Towing A Trailer - Volvo 760 GLE Turbo 1986 Manual

1986 Volvo 760 GLE, Turbo
When preparing for trailer hauling, observe the following:
Use a trailer hitch which meets Federal Safety Standards for rear end collisions (FMVSS 301-75). For
trailer weights exceeding 2000 lbs (908 kgs) use only a trailer hitch offered as a Genuine Volvo
Accessory.
Note: Models with automatic transmission are equipped with a transmission oil cooler as standard
equipment. This cooler helps prevent overheating of the transmission during times of increased load, as
when towing a trailer.
Maximum trailer weight recommended by Volvo is 3,300 lbs (1,500 kgs). Observe legal requirements
of the state in which the vehicles are registered.
All Volvo models are equipped with energy-absorbing shock-mounted bumpers. Trailer hitch
installation should not interfere with the proper operation of this bumper system.
WARNING!
Bumper-attached trailer hitches must not be used on Volvos, nor should safety chains be attached to
the bumper.
Trailer hitches attaching to the vehicle rear axle must not be used.
Note: Never connect a trailer's hydraulic brake system directly to the vehicle brake system, nor a trailer's
lighting system directly to the vehicle lighting system. Consult your nearest authorized Volvo dealer for
correct installation. Trailer towing does not normally present any particular problems, but take into
consideration:
The rear suspension incorporates "Nivomat®", an automatic level regulating system to compensate for
load variations. The system operates when the vehicle is in motion. The rear of the vehicle will however
droop if for instance you are carrying a lot of luggage in the trunk or if the vehicle is hitched to a trailer;
but as soon as you start driving, the "Nivomat®" system will raise the rear of the vehicle to the most
suitable level.
Recommended hitch tongue load is 110 lbs (50 kgs) for trailer weights below 2,650 lbs (1,200 kgs)
and 143-154 lbs (65-70 kgs) for trailer weights above 2,650 lbs (1,200 kgs). However, the hitch tongue
load should not exceed 200 lbs (90 kgs).
For trailer weights between 2,650-3,300 lbs (1,200-1,500 kgs) a top speed of 50 mph (80 km/h)
should never be exceeded.
Engine and transmission are subject to increased loads. Therefore, engine coolant temperature should
be closely watched when driving in hot climates or hilly terrain. Use lower gear and turn off air
conditioner if temperature gauge pointer enters the red range.
Disengage the overdrive ("
Avoid overload and other abusive operation.
Hauling a trailer affects handling, durability, and economy. A trailer air dam (Volvo accessory) will
often improve mileage.
It is necessary to balance trailer brakes with the towing vehicle brakes to provide a safe stop (check
and observe State/Local regulations).
file:///K|/ownersdocs/1986/1986_760_GLE_Turbo/86760_03.htm (17 of 20)12/30/2006 7:52:32 AM
" light goes on) on models with automatic transmission.