True North TN20 Installation And Operating Instructions Manual
Hide thumbs
Also See for TN20:
- Installation and operating instructions manual (20 pages) ,
- Installation and operating instructions manual (28 pages) ,
- Installation and operating instructions manual (28 pages)
Table of Contents
Advertisement
IMPORTANT:
THESE INSTRUCTIONS ARE TO
REMAIN WITH THE HOMEOWNER
SAVE THESE INSTRUCTIONS
SAFETY NOTICE: If this stove is not properly
installed, a house fire may result. For your
safety, follow the installation instructions.
Contact local building or fire officials about
restrictions and installation inspection re-
quirements in your area.
TESTED and LISTED to CAN/ULC S627
AND UL 1482
Meets the Environmental Protection Agency's
May 2015 Particulate Emission Standards
140515-20
INSTALLATION
A N D
INSTRUCTIONS
MODEL: TN20
SERIES: A
TN20
SERIAL #
O P E R AT I N G
5055.552-A
Advertisement
Table of Contents
Related Manuals for True North TN20
Summary of Contents for True North TN20
- Page 1 Contact local building or fire officials about restrictions and installation inspection re- INSTRUCTIONS quirements in your area. TESTED and LISTED to CAN/ULC S627 AND UL 1482 MODEL: TN20 Meets the Environmental Protection Agency's May 2015 Particulate Emission Standards SERIES: A 140515-20 TN20...
-
Page 2: Table Of Contents
Label ....................23 PLEASE SAVE THESE INSTRUCTIONS This manual describes the installation and operation of the True North, TN20 Freestanding wood heater. This heater meets the 2015 U.S. Environmental Protection Agency's crib wood emission limits for wood heaters sold after May 15, 2015. -
Page 3: Safety And Maintenance
This heavy deposit is building up at least as quickly in the chimney. 4. DOOR GASKETS - The gasket used for the True North (5/8"(16mm) medium density fiberglass rope) requires only light pressure to seal. This will prolong seal life. It is important that the door seal be maintained in good condition. -
Page 4: Maintenance Checks
- Replace the baffle tubes if they have cracking or breakage. - Please contact your Dealer if you experience any of the damage listed above. Continuing to operate your stove with broken parts may accelerate damage to other parts and may void your warranty TN20 140515-20... -
Page 5: Chimney Smoke And Creosote Formation
Chimney fires are easy to detect; they usually involve one or more of the following: -Flames and sparks shooting out of the top of the chimney -A roaring sound -Vibration of the chimney TN20 140515-20... -
Page 6: Operation
3. Ignite the paper and leave the door ajar approimately Your True North heater is designed for maximum overall 1/2"(13mm) - 1"(25mm) until the wood kindling is fully efficiency at a moderate firing rate. Overfiring is hazardous engulfed in flame. -
Page 7: Restarting After Extended Or Overnight Burns
If the ashes are disposed of by burial in soil or otherwise locally dispersed, they should be retained in closed container until all cinders have thoroughly cooled. Other waste should not be placed in this container. TN20 140515-20... -
Page 8: Stove Dimensions
203mm 21 1/2" 21 1/2" 549mm 549mm 3" Alcove: Min. Height 7 1/2' 76mm Max. Depth 3' 11" 5" Double Wall Connector - Mobile Home 279mm 127mm 3" 15" 76mm 8" 381mm 203mm 3" 21 1/2" 76mm 549mm TN20 140515-20... -
Page 9: Residential
5. Install the remaining lengths of pipe one on top of the other to the finished height of the chimney connector 3. Alternately, for close clearances, use a listed double- and secure to each other. wall connector. See Figure #1, page 8. TN20 140515-20... -
Page 10: Baffle Installation
4. Grasp the right half of the baffle board the slide over to baffle board. the left. 7. Push baffle board tight against the rear of the firebox. 5. Tilt the back of the board up and guide it down and through the door opening. TN20 140515-20... -
Page 11: Through Wall Installations
Supports shall be securely fastened to wall surfaces on all sides and shall be sized to fit and hold chimney section. Fasteners used to secure chimney section shall not penetrate chimney flue liner. Clearance: 2 in. (51 mm) TN20 140515-20... -
Page 12: Mobile Home Installation
Consult your chimney supplier for installation advice. Procedure: WARNING: THE STRUCTURAL INTEGRITY OF THE MOBILE HOME FLOOR, WALL AND CEILING/ROOF MUST BE MAINTAINED. Note: See "Combustion Air" section on page 14. TN20 140515-20... - Page 13 (1219 mm) Non-combustible floor protector Hooded vent or 90 elbow turned down * 4"(100mm) diameter air inlet with rodent screen * If the crawl space is well ventilated it is not necessary to extend air inlet to outside TN20 140515-20...
-
Page 14: Ember Protector
During extremely cold weather, and especially when burning at very slow rates, the upper parts of the exposed chimney may ice up, partially blocking the flue gases. If blockage occurs, flue gases may enter living space. TN20 140515-20... -
Page 15: Optional Blower
Proper blower speed matched with air control setting will ensure peak performance from your stove. Operate as follows: - Except on "High" setting, wait 30 minutes before turning on blower to desired setting. FIG. #7 ELECTRICAL RATING 115V, 60Hz, 0.5A SPEED CONTROL BLOWER POWER CORD TN20 140515-20... -
Page 16: Firebrick Installation
3) Finally install the last 4 firebricks by inserting the side brick under the retaining flange and then the bottom brick under the.side brick and lay it down. FIG. #10 REAR FRONT TN20 140515-20... -
Page 17: Troubleshooting
1. Combustion air supply blocked - Check outside air supply for obstruction - Check that room air cover is removed 2. Draft too low - Chimney plugged or restricted, inspect and clean - Chimney oversized or otherwise unsuitable, consult Dealer TN20 140515-20... -
Page 18: Replacement Parts
DESCRIPTION PART NO. 1.... Side Shield Kit, Set L&R, ....TRNO.20SSA All parts may be ordered from your nearest True North dealer. 2..Baffle Board (2pcs.) ........TRNO.BAFF Contact True North for the location of the dealer nearest you. 3.... Baffle Tube Set(4pcs.) ....TRNO.50001101 4.... -
Page 19: Warranty Information
(dated, bill of sale), model name and serial number must be supplied when making any warranty claim to your TRUE NORTH Dealer. This warranty covers brand new products only, which have not been altered, modified nor repaired since shipment from factory. This warranty applies to normal residential use only. - Page 20 TN20 140515-20...
- Page 21 TN20 140515-20...
- Page 22 TN20 140515-20...
-
Page 23: Label
Label LOCATED ON BACK OF STOVE MUR COTE MUR ADJACENT SIDE WALL ADJACENT WALL COTE SIDE TN20 140515-20... - Page 24 PACIFIC ENERGY FIREPLACE PRODUCTS LTD. 2975 Allenby Rd., Duncan, B.C. V9L 6V8 For technical support, please contact your retailer. Web site: http://www.pacificenergy.net Printed in Canada...
Need help?
Do you have a question about the TN20 and is the answer not in the manual?
Questions and answers