire(s) or plug(s) faulty. replace spark plug(s). Refer to Engine Manual for detailed instructions. 6. Faulty electrical system. 6. Contact your Gravely Dealer. 7. Faulty engine. 7. Contact your Gravely Dealer. 1. Choke engaged. 1. Disengage choke. Engine 2.
Page 23
1. Operator presence switch not 1. Depress operator presence switch depressed. by sitting on seat. 2. Faulty operator presence switch. 2. Contact your Gravely Dealer. 3. Electric clutch connector is loose 3. Connect the electric clutch PTO or or disconnected.
SERVICE PARTS ACCESSORIES Be sure to always use genuine Gravely See your authorized Gravely dealer to add parts to keep your unit running like new. these optional accessories to your unit. Part No. Description Part no. Qty Description 51510000 Spindle Assembly...
SPECIFICATIONS Model Number 915070 915054 915064 Model 1534 1540 1534 Engine Type Briggs & Stratton Kohler Engine Power – hp (kW) at 15.5 (10.4) 15 (11.5) Maximum RPM Governed RPM (May be 3400 3375 different from maximum RPM) Speed Forward Max. – m.p.h (km/h) 6 (9.6) Reverse Max.
This warranty gives you specific legal rights, and you may also have other rights which vary from state to state. Form: ALW2-122002 2-Year Limited Warranty GT and GLT Tractors, ZT Mower, PRO 21 Mower, String Gravely Division of Ariens Company Trimmer and Gravely at Home products GB - 26...