Atwood hydro flame 8900-III series Information Manual

1120 North Main Street • Elkhart, IN 46514
USA : 800-546-8759 Canada & USA : 800-825-4328
Internet: http://www.atwoodmobile.com
English, Français (ET Canada)
Should you require further information, contact your dealer or nearest
Atwood Mobile Products Service Center.
Follow this instruction to insure safe operation of the furnace.
This book contains instructions covering the operation and
maintenance of your furnace. Keep with unit at all times.
TO THE INSTALLER: LEAVE THIS MANUAL WITH THE
APPLIANCE.
TO THE CONSUMER: RETAIN THIS MANUAL FOR
"FOR COMPLETE INSTALLATION INSTRUCTION REFER TO THE
FUTURE REFERENCE.
INSTALLATION OWNER'S MANUAL"
LOCATION AND PHONE NUMBERS QUALIFIED SERVICE CENTERS
• Website http://www.atwoodmobile.com
• Call 866-869-31181 for Atwood Service Center List
INDEX
OPERATING INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . .
MAINTENANCE AND CLEANING . . . . . . . . . . . . . . . . . . . . .
SERVICING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GAS CONVERSION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
VALVE CONVERSION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ORIFICE REPLACEMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ANNUAL PREVENTATIVE MAINTENANCE INSPECTION
WARRANTY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
FURNACE EXTENDED SERVICE CONTRACT . . . . . . . . . .
TERM AND PROVISIONS: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
EXCLUSIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
LIMITATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
EXTENDED SERVICE ORDER FORM . . . . . . . . . . . . . . . . . .
FOR YOUR SAFETY READ ALL INFORMATION
BEFORE OPERATING FURNACE
SAFETY SYMBOLS
SAFETY ALERT SYMBOLS
Safety symbols alerting you to potential personal safety hazards.
Obey all safety messages following these symbols.
WARNING
Avoid possible
injury or death
Installation of this appliance must be made in accordance
with the written instructions provided in this manual. No
agent, representative or employee of Atwood or other
person has the authority to change, modify or waive any
provision of the instructions contained in this manual.
CAUTION
Avoid possible injury and/or
property damage
WARNING
™
DO NOT touch exterior exhaust grills, when furnace is
•
operating.
Supervise young children in the same room as the
•
furnace.
Improper installation, adjustment, alteration, service or
maintenance can cause property damage, personal injury or
loss of life. Refer to the installation instructions and/or
owners manual provided with this appliance.
2
3
3
Be sure the furnace and all ignition systems are "OFF"
during any type of refueling and while vehicle is in motion or
4
4 being towed.
.
5
6
6
6
If information in this manual is not followed exactly, a fire or
6
explosion may result causing property damage, personal
7
injury or loss of life.
BEFORE OPERATING FURNACE, smell all around appliance area for
gas and check fitting with a soapy water solution. Be sure to smell next
to floor because some gas is heavier than air and will settle near floor.
This appliance does not have a pilot. It is equipped with an ignition
device which automatically lights the burner. DO NOT try to light the
burner by hand.
Use only your hand to turn a gas control valve. Never use tools. If the
valve will not turn by hand, don't try to repair it. Call a qualified Service
Technician. Forcing or attempting to repair may result in a fire or
explosion.
Do not use the appliance if any part has been under water,
immediately call a qualified Service Technician to inspect the appliance
and to replace any part of control system and any gas control which
has been under water.
Your furnace should be inspected by a qualified service agency
yearly before turning the furnace on. Particular attention should be
given to the following items.
Literature number 30093
SERIES 7900-II, 8012-II,
™
Series User's Information Manual
CAUTION
PERSONAL INJURY
WARNING
WARNING
FIRE OR EXPLOSION
WARNING
FIRE OR EXPLOSION
WARNING
POSSIBLE INJURY OR DEATH
hydro flame™
Furnace Models
SERIES 8500-IV
SERIES 8900-III
Effective 10/10