Maintenance Schedule; Every Ride; Every Month - Stealth bomber Owner's Manual

MAINTENANCE SCHEDULE

Your Stealth Bike should be cared for and maintained according to the following schedule
assistance if required.
WARNING: Many Stealth service and repair tasks require special knowledge and tools. Do not begin any adjustments or
service on your bike until you have learned from your dealer how to properly complete them. Improper adjustment or
service may result in damage to the bike or in an accident which can cause serious injury or death.

EVERY RIDE

Upon returning from each ride, perform the following checks and repairs.
1. Wipe down your bike and remove excess moisture from mainframe and hub motor. This is essential in maintaining
the electrical system of your bike.
CAUTION: Washing your bike with high pressure could result in water damage to the electrical system. This will void
your warranty.
2. Charge battery. REFER to Charging procedure pg. 12.
3. Wipe down stanchion tubes. Failure to keep these clean could result in oil loss and damage to your forks.
4. Check suspension fork bolts and clamps to ensure they are correctly secured.
5. Lubricate the chain especially after off road riding. (Silicone based chain lube is preferred).
6. Check the brakes for proper operation.

EVERY MONTH

1. Check the tyre pressures and wheels. Replace any damaged components.
2. Ensure that steering head bearings, handlebars and associated bolts are tight.
3. Check the seat and seat post alignment and fasteners.
4. Ensure there is no fouling or excessive wear of wires and cables on the controls.
5. Check the frame for damage. High force loads can damage frame components.
6. Check for loose spokes and replace if necessary.
7. Spray CRC 5.56 through breather hole of motor for 2 full rotations of wheel. Spin wheel by hand 10-15 rotations.
NOTE: Visually inspect brake pad thickness periodically for wear. Pads should be
replaced when pad thickness is less than 0.5mm.
STEALTH ELECTRIC BIKES 2013 OWNER'S MANUAL
.
Refer to your dealer for
B
V 1.2 PAGE | 28