Explanation Of Symbols And Safety Information; Guideline To Symbols; Safety Instructions - Buderus Logamax plus GB162-L.B. 80 kW Installation Instructions Manual

12.3 Clean the heat exchanger, burner and
condensate trap . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
12.3.1 Remove the gas valve . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
12.3.2 Remove the burner cover with the fan and the
gas valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
12.3.3 Remove the burner and the burner seal . . . . . . . . . . . . 45
12.3.4 Checking ignition unit . . . . . . . . . . . . . . . . . . . . . . . . . . 45
12.3.5 Disconnect the condensate trap . . . . . . . . . . . . . . . . . . 46
12.3.6 Remove the condensate collector . . . . . . . . . . . . . . . . . 46
12.3.7 Clean the heat exchanger . . . . . . . . . . . . . . . . . . . . . . . 47
12.4 Check and adjust the flue gases CO
12.5 Function check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
13 Display information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
13.1 Removing the control panel . . . . . . . . . . . . . . . . . . . . . . 48
13.2 Replacing the control panel . . . . . . . . . . . . . . . . . . . . . . 48
13.3 BC10 Display readings . . . . . . . . . . . . . . . . . . . . . . . . . 48
13.4 BC10 Display settings . . . . . . . . . . . . . . . . . . . . . . . . . . 48
13.5 BC10 Display codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
14 Technical specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
14.1 Technical specifications of GB162-boilers at
low BTU (4,000-10,200 ft.) . . . . . . . . . . . . . . . . . . . . 54
15 Reports . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
15.1 Start-up report . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
15.2 Inspection report . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
15.3 Service report . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
16 Spare parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
Logamax plus GB162-L.B. 80 kW / 100 kW - 6720645916 (2014/10)
1
1.1
Warnings
emissions . . . . . 47
2
Signal words at the beginning of a warning are used to indicate the type
and seriousness of the ensuing risk if measures for minimizing damage
are not taken.
• NOTE indicates that damage to property may occur.
• CAUTION indicates possible minor to medium personal injury.
• WARNING indicates possible severe personal injury.
• DANGER indicates a potential for loss of life.
Important Information
Additional symbols
Symbol
▶

•
-
Table 1
1.2
Installation and service must be performed by a qualified installer,
service agency or the gas supplier.
▶ Do not store or use gasoline or other flammable vapors and liquids in

Explanation of symbols and safety information

Explanation of symbols and safety information

Guideline to symbols

Warnings are indicated in the text by a warning triangle
and a gray background.
In case of danger from electric shock, the exclamation
point on the warning triangle is replaced with a flash.
Important information neither indicating personal injury
nor damage to property are marked with this symbol.
They are separated by lines above and below the text.
Explanation
Sequence of steps
Cross-reference to other points in this document or to
other documents
Listing/list entry
Listing/list entry (2nd level)

Safety instructions

WARNING:
A fire or explosion may result causing property damage,
personal injury or death.
▶ If the information in these instructions is not followed
exactly,
DANGER:
if flammable gas explodes.
▶ Beware if you smell gas: there may be an explosion
hazard!
the vicinity of this or any other boiler.
1
5