U-Line 95 Icemaker Service And Parts Manual page 27

Water line leaking at solenoid valve outlet
Water line leaking at fill tube
Defrost drain line not in drain pan
Crack in water line
13. Water leak (inside unit)
Cause
Ice maker assembly fill cup obstructed
Fill ice cup and fill tube out of alignment
Water level too high
Defrost drain plugged
14. Excessive frost build-up
Cause
Door gasket not sealing properly
Door out of alignment
Water soaked cabinet insulation
Light stays on when door is closed
15. Noisy
Cause
Copper refrigeration tube touching cabinet
Fan blade touching shroud
Fan blade obstruction (wiring, foam
insulation, packaging material)
16. Ice build-up in drain trough or drainage problem (see page 20)
Cause
Obstructed drain cup or tube
Evaporator not touching drain trough
drain
Kinked drain tube
Drain trough spout and drain cup
not aligned
17. Unit will not defrost
Cause
Bypass valve bent (will not operate)
bly
Bypass coil defective
Defrost timer defective
Bypass valve defective
18. Fresh food temperature too cold
Cause
Ice bucket not fully inserted
Temperature control set too cold
Air leak at evaporator cover
assembly
Replace water line
Remedy
Adjust water level
Remedy
(factory repair only)
Remedy
Remedy
trough along entire length
Reroute drain tube
Remedy
Replace bypass valve
Remedy
(counterclockwise)
Replace water line and fitting
Tighten clamp or fill tube replace fill tube
Position drain line in drain pan
Remove obstruction.
Align fill tube and fill cup
Ice in drain trough (refer to #16)
Adjust door hinges or replace door gasket
Adjust door hinges
Replace foamed cabinet assembly
Repair or adjust light bracket
Carefully adjust tubing
Adjust fan mounting or shroud
Remove obstruction
Clear obstruction
Reposition evaporator to contact
Align drain trough and drain cup
Align bypass valve and coil assem-
Replace defrost timer
Replace bypass valve
Push ice bucket in place
Adjust control to warmer setting
Seal cover with RTV
27