Front Cast Removal; Glass Door Installation And Removal; Glass / Door Replacement - Napoleon GDS60N Installation And Operating Instrictions

5.3

FRONT CAST REMOVAL

5.3.1 Lift the top casting off the unit.
5.3.2 Loosen the securing bolts on the cast front (located at either side on the top). Lift up and out.
5.3.3 To install the front, repeat in reverse order.
5.4

GLASS DOOR INSTALLATION AND REMOVAL

When installing the glass door, a simple procedure must be followed in order to not damage the door.
5.4.1 Lift the top casting off.
5.4.2 Lift the cast front out of its retainers (located at either side on the top).
5.4.3 Open the valve control cover. Pull the latch handles forward to release. The door may now be safely
removed by swinging the bottom out and lifting it off. To install the door, repeat in reverse order.
The return fl ange must fi t over the top of the ridge so that it rests on top of the fi rebox.
The 'T' latch portion is threaded and can be loosened or tightened to adjust for an effective door seal.
Care must be taken when re-installing the door to ensure that the gasket at the top of the door does
not bunch.
5.5

GLASS / DOOR REPLACEMENT

CARE MUST BE TAKEN WHEN REMOVING AND DISPOSING OF ANY BROKEN GLASS OR
DAMAGED COMPONENTS. BE SURE TO VACUUM UP ANY BROKEN GLASS FROM INSIDE THE
5.5.1 Place the door frame face down careful not to scratch the paint.
5.5.2 Center the gasketed glass inside the door frame with the thick
side of the gasket facing up.
5.5.3 Bend the glass retainers located along the edge of the door
frame over the gasket holding the glass in place. Be careful not
to break the glass.
NorthlineExpress.com
!
DO NOT USE SUBSTITUTE MATERIALS.
GLASS MAY BE HOT, DO NOT TOUCH GLASS UNTIL COOLED.
APPLIANCE BEFORE OPERATION.
http://www.northlineexpress.com
LATCH
WARNING
GASKET
GLASS
RETAINER
33
RETURN
FLANGE
RIDGE
GLASS
DOOR FRAME
W415-0788 / 05.15.09
Toll-Free 1-866-667-8454